Detroit Diesel Series 60 Operator's Manual page 8

TABLE OF CONTENTS
COOLANT INHIBITOR ELEMENT .......................................... 75
ITEM 14 - CRANKING MOTOR .................................................. 75
ITEM 15 - AIR SYSTEM ............................................................. 76
ITEM 16 - EXHAUST SYSTEM ................................................... 76
ITEM 17 - ENGINE (STEAM CLEAN) ......................................... 76
ITEM 18 - RADIATOR ................................................................. 76
ITEM 19 - OIL PRESSURE ......................................................... 77
ITEM 20 - BATTERY-CHARGING ALTERNATOR ...................... 77
®
BOSCH T1 ALTERNATOR SERVICE REQUIREMENTS ...... 78
GENERAL SERVICE REQUIREMENTS - BOSCH
®
DELCO REMY ALTERNATORS ............................................ 78
ITEM 21 - ENGINE AND TRANSMISSION MOUNTS ................ 78
ITEM 22 - CRANKCASE PRESSURE ........................................ 78
ITEM 23 - FAN HUB .................................................................... 78
ITEM 24 - THERMOSTATS AND SEALS .................................... 79
ITEM 25 - CRANKCASE BREATHER ......................................... 79
ITEM 26 - ENGINE TUNE-UP .................................................... 79
ITEM 27 - VIBRATION DAMPER ................................................ 80
HOW-TO SECTION .............................................................................. 81
HOW TO SELECT LUBRICATING OIL ............................................ 81
LUBRICANT REQUIREMENTS .................................................. 81
EGR-EQUIPPED ENGINES .................................................... 81
NON-EGR ENGINES .............................................................. 81
ENGINES BUILT PRIOR TO 1998 .......................................... 81
COLD WEATHER STARTING ...................................................... 82
SYNTHETIC OILS ....................................................................... 82
THE USE OF SUPPLEMENTAL ADDITIVES .............................. 83
WHEN TO CHANGE OIL ................................................................. 83
DISPOSING OF WASTE OIL ...................................................... 84
HOW TO REPLACE THE LUBE OIL FILTERS ................................ 84
REPLACE SPIN-ON TYPE OIL FILTER ...................................... 84
HOW TO SELECT FUEL OIL ........................................................... 86
QUALITY ...................................................................................... 86
FUEL CONTAMINATION ............................................................. 86
PROHIBITED ADDITIVES ........................................................... 87
USED LUBRICATING OIL ....................................................... 87
GASOLINE ............................................................................. 87
HOW TO REPLACE THE FUEL FILTERS ....................................... 87
vi
6SE484 0401 Copyright © 2004 DETROIT DIESEL CORPORATION
®
AND
All information subject to change without notice. (Rev. 01/04)