PIONEER Service Manual. A subscription to, or additional copies Also test with plug reversed of, PIONEER Ser vice Manual may be obtained at a (Using AC adapter Earth nominal charge from PIONEER. plug as required)
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. VSX-516-K...
For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 2.1 PACKING VSX-516-K/MYXJ5 VSX-516-S/MYXJ5 VSX-516-S/MVXJ5 ONLY...
See Contrast table(2) (Dutch/Spanish) Operating Instructions See Contrast table(2) (French/German) Remote control See Contrast table(2) (2) CONTRAST TABLE VSX-516-S/KUCXJ, VSX-516-K/MYXJ5, VSX-516-S/MYXJ5, VSX-516-S/MVXJ5 and VSX-516-K/KUCXJ are con- stracted the same except for the following: VSX-516-K VSX-516-S VSX-516-K VSX-516-S VSX-516-S Mark No.
2.2 EXTERIOR SECTION VSX-516-K/MYXJ5 VSX-516-S/MYXJ5 VSX-516-S/MVXJ5 ONLY VSX-516-K/MYXJ5 VSX-516-S/MYXJ5 VSX-516-S/MVXJ5 ONLY VSX-516-K/KUCXJ VSX-516-K/KUCXJ VSX-516-S/KUCXJ VSX-516-S/KUCXJ ONLY ONLY VSX-516-K/MYXJ5 VSX-516-S/MYXJ5 VSX-516-S/MVXJ5 ONLY VSX-516-K/MYXJ5 VSX-516-S/MYXJ5 VSX-516-S/MVXJ5 ONLY Refer to "2.3 FRONT PANEL SECTION" VSX-516-K/MYXJ5 VSX-516-S/MYXJ5 VSX-516-S/MVXJ5 ONLY Cleaning paper GED-008 VSX-516-K/MYXJ5 VSX-516-S/MYXJ5...
Page 9
BBZ40P080FNI 11P F. F. C/30V XDD3189 19P F. F. C/30V XDD3190 Screw See Contrast table(2) (2) CONTRAST TABLE VSX-516-S/KUCXJ, VSX-516-K/MYXJ5, VSX-516-S/MYXJ5, VSX-516-S/MVXJ5 and VSX-516-K/KUCXJ are con- stracted the same except for the following: VSX-516-K VSX-516-S VSX-516-K VSX-516-S VSX-516-S Mark Symbol and Description...
2.3 FRONT PANEL SECTION 18(2/2) 18(1/2) VSX-516-K/MYXJ5 VSX-516-S/MYXJ5 VSX-516-S/MVXJ5 ONLY VSX-516-K/MYXJ5 VSX-516-S/MYXJ5 VSX-516-S/MVXJ5 ONLY No. 18 (2/2) VSX-516-K...
Page 11
SUB BTN See Contrast table(2) FUNC BTN See Contrast table(2) LISTEN BTN See Contrast table(2) (2) CONTRAST TABLE VSX-516-S/KUCXJ, VSX-516-K/MYXJ5, VSX-516-S/MYXJ5, VSX-516-S/MVXJ5 and VSX-516-K/KUCXJ are con- stracted the same except for the following: VSX-516-K VSX-516-S VSX-516-K VSX-516-S VSX-516-S Mark No.
CN601 IC851 PDC121A8 IC401 8 bit Serial ROM F2602E-01 XM RADIO XMDT MYXJ5, MVXJ5 ONLY COAX1 DSP ASSY COAX2 5.1CHIN ASSY CN307 CN105 SL/SR KUCXJ ONLY IC551 TC74HC4052AF COMPO SEL IC552 TC74HC4052AF COMPO SEL IC553 NJM2581M DRIVER COMPONENT ASSY VSX-516-K...
Page 13
(SBL/SBR/SB) KUCXJ: IC603 MYXJ5, MVXJ5: IC600 POWER PACK 30dB KUCXJ: SBL/SBR RY501 MYXJ5, MVXJ5: SB IC312 Q501 A. MUTE VIDEO ASSY IC301 NJM2595M COMPOSITE SEL CN111 CN816 TV/SAT SW PREOUT DVD/LD CN803 CN302 Q303 A. MUTE VCR REC MONITOR VSX-516-K...
Symbol In PCB Symbol In Schematic Part Name Diagrams Diagrams C E B Capacitor Connector Transistor B C E SIDE A Transistor with resistor B C E Field effect SIDE B P.C.Board Chip Part transistor Resistor array 3-terminal regulator VSX-516-K...
REG B FL AC2 R1251 FL AC1 C1251 AC RY C1252 IC851 BLUE BROWN AC WUP CN1201 GNDU STBY CN1201 CMKM-P3X TRAN 1 ASSY XWZ 4078 (XNP3101-C) (XNP3100-C) TRANS2 ASSY TRANS1 ASSY D E O V D E O V VSX-516-K...
Page 57
REG B FL AC2 CAUTION FL AC1 REPLACE IC LINKS AS AC RY AS MARKED. MFD. BY LITTLEFUSE INC. AC WUP GNDU PRIMARY STBY CN1201 CMKM-P3X TRANS1 ASSY XWZ3958 CN1201 (XNP3101-C) (XNP3100-C) D E O V D E O V VSX-516-K...
C816 C819 C806 XWZ 4129 TA7805S R802 PRINTED TA7812S TA79012S SIDE PRINTED PRINTED PRINTED SIDE SIDE SIDE TA7805S IC801 IC802 IC803 IC807 D810 D813 (XNP3100-C) (XNP3100-C) SIDE B SIDE B DIGITAL IN ASSY REGULATOR ASSY (XNP3100-C) CN800 (XNP3100-C) CN1903 VSX-516-K...
Not used LE25FW106M Q801 Not used UN5212 L851 CHIP SOLID INDUCTOR Not used QTL1013 R820 RS1/16S0R0J Not used R821, R853 Not used RS1/16S0R0J R828–R830, R851 Not used RS1/16S470J R855–R857 Not used RS1/16S103J C851 Not used CCSRCH471J50 C852 Not used CKSRYB104K16 VSX-516-K...
IC 103 (A,198,72) OP-AMP IC HA17558AF J 41 JUMPER WIRE D15A03-100-2651 IC 104 (A,198,56) OP-AMP IC HA17558AF J 42 JUMPER WIRE D15A07-125-2651 IC 105 (A,198,87) OP-AMP IC HA17558AF IC 106 (A,198,41) OP-AMP IC HA17558AF IC 107 (A,216,88) OP-AMP IC HA17558AF VSX-516-K...
Page 72
RS1/16S104J R 307 (B,165,68) RS1/16S101J R 508 (A,162,82) RS1/16S272J R 308 (B,171,72) RS1/16S101J R 509 (A,162,96) RS1/16S272J R 311 (A,258,102) METAL OXIDE RESISTOR RS1LMF101J R 512 (A,159,83) RS1/16S102J R 312 (A,266,102) METAL OXIDE RESISTOR RS1LMF101J R 513 (A,159,96) RS1/16S102J VSX-516-K...
Page 73
C 122 (A,280,25) CEAT100M50 C 246 (A,194,74) CCSRCH331J50 C 125 (A,280,62) CEAT100M50 C 247 (B,193,69) CCSRCH331J50 C 126 (A,280,53) CEAT100M50 C 248 (B,193,75) CCSRCH331J50 C 127 (A,280,47) CEAT100M50 C 249 (A,205,69) CEAT100M50 C 128 (A,280,40) CEAT100M50 C 250 (A,205,75) CEAT100M50 VSX-516-K...
Page 74
Q 255 (A,75,98) TRANSISTOR 2SC4081 C 363 (A,139,68) CCSRCH101J50 Q 256 (A,75,94) CHIP TRANSISTOR 2SD2704K C 364 (A,139,84) CKSRYB472K50 Q 257 (A,78,108) TRANSISTOR 2SA1576A C 365 (A,136,73) ELECT. CAPACITOR CEAT220M50 Q 259 (A,69,97) DIGITAL TR(SC-70) RT1P241M C 366 (A,136,80) ELECT. CAPACITOR CEANP4R7M50 VSX-516-K...
Page 75
R 103 (B,283,62) RS1/16S222J R 245 (B,188,69) RS1/16S332J R 104 (B,283,52) RS1/16S222J R 246 (B,188,75) RS1/16S332J R 105 (B,283,47) RS1/16S331J R 247 (B,190,69) RS1/16S332J R 106 (B,293,40) RS1/16S331J R 248 (B,190,75) RS1/16S332J R 107 (B,283,87) RS1/16S331J R 249 (B,197,69) RS1/16S332J VSX-516-K...
Page 76
RS1/16S223J R 9007(B,93,89) RS1/16S474J R 446 (A,74,233) RS1/16S104J R 9008(A,86,90) RS1/16S221J R 447 (A,88,94) RS1/16S472J R 9009(A,65,85) RS1/16S473J R 448 (A,89,104) RS1/16S104J R 9010(B,115,45) RS1/16S512J R 449 (A,80,108) RS1/16S102J R 9011(A,63,76) RS1/16S102J R 453 (A,146,35) RS1/16S102J R 9012(A,63,73) RS1/16S0R0J VSX-516-K...
Page 77
C 122 (A,280,25) CEAT100M50 C 214 (A,223,90) CEAT100M50 C 125 (A,280,62) CEAT100M50 C 215 (B,233,84) CKSRYB103K50 C 126 (A,280,53) CEAT100M50 C 216 (B,231,89) CKSRYB103K50 C 127 (A,280,47) CEAT100M50 C 217 (A,202,85) CKSRYB103K50 C 128 (A,280,40) CEAT100M50 C 218 (A,202,90) CKSRYB103K50 VSX-516-K...
Page 78
LM1117DT-ADJ C 343 (A,149,51) CCSRCH101J50 IC 952 (B,19,48) OCTAL BUS BUFFER IC TC74VHCT244AFTS1 C 344 (A,150,66) CCSRCH101J50 D 701 (A,79,33) DIODE DAP202K C 345 (A,145,56) ELECT. CAPACITOR CEAT220M50 D 702 (B,80,32) DIODE DAN202K C 346 (A,145,63) ELECT. CAPACITOR CEAT220M50 VSX-516-K...
Page 79
R 577 (B,93,61) RS1/16S104J R 819 (B,38,49) RS1/16S101J R 579 (A,96,58) RS1/16S0R0J R 820 (B,35,43) RS1/16S0R0J R 601 (A,110,57) RS1/16S0R0J R 822 (B,42,44) RS1/16S103J R 602 (A,109,57) RS1/16S0R0J R 823 (B,43,50) RS1/16S473J R 603 (A,107,57) RS1/16S0R0J R 827 (B,51,51) RS1/16S470J VSX-516-K...
Page 80
C 617 (B,117,42) CKSRYB102K50 C 909 (A,96,34) CEVW101M16 C 618 (A,121,45) CEVW470M6R3 C 916 (B,67,47) CCSRCH471J50 C 619 (A,116,48) CKSRYB104K16 C 917 (B,69,47) CKSRYB103K50 C 620 (A,114,48) CCSRCH471J50 C 918 (B,79,49) CKSRYB104K16 C 621 (A,114,51) CKSRYB474K10 C 919 (B,80,49) CCSRCH471J50 VSX-516-K...
Page 81
RS1/16S103J D 647 (A,200,17) ZENER DIODE MTZJ15A R 609 (A,91,35) RD1/4PU273J D 648 (A,196,21) ZENER DIODE MTZJ15A R 610 (A,225,35) RD1/4PU273J D 651 (A,192,57) DIODE 1SS133 R 611 (A,90,28) RD1/4PU821J D 652 (A,262,57) DIODE 1SS133 R 612 (A,223,28) RD1/4PU821J VSX-516-K...
Page 82
R 691 (A,55,55) RESISTOR (0.22, 5W) ACN7094 R 885 (B,310,57) RS1/16S221J R 692 (A,70,72) RD1/4PU182J R 886 (B,310,61) RS1/16S221J R 693 (A,67,77) RD1/4PU821J R 887 (B,310,65) RS1/16S221J R 694 (A,62,72) RD1/4PU223J R 888 (B,315,22) RS1/16S221J R 695 (A,97,22) RD1/4PU333J R 1101(B,273,68) RS1/16S0R0J VSX-516-K...
Page 84
R 651 (A,164,56) RD1/4PU222J L 753 (A,120,107) COIL ATH1004 R 652 (A,215,41) RD1/4PU222J L 761 (A,130,108) COIL ATH1004 R 653 (B,160,50) RS1/16S103J L 762 (A,142,108) COIL ATH1004 R 654 (B,219,46) RS1/16S103J J 43 JUMPER WIRE 11P D20PYY1120E R 659 (A,159,35) RD1/4PU273J VSX-516-K...
Page 85
C 662 (B,241,27) CCSRCH470J50 R 781 (A,87,30) RD1/4PU273J C 663 (B,184,27) CCSRCH470J50 R 782 (A,84,22) RD1/4PU821J C 664 (B,241,24) CCSRCH470J50 R 783 (A,104,21) RD1/4PU273J R 784 (A,111,35) RD1/4PU331J C 665 (A,184,45) CEANP2R2M50 > R 785 (A,105,31) RESISTOR (0.22, 5W) ACN7094 VSX-516-K...
Page 86
851 (A,49,207) 11P CABLE HOLDER 51048-1100 Q 1551(B,78,211) CHIP TRANSISTOR 2SD2704K Q 1552(B,102,219) CHIP TRANSISTOR 2SD2704K J 47 JUMPER WIRE D20PYY0640E TRANS3 ASSY JA 1551(A,117,233) HEADPHONE JACK RKB1014 KN1551(A,69,231) WRAPPING TERMINAL VNF1084 TRANS3 ASSY has no service part. 1551(A,59,220) 6P CABLE HOLDER 51048-0600 VSX-516-K...
Page 87
IC 402 (A,223,169) REMOTE RECEIVER UNITGP1UM27XK0VF R 455 (A,45,146) RD1/4PU681J Q 442 (B,238,190) TRANSISTOR RT1N241M R 456 (A,35,144) RD1/4PU821J Q 484 (B,217,189) TRANSISTOR 2SA1576A R 457 (A,16,139) RD1/4PU122J D 401 (B,239,163) DIODE DAN202K R 459 (A,109,134) RD1/4PU472J R 460 (A,101,135) RD1/4PU681J VSX-516-K...
Page 88
C 403 (A,234,168) CEAT221M6R3 C 891 (A,97,218) ELECT. CAPACITOR CEAT471M35 C 410 (B,49,186) CKSRYB103K50 C 892 (A,86,218) ELECT. CAPACITOR CEAT471M35 C 411 (B,51,186) CKSRYB103K50 C 412 (A,42,178) CEAT470M50 REGULATOR ASSY C 418 (B,141,179) CKSRYB104K16 C 419 (B,103,182) CKSRYB103K50 MISCELLANEOUS VSX-516-K...
55 (A,317,9) 4P CABLE HOLDER 51048-0400 R 391 (B,20,38) RS1/16S0R0J R 392 (B,30,55) RS1/16S0R0J RESISTORS > R 51 (A,318,37) RESISTOR(2.2M, 1/2W) RCN1080 CAPACITORS R 52 (A,275,11) RD1/2PM270J C 302 (B,22,44) CKSRYB103K50 R 53 (A,307,12) RD1/4PU332J C 304 (B,33,19) CKSRYB221K50 R 54 (A,319,16) RD1/4PU103J VSX-516-K...
Page 90
C 706 (A,47,44) CCSRCH471J50 R 711 (B,37,42) RS1/16S472J C 707 (A,45,51) CKSRYB104K16 C 708 (A,45,50) CCSRCH471J50 R 712 (A,27,43) RS1/16S475J C 709 (A,30,51) CKSRYB104K16 R 717 (A,31,29) RS1/16S473J C 710 (A,30,50) CCSRCH471J50 R 718 (A,36,25) RS1/16S101J R 719 (A,35,25) RS1/16S101J VSX-516-K...
There is no information to be shown in this chapter. IC 951 (B,55,57) OP-AMP IC HA17558AF D 951 (B,73,69) DIODE UDZS5R1(B) D 952 (A,38,107) DIODE UDZS5R1(B) D 953 (A,36,107) DIODE UDZS5R1(B) D 957 (B,57,67) DIODE DAN217U L 970 (A,60,38) COIL ATH7015 VSX-516-K...
Cut 3 cable ties. Remove PCB holder(one screw). Note : The unit does not operate when the screws of Speaker Terminal are taken off from Rear Panel. Heat-sink caution when disassembling : The Heat-sink becomes hot; please take care. VSX-516-K...
Page 93
TRANS Assy. Note : The unit does not operate when the screws of Speaker Terminal are taken off from Rear Panel. Heat-sink caution when disassembling : The Heat-sink becomes hot; please take care. VSX-516-K...
Page 94
COMPONENT VIDEO MAIN ASSY ASSY USB IN ASSY R. ENCODER ASSY TRANS 2 ASSY PRIMARY ASSY FRONT DISPLAY POWER PACK ASSY ASSY POWER KEY ASSY TRANS 3 ASSY HP ASSY TRANS 4 NOTE : This photograph is VSX-916-S. ASSY VSX-516-K...
1W WUP P82/INT0 EVR CLK LOW_CONSUMPTION UART SW2 USB HREQ VIDEO4 USB CTL RY-AC USB XLAG iPod Sense P75/TA2IN RY_A USB XRST P74/TA2OUT RY_C/R P73/CTS2/RTS2 RY_B USCS /TA1IN/V P72/CLK2 DISP RST AMUTE /TA1OUT/V P71/RXD2/SCL2 /TA0IN P70/TXD2/SDA2 NECK SELECT /TA0OUT VSX-516-K...
Page 96
DSP ASSY DIR DO Data input signal for communication with DIR/DAC DIR CS Chip select signal for communication with DIR/DAC LSSN DSP ASSY DIR CDC RST Reset signal for DIR CODEC DIR ERR lock/unlock signal XTL0 DIR X'tal change VSX-516-K...
Page 97
1 to switch region P101/AN1 SIMUKE2 lnput 2 to switch region AVSS AVSS connects with VCC. P100/AN0 HP DET HP detection H:detected. VREF VREF connects with VCC. AVcc AVCC connects with VCC. P97/ADTRG/SIN4 USDAO data input from USB VSX-516-K...
Page 98
C-MOS P-CH FIP31/P37 DISP EN P00/INTP0 C-MOS P-CH FIP32/P40 NC(PD)(MULTIROOM SRIN) P01/INTP1 C-MOS P-CH FIP33/P41 SR IN P02/T1 C-MOS P-CH FIP34/P42 AVSS P-CH FIP35/P43 KEY IN4 ANI3 COPM P-CH FIP36/P44 KEY IN3 ANI2 COMP P-CH FIP37/P45 POWER ON LED VSX-516-K...
Page 99
Digital Precision Processing LED. H:ON, L:OFF . Only for 816KU, 816SF , 916MY, 516J P53/FIP43 P52/FIP42 P51/FIP41 P50/FIP40 P47/FIP39 P46/FIP38 FIP37/P45 POWER ON LED POWER LED output FIP36/P44 Display FIP35/P43 Display FIP34/P42 Display FIP33/P41 Display FIP32/P40 Display FIP31/P37 Display FIP30/P36 Display FIP29/P35 Display FIP28/P34 Display VSX-516-K...
Page 107
GPIO_D16 GPIO_D[16] GPIO_D17 GPIO_D[17] GPIO_D18 GPIO_D[18] GPIO_D19 GPIO_D[19] GPIO_D20 GPIO_D[20] GPIO_D21 GPIO_D[21] − VSSIO Digital ground for I/O MODE1 Mode select input 1, Pull-down for normal operation. JTAG serial data input for ARM940T JTAG test mode select for ARM940T VSX-516-K...
Page 108
Pin Function No. Pin Name Pin Function P-channel MOS FET drain OUT 1 − Ground FAULT Open-drain FAULT output GND 2 ON (ON) Enable input: 4618 active low, 4618- active high P-channel MOS FET source FAULT 3 ON (ON) VSX-516-K...
POWER PACK ASSY R726 IC9001 OL DT (U-P) DC DET Pin72 (refer 1) DC PROT Normal : +5 V Fan Stop DET. FAN abnormal Fan Stop STOP : 0 V Q253 R445 Fan - R446 Fan + -12V +12V VSX-516-K...
Page 110
Voltage supply to POWER AMP IC (VH-) Voltage supply to +12 V REGULATOR IC D+5.6V Q807(1/2) C801 2200 D801 D807 Q807(2/2) S1WB(A)60SD Q808(1/2) R807 R808 C802 Q808(2/2) R806 2200 C806 1/50 D806 MTZJ6.2B Voltage supply to -12 V REGULATOR IC VSX-516-K...
When an overload is detected, A.MUTE* is turned on, speaker relay is turned off, then "OVERLOAD" flashes on the display. ↓ The abnormality continues for 3 seconds. ↓ Continues. ↓ Recovery The power is shut off even if the The power is shut off. unit recovers. VSX-516-K...
Page 112
However, when the following keys are pushed so that the key input of a line and the service can be carried out, power can be on. 1 TESTMODE ON (A55F+A55F) 2 When power off, push FRONT ENTER key + ADVANCED SURROUND key continuously 2sec. (Effective, only when power-off is carried out by DC detection) VSX-516-K...
5) Furthermore, check the output DC voltage of each channel of power pack IC600, IC601, IC602 and IC603 to limit the failure channel and identify the defect power pack. ↓ • After identify the failure channel, check that each part is not damaged (resistor, diode... etc. value / open / short) VSX-516-K...
: USB Host control decoder (MP3/WMA/MPEG-4AAC) 16M FLASH ROM : Firmware is stored 64M SDRAM : Temporary storage area of decoding music file LOAD SWITCH : Current limitation to USB device power 2ch DAC : D/A converter for analog output VSX-516-K...
Page 115
In this state, flashing of "USB ERROR1" stops, but playback will not start. To start playback, press the USB play key again. In the above case, if overcurrent is detected again, the above procedures 1 through 4 are repeated. VSX-516-K...
Page 116
Is IC702 the voltage abnormally IC7814 (pins 14, 15) 1.8 V ? hot? Replace IC702. Check the parts and the voltage patterns in the path. The output and GND may be 5 V ? short-circuited. Check the path between them. VSX-516-K...
Page 118
L/R clock IC701 (pin 63). signal IC781 (pin 3) IC781 (pins 10,11) LOUT/ROUT DATA Is there Are there Check the output from Replace IC781. DATA signal audio signal IC701 (pin 67). Check the parts and pattern between IC781 and CN702. VSX-516-K...
Page 119
• Never change the function setting or turn the power off during the process of Steps 3 through 5. If you do, loading of the firmware will fail, and updating procedures cannot be continued. In such a case, replacement of the flash memory is required. VSX-516-K...
System Setup menu. Switches between direct and stereo playback. RETURN Direct playback bypasses the tone controls Confirms and exits the current menu. for the most accurate reproduction of a source. Also selects the Auto Surround mode (Auto playback ). VSX-516-K...
Page 121
Direct playback bypasses the tone controls for the most accurate reproduction of a source. 20 EX Lights when a Dolby Digital Surround EX encoded AUTO SURR. signal is detected. Lights when the Auto Surround feature is switched on (see Auto playback). 21 Master volume level VSX-516-K...
Page 122
60 min - 90 min - Off). You can check the remaining sleep time at any time by pressing SLEEP once. DIMMER Dims or brightens the display. ANALOG ATT Attenuates (lowers) the level of an analog input signal to prevent distortion. VSX-516-K...
Page 123
HDD or vice-versa. Switch the display between station preset 12 DVD/DVR control buttons name and frequency. Use these buttons to control a Pioneer DVD CLASS player or recorder connected to your system Switches between the three banks (classes) (press SHIFT to access the commands bordered of station presets.
Page 124
CLEANING Before shipping out the product, be sure to clean the following positions by using the prescribed cleaning tools: Position to be cleaned Cleaning tools Fans Cleaning paper : GED-008 VSX-516-K...