Cooling System [L3 With Tc]; Cooling System Location Index; Cooling System Service Warnings[L3 With Tc] - Mazda CX-7 2007 Workshop Manual

COOLING SYSTEM LOCATION INDEX[L3 WITH TC]
5
4
.
1 Cooling system cap
(See 01-12-7 COOLING SYSTEM CAP
INSPECTION[L3 WITH TC].)
2 Coolant reserve tank
(See 01-12-3 ENGINE COOLANT LEVEL
INSPECTION[L3 WITH TC].)
(See 01-12-7 COOLANT RESERVE TANK
REMOVAL/INSTALLATION[L3 WITH TC].)
3 Radiator
(See 01-12-4 ENGINE COOLANT PROTECTION
INSPECTION[L3 WITH TC].)
(See 01-12-5 ENGINE COOLANT
REPLACEMENT[L3 WITH TC].)
(See 01-12-6 ENGINE COOLANT LEAKAGE
INSPECTION[L3 WITH TC].)
(See 01-12-8 RADIATOR REMOVAL/
INSTALLATION[L3 WITH TC].)
4 Thermostat
(See 01-12-11 THERMOSTAT REMOVAL/
INSTALLATION[L3 WITH TC].)
(See 01-12-11 THERMOSTAT INSPECTION[L3
WITH TC].)
End Of Sie

COOLING SYSTEM SERVICE WARNINGS[L3 WITH TC]

Warning
• Never remove the cooling system cap or loosen the radiator drain plug while the engine is
running, or when the engine and radiator are hot. Scalding engine coolant and steam may shoot
out and cause serious injury. It may also damage the engine and cooling system.
• Turn off the engine and wait until it is cool. Even then, be very careful when removing the cap.
Wrap a thick cloth around it and slowly turn it counterclockwise to the first stop. Step back while
the pressure escapes.
• When you are sure all the pressure is gone, press down on the cap using the cloth, turn it, and
remove it.
• Depending on the vehicle, the cooling fan may operate suddenly even when the ignition switch is
turned off. Therefore, keep hands and tools away from the cooling fan even if the cooling fan is
not operating to prevent injury to personnel or damage to the cooling fan. Always disconnect the
negative battery cable when servicing the cooling fan or parts near the cooling fan.
01-12–2
2007 Mazda CX-7 Workshop Manual (1871–1U–06B)

COOLING SYSTEM [L3 WITH TC]

3
9
5 Water pump
(See 01-12-12 WATER PUMP REMOVAL/
INSTALLATION[L3 WITH TC].)
6 Cooling fan motor No.1
(See 01-12-12 FAN MOTOR REMOVAL/
INSTALLATION[L3 WITH TC].)
(See 01-12-14 FAN MOTOR INSPECTION[L3 WITH
TC]01-12-14 FAN MOTOR INSPECTION[L3 WITH
TC].)
7 Cooling fan motor No.2
(See 01-12-12 FAN MOTOR REMOVAL/
INSTALLATION[L3 WITH TC].)
(See 01-12-14 FAN MOTOR INSPECTION[L3 WITH
TC].)
8 Fan control module No.1
(See 01-12-14 FAN CONTROL MODULE
INSPECTION[L3 WITH TC].)
9 Fan control module No.2
(See 01-12-14 FAN CONTROL MODULE
INSPECTION[L3 WITH TC].)
Revised 7/2006 (Ref. No. R065/06)
id011239800100
8
6
acxuuw00002010
id011239800200