Table Of Contents - Quadra-Fire CASTILE-MBK-B Owner's Manual

Castile-B FS Pellet Stove
Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Indicates practices which may cause damage to the fi replace or to property.
Section 1: Listing and Code Approvals
A. Appliance Certifi cations ......................4
B. Mobile Home Approved ......................4
C. Glass Specifi cations ............................4
D. Electrical Rating ..................................4
E. BTU & Effi ciency Specifi cations ..........4
Section 2: Getting Started
A. Design, Installation & Location
Considerations ....................................5
B. Locating Your Appliance & Chimney ..6
C. Thermostat Location ...........................6
D. Draft ....................................................6
E. Negative Pressure ..............................6
F. Fire Safety ..........................................7
G. Tools & Supplies Needed ...................7
H. Inspect Appliance & Components
Pre-Use Check List .............................7
Section 3: Dimensions & Clearances
A. Appliance Dimensions ........................8
B. Clearances to Combustibles ...............9
C. Hearth Requirements..........................10
Section 4: Vent Information
A. Chimney & Exhaust Connection .........11
B. Venting Termination Requirements ....11
C. Equivalent Feet of Pipe .......................12
D. Pipe Selection Chart ............................12
Section 5: Venting Systems
A. Alcove .................................................13
B. Through the Wall .................................14
C. Vertical ................................................15
D. Through the Wall & Vertical ................15
E. Masonry ..............................................16
F. Alternate Masonry ...............................16
Section 6: Mobile Home
November 21, 2011

TABLE OF CONTENTS

..................................17
Section 7: Appliance Set-Up
A. Outside Air Kit .....................................18
B. Leg Leveling System ...........................19
C. Top Vent Adapter ................................19
D. Rear Vent Adapter ..............................19
E. Log Set Placement ..............................20
Thermostat Installation ........................21
F.
Section 8: Operating Instructions
A. Fuel Size, Material & Storage .............22
B. General Operation Information ...........23
C. Before Your First Fire .........................23
D. Starting Your First Fire ........................23
E. Fire Characteristics .............................24
F. Ignition Cycles ....................................24
G. Feed Rate Adjustment Instructions.....24
H. Frequently Asked Questions...............25
Section 9: Troubleshooting
Section 10 Maintaining & Servicing Appliance
:
A. Proper Shutdown Procedures .............29
B. Quick Reference Maintenance Guide .29
C. General Maintenance & Cleaning .......29-32
D. High Ash Fuel Content Maintenance ..33
E. Soot or Creosote Fire ..........................33
F. Blower Replacement ...........................34-35
G. Baffl e Removal ....................................35
H. Igniter Replacement ............................36
I. Glass Replacement .............................36
J. Broken/Damaged Component ............36
Section 12: Reference Material
A. Component Functions.........................37-38
B. Component Locations .........................39
C. Exploded Drawing...............................40
D. Service Parts & Accessories ...............41-45
E. Warranty Policy ...................................46-47
F. Contact Information .............................48
7021-130C
R
............................26-28
Page 3