Mercruiser ® Engine Flush Out Option - Four winns FUNSHIP Owner's Manual

B. MerCruiser Engine Flush Out Option
®
MerCruiser engine flush out procedures if
®
not followed in accordance to their specific
instructions can result in costly engine dam-
age. Follow MerCruiser's specific instructions
for flush-out procedures located in the Engine
operator's manual. Consult engine manu-
factuer's authorized service center for addi-
tional assistance should further questions
arise.
Make sure that no section of flush hoses is
in contact with moving or hot engine parts or
abrasive surfaces such as screw threads,
sharp edges, etc., which could damage the
hoses. Damage to the hoses could cause
leaks and possible flooding of the engine
compartment. Periodically check hoses for
abrasions.
NOTICE
The Four Winns installed flush out kit for
MerCruiser engines may be used with the
®
boat in or out of the water and the engine ON.
See MerCruiser's engine operator's manual
for the specific engine flushout procedure.
For out of water flushing, avoid possible injury
by removing the propeller and ensure that no
people or animals are in the area of the drive
unit while flushing. Contact with moving drive
components and the propeller can cause per-
sonal injury or death.
General Maintenance - Section R
To flush out the Mercruiser
lines below as well as the specific procedure outlined
in.MerCruiser's.engine.operator's.manual:...
1.. Remove.cap.from.coupling.and.attach.water..
supply.hose.
2... Turn.on.water.supply.-.See.Engine.owner's.
manual.
3. The engine must be running at idle during flushing
procedure.
4. Allow water to flush the engine and exhaust .
manifold.for.about.ten.minutes.
5.. Turn.engine.OFF.and.turn.water.off..Disconnect.
hose;.replace.and.tighten.cap.securely.
Reinstall cap onto coupler after flushing.
The cap must be secured after flushing of
engine to prevent air from entering the system
and resulting in possible engine damage.
.engine.follow.the.guide-
®
Owner's Manual Page