Summary of Contents for MULTIQUIP Mikasa series MVH-306D
Page 1
SERIES MODELS MVH-306D (RECOIL START) MVH-306DS (ELECTRIC START) REVERSIBLE PLATE COMPACTOR (YANMAR L-70EE DIESEL ENGINE) Revision #11 (04/04/14) To find the latest revision of this publication, visit our website at: www.multiquip.com THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
, 2006 Order via Internet (Dealers Only) Best Deal! If you have an MQ Account, to obtain a Username Order parts on-line using Multiquip’s SmartEquip website! and Password, E-mail us at: parts@multiquip. ■ View Parts Diagrams com. ■ Order Parts To obtain an MQ Account, contact your ■...
SAFETY INFORMATION Do not operate or service the equipment before reading Potential hazards associated with the operation of this the entire manual. Safety precautions should be followed equipment will be referenced with hazard symbols which at all times when operating this equipment. may appear throughout this manual in conjunction with Failure to read and understand the safety safety messages.
Page 7
NEVER use accessories or attachments that are not NEVER operate this equipment when not recommended by Multiquip for this equipment. Damage feeling well due to fatigue, illness or when to the equipment and/or injury to user may result.
Page 8
SAFETY INFORMATION COMPACTOR SAFETY WARNING DANGER DO NOT place hands or fingers inside engine compartment when engine is running. NEVER operate the equipment in an explosive atmosphere or near combustible materials. An NEVER operate the engine with heat shields or explosion or fire could result causing severe guards removed.
Page 9
SAFETY INFORMATION FUEL SAFETY BATTERY SAFETY (ELECTRIC START ONLY) DANGER DANGER DO NOT add fuel to equipment if it is placed inside truck DO NOT drop the battery. There is a possibility that the bed with plastic liner. Possibility exists of explosion or battery will explode.
Page 10
SAFETY INFORMATION TRANSPORTING SAFETY CAUTION NEVER allow any person or animal to stand underneath the equipment while lifting. NOTICE Before lifting, make sure that the equipment parts (hook and vibration insulator) are not damaged and screws are not loose or missing. Always make sure crane or lifitng device has been properly secured to the lifting bail (hook) of the equipment.
DIMENSIONS Figure 3. MVH-306D/DS Reversible Plate Compactor Dimensions . n i . n i PAGE 12 — MVH306D/DS PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #11 (02/04/14)
GENERAL INFORMATION Plate Compactor Frequency/Speed The Mikasa MVH-306D/DS is a walk behind, reversible plate The compactor's vibrating plate maximum frequency is 4400 compactor designed for the compaction of sand, clay and vpm (vibrations per minute). The forward and reverse travel speed asphalt.
COMPONENTS Figure 4. MVH-306D/DS Reversible Plate Compactor Components Figure 4 illustrates the location of the major components for the MVH-306D/DS Reversible Plate Compactor. The function of each component is described below: Belt Cover – Remove this cover to gain access to the V- Hand Grip –...
BASIC ENGINE Figure 5. MVH-306D/DS Engine Components ENGINE COMPONENTS Recoil Starter– Manual-starting method. Pull the starter Figure 5 illustrates the location of the major lever components of grip until resistance is felt, then pull briskly and smoothly. the machine. Each component is described below: Oil Filler Cap / Dipstick –...
INSPECTION CAUTION 4. If the oil level is low (Figure 7), fill to the edge of the oil filler hole with the recommended oil type (Table 4). Maximum oil NEVER operate the compactor in a capacity is 1.16 quarts (1.10 liters). confined area or enclosed area structure that does not provide ample free flow of air .
Page 17
INSPECTION CAUTION DANGER DO NOT overfill hydraulic oil tank. This could cause oil EXPLOSIVE FUEL! leaks and sluggish operation. Clean cap and surrounding Motor fuels are highly flammable and can area before opening to prevent dirt from entering oil tank. be dangerous if mishandled.
OPERATION CAUTION DO NOT attempt to operate the compactor until the Safety, General Information and Inspection sections of this manual have been read and thoroughly understood . Releasing the Handle Figure 14. Handle Adjustment 1. Pull the handle release pin, (Figure 13) then push down on the hand grip to release the handle.
Page 19
OPERATION If the engine fails to start, DO NOT continue to rotate the ignition key for more than 5 seconds. Return the key to the RUN position and wait 10 seconds before starting again Figure 18. Engine Start Handle Push down decompression lever (Figure 19) and Figure 17.
Page 20
OPERATION NOTICE ALWAYS move the throttle lever quickly without hesitation, because increasing the engine speed slowly causes the clutch to slip. 3. To make the compactor move in the forward direction push the travel lever ( Figure 21) forward. Figure 22. Throttle Lever (Stop) Figure 23.
MAINTENANCE NOTICE CAUTION Fuel piping and connections should be replaced every 2 Inspection and other services should always be carried out years. on hard and level ground with the engine shutdown. Inspection and Maintenance Service Tables. 1. To make sure your plate compactor is always in good working condition before using, carry out the maintenance inspection in accordance with Tables 5 through 7.
Page 22
MAINTENANCE Engine Oil Replacement: 1. Replace engine oil, in first 25 hours of operation and every 50 to 100 hours afterwards. 2. Oil may be drained more easily when it is warm after operation (For more details, see separate engine Owner's Manual).
Page 23
MAINTENANCE 2. Push the travel lever back and forth to drain the hydraulic oil Vibrator Oil Level Check from the hand pump (hydraulic oil reservoir). NOTICE Always clean the area around the vibrator oil level check plug before removing oil check plug. This will prevent dirt and debris from entering the system.
Page 24
MAINTENANCE Always wear eye protection and rubber gloves , since the CAUTION battery contains sulfuric acid which burns skin and eats Make sure hydraulic oil is at a normal safe operating level. through clothing. In case of contact, flush thoroughly with DO NOT over fill.
Page 25
MAINTENANCE Battery fluid will be lost through continuous charging and LONG TERM STORAGE discharging. When storing your compactor for long periods do the following: Discontinue charging if the electrolyte temperature exceeds Run the engine at idle spped for 3-5 minutes. 117 °...
TROUBLESHOOTING diagnosis based on the Engine Troubleshooting (Table 8) Practically all breakdowns can be prevented by proper handling and maintenance inspections, but in the event of a information shown below. If the problem cannot be remedied, please leave the unit just as it is and consult our company's breakdown, please take a remedial action following the business office or service plant.
TROUBLESHOOTING diagnosis based on the Compactor Troubleshooting (Table 9) Practically all breakdowns can be prevented by proper information shown below. If the problem cannot be remedied, handling and maintenance inspections, but in the event of a please leave the unit just as it is and consult our company's breakdown, please take a remedial action following the business office or service plant.
The contents and part numbers listed in the parts A blank entry generally indicates that the item is not sold section are subject to change without notice. Multiquip separately. Other entries will be clarified in the “Remarks” does not guarantee the availability of the parts listed.
NAMEPLATE AND DECALS NAMEPLATE AND DECALS Shell Tellus Oil Shell Tellus Oil NPA-748 STOP START OPERATIONAL CAUTION Do not move travel lever if engine stops NPA-1106 V BELT HDPF-5370 NPA-537 J 0PERATIONAL CAUTION Prior to OPERATION, check the engine oil and fuel levels. If not enough, add to proper levels. Warm up engine at low speed for 3-5 minutes.
Page 31
NAMEPLATE AND DECALS NAMEPLATE AND DECALS PART NO. PART NAME QTY. REMARKS 920201950 DECAL: OIL SAE 10W-30 920105070 DECAL: MIKASA LOGO ......1..ELECTRIC START MODEL ONLY 920110370 DECAL: MODEL LOGO MVH-306 920209620 DECAL: CAUTION 920207480 DECAL: SHELL TELLUS OIL 46 920204580 DECAL: FULL THROTTLE 920203330...
BASE AND ENGINE ASSY. BASE AND ENGINE ASSY. PAGE 34 — MVH306D/DS PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #11 (02/04/14)
Page 35
BASE AND ENGINE ASSY. BASE & ENGINE ASSY. PART NO. PART NAME QTY. REMARKS 464117850 BASE 914410022 ENGINE ASSY. L70EE (YANMAR) 0105051045 BOLT 10X45 T 030210250 WASHER, LOCK M10 031110160 WASHER, FLAT M10 464216560 BELT COVER (IN) 011208025 BOLT 8X25 T 030208200 WASHER, LOCK M8 031108160...
Page 36
BASE AND ENGINE ASSY. BASE AND ENGINE ASSY. (CONTINUED) PAGE 36 — MVH306D/DS PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #11 (02/04/14)
Page 37
BASE AND ENGINE ASSY. BASE AND ENGINE ASSY. (CONTINUED) PART NO. PART NAME QTY. REMARKS 459010060 UNION TIP, DRAIN 459010070 DRAIN HOSE 459010090 HOSE BAND 459010080 GASKET(OIL DRAIN) 0401140030 PLUG 464457380 DRAIN JOINT 014208020 BOLT 8X20 T 030208200 WASHER, LOCK M8 464117910 GUARD HOOK 012214030...
HAND PUMP ASSY. HAND PUMP ASSY. O-RING PAGE 44 — MVH306D/DS PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #11 (02/04/14)
Page 45
HAND PUMP ASSY. HAND PUMP ASSY. PART NO. PART NAME QTY. REMARKS 4649-10040 ACCUMLATOR 464910080 O-RING DUST,SEAL,SET ......1 ..... INCLUDES ITEMS W/# 464010040 CONTROL SHAFT 464010050 BUSH 464010060 464010070 STOPPER 099205005 SOCKET HEAD SCREW 5X5 T 464010080 PLUG 464010090 PIN,STOPPER 464010100 PLUG 458010080...
YANMAR L-70EE — CYLINDER HEAD AND COVER ASSY. CYLINDER HEAD AND COVER ASSY. PAGE 52 — MVH306D/DS PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #11 (02/04/14)
Page 53
YANMAR L-70EE — CYLINDER HEAD AND COVER ASSY. CYLINDER HEAD & COVER ASSY. PART NO. PART NAME QTY. REMARKS 11487111020 CYLINDER HEAD 11487111100 VALVE, SUCTION 11487111110 VALVE, EXHAUST 11435011120 SPRING, VALVE 10115811180 RETAINER, SPRING 27310060001 COTTER ASSY 11477111250 SUPPORT CAM, ARM ........1 ..... INCLUDES ITEMS W/ 11477111260 SUPPORT, ROCKER ARM 11477111650...
YANMAR L-70EE — AIR CLEANER ASSY. AIR CLEANER ASSY. PAGE 56 — MVH306D/DS PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #11 (02/04/14)
Page 57
YANMAR L-70EE — AIR CLEANER ASSY. AIR CLEANER ASSY. PART NO. PART NAME QTY. REMARKS 11425012211 GASKET, AIR CLEANER 71425012560 CLEANER ASSY, AIR .........1 ..... INCLUDES ITEMS W/ 11425012520 COVER, AIR CLEANER 11425012530 CASE, AIR CLEANER 11465012591 ELEMENT, WET AIR 11425012560 WASHER M 6, SEAL 11425012550...
YANMAR L-70EE — FUEL TANK AND FUEL LINE ASSY. FUEL TANK AND FUEL PIPE ASSY. PAGE 66 — MVH306D/DS PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #11 (02/04/14)
Page 67
YANMAR L-70EE — FUEL TANK AND FUEL LINE ASSY. FUEL TANK & FUEL LINE ASSY. PART NO. PART NAME QTY. REMARKS 71435055711 TANK, FUEL (RED) (50) ......... 1 ..... INCLUDES ITEMS W/ 11428855040 CAP ASSY, TANK ........... 1 ..... INCLUDES ITEMS W/ 11428855080 VALVE 11425055100...
YANMAR L-70EE — STARTING MOTOR AND DYNAMO ASSY. STARTING MOTOR AND DYNAMO ASSY. PAGE 68 — MVH306D/DS PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #11 (02/04/14)
Page 69
YANMAR L-70EE — STARTING MOTOR AND DYNAMO ASSY. STARTING MOTOR & DYNAMO ASSY. PART NO. PART NAME QTY. REMARKS 11436277011 STARTER (S114 - 414A) ........1 .... INCLUDES ITEMS W/ 11438177110 ARMATURE X2114811000 WASHER KIT, THRUST X2114715500 STOPPER SET, PINION 11438177130 COIL ASSY, FIELD 11438177140 COVER, REAR...