Safety Rules - Generac Power Systems GP Series Owner's Manual

SAVE THESE INSTRUCTIONS – The manufacturer suggests that these rules for safe operation be copied and posted near the unit's
installation site. Safety should be stressed to all operators and potential operators of this equipment.
NEVER operate the generator indoors, in a garage, near an
open window, or in an area that could accumulate exhaust
gas.
Allow at least five (5) feet, or greater, of clearance on all
sides of generator. Never operate the unit inside any room
or enclosure.
• Never start or stop the unit with electrical loads connected to
receptacles AND with connected devices turned ON. Start
the engine and let it stabilize before connecting electrical
loads. Disconnect all electrical loads before shutting down the
generator.
• Do not insert objects through unit's cooling slots.
• Never operate generator:
compartment; if connected electrical devices overheat; if electrical
output is lost; if engine or generator sparks; if flames or smoke are
observed while unit is running; if unit vibrates excessively.
Study these SAFETY RULES carefully before installing, operating or
servicing this equipment. Become familiar with this manual and with
the unit. The generator can operate safely, efficiently and reliably only
if it is properly installed, operated and maintained. Many accidents
are caused by failing to follow simple and fundamental rules or
precautions.
WARNING:
The engine exhaust from this product contains
chemicals known to the state of California to cause
cancer, birth defects or other reproductive harm.
WARNING:
This product contains or emits chemicals
known to the state of California to cause
cancer, birth defects or other reproductive harm.
The manufacturer cannot anticipate every possible circumstance that
might involve a hazard. The warnings in this manual, and on tags and
decals affixed to the unit are, therefore, not all inclusive. If using a
procedure, work method or operating technique that the manufacturer
does not specifically recommend, ensure that it is safe for others. Also
make sure the procedure, work method or operating technique utilized
does not render the generator unsafe.
2
IMPORTANT SAFETY INSTRUCTIONS
Portable Generator System
DANGER
in rain; indoors or in any enclosed
Despite the safe design of this generator,
operating this equipment imprudently,
neglecting its maintenance or being careless
can cause possible injury or death. Permit only
responsible and capable persons to operate or
maintain this equipment.

Potentially lethal voltages are generated by
these machines. Ensure all steps are taken to
render the machine safe before attempting to
work on the generator.
Parts of the generator are rotating and/or hot
during operation. Exercise care near running
generators. Do not touch hot surfaces such as
the muffler. Severe burns can occur on contact.
Allow generator to cool before touching.
• Never operate in an enclosed area or indoors.
• For safety reasons, the manufacturer recommends that the
maintenance of this equipment is carried out by an Authorized
Dealer.
• The engine exhaust fumes contain carbon monoxide, which
can be DEADLY. This dangerous gas, if breathed in sufficient
concentrations, can cause unconsciousness or even death. This
exhaust system must be properly maintained. Do nothing that
might render the exhaust system unsafe or in noncompliance with
any local codes and/or standards.
• Keep hands, feet, clothing, etc., away from drive belts, fans, and
other moving or hot parts. Never remove any fan guard while the
unit is operating.
• Adequate, unobstructed flow of cooling and ventilating air is critical
to correct generator operation. Do not alter the installation or
permit even partial blockage of ventilation provisions, as this can
seriously affect safe operation of the generator. The generator
MUST be operated outdoors.
• When working on this equipment, remain alert at all times. Never
work on the equipment when physically or mentally fatigued.
• Inspect the generator regularly, and contact the nearest Authorized
Dealer for parts needing repair or replacement.
• Before performing any maintenance on the generator, disconnect
its battery cables (if equipped) to prevent accidental start up.
Disconnect the cable from the battery post indicated by a
NEGATIVE, NEG or (–) first. Reconnect that cable last.
• Never use the generator or any of its parts as a step. Stepping on
the unit can stress and break parts, and may result in dangerous
operating conditions from leaking exhaust gases, fuel leakage, oil
leakage, etc.
• Do NOT operate generator in the rain.
DANGER
GENERAL HAZARDS