Summary of Contents for MULTIQUIP Mikasa Series MVH406GH
Page 1
OPERATION AND PARTS MANUAL SERIES MODEL MVH406GH REVERSIBLE PLATE COMPACTOR (HONDA GX390U1SMX2 GASOLINE ENGINE) Revision #3 (02/04/14) To find the latest revision of this publication, visit our website at: www.multiquip.com THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
, 2006 Order via Internet (Dealers Only) Best Deal! If you have an MQ Account, to obtain a Order parts on-line using Multiquip’s SmartEquip website! Username and Password, E-mail us at: ■ View Parts Diagrams parts@multiquip.com. ■ Order Parts To obtain an MQ Account, contact your ■...
This Owner's Manual has been developed to provide complete instructions for the safe Engine exhaust gases contain and efficient operation of the Multiquip MVH- poisonous carbon monoxide. This gas 406GH Plate Compactor . Refer to the engine is colorless and odorless, and can manufacturer's instructions for data relative cause death if inhaled.
Page 7
MVH-406GH — SAFETY MESSAGE ALERT SYMBOLS CAUTION - Rotating Parts CAUTION - Equipment Damage Messages NEVER operate equipment with covers, Other important messages are provided throughout this or guards removed. Keep fingers, hands, manual to help prevent damage to your light tower, other hair and clothing away from all moving property, or the surrounding environment.
■ NEVER use accessories or attachments, which are not location out of the reach of children. recommended by Multiquip for this equipment. Damage to ■ NEVER run engine without air cleaner. Severe engine the equipment and/or injury to user may result.
Page 9
MVH-406GH — RULES FOR SAFE OPERATION ■ NEVER disconnect any "emergency or safety devices" . Emergencies These devices are intended for operator safety. Disconnection ■ ALWAYS know the location of the of these devices can cause severe injury, bodily harm or even nearest fire extinguisher .
Figure 2 displays the operation and safety decals as they appear on the reversible plate compactor. Should any of these decals become damaged or unreadable, contact the Multiquip Parts Department for a replacement set. Figure 2. Operation and Safety Decals...
MVH-406GH — DIMENSIONS Figure 3. MVH-406GH Reversible Plate Compactor Dimensions . n i . n i . n i PAGE 12 — MVH406GH PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (02/04/14)
MVH-406GH— FEATURES Plate Compactor Frequency/Speed The Mikasa MVH-406GH is a walk behind, reversible plate The compactor's vibrating plate maximum frequency is 4600 compactor designed for the compaction of sand, clay and vpm (vibrations per minute). The forward and reverse travel speed asphalt.
Page 14
MVH-406GH— PLATE COMPACTOR COMPONENTS M V H - 4 0 6 Figure 4. MVH-406GH Reversible Plate Compactor Components Belt Cover – Remove this cover to gain access to the V- Figure 4 illustrates the location of the major components for the belts.
MVH-406GH— ENGINE COMPONENTS Figure 5. MVH-406GH Engine Components INITIAL SERVICING The engine (Figure 5) must be checked for proper lubrication and Choke Lever – Used in the starting of a cold engine, or in filled with fuel prior to operation. Refer to the manufacturers engine cold weather conditions.
MVH-406GH — PRE-INSPECTION 4. If the oil level is low (Figure 7), fill to the edge of the oil filler CAUTION hole with the recommended oil type (Table 4). Maximum oil capacity is 1.16 quarts (1.10 liters). NEVER operate the compactor in a confined area or enclosed area structure that does not provide ample free flow of air .
Page 17
MVH-406GH — PRE-INSPECTION Remove the air cleaner element (Figure 11) and inspect it CAUTION for signs of wear or dirt. If air cleaner element is dirty, clean or replace element. DO NOT overfill hydraulic oil tank. This could cause oil leaks and sluggish operation.
Page 18
MVH-406GH — OPERATION CAUTION DO NOT attempt to operate the compactor until the Safety, General Information and Inspection sections of this manual have been read and thoroughly understood . This section is intended to assist the operator with the initial start-up of the Figure 14.
Page 19
MVH-406GH — OPERATION Place the choke lever ( Figure 17) in the “OPEN” position if starting a cold engine. Figure 20. Engine Start Handle If the engine has started, slowly return the choke lever (Figure 18) to the “CLOSED” position. If the engine does Figure 17.
Page 20
MVH-406GH—OPERATION ALWAYS move the throttle lever quickly without hesitation, because increasing the engine speed slowly causes the clutch to slip. 3. To make the compactor move in the forward direction push the travel lever ( Figure 22) forward. Figure 23. Throttle Lever (Stop) Figure 22.
Page 21
MVH-406GH — MAINTENANCE CAUTION CAUTION Inspection and other services should always be carried out on Fuel piping and connections should be replaced every 2 years. hard and level ground with the engine shutdown. Inspection and Maintenance Service Tables. 1. To make sure your plate compactor is always in good working condition before using, carry out the maintenance inspection in accordance with Tables 5 through 7.
MVH-406GH — MAINTENANCE Engine Oil Replacement: Spark Plug 1. Replace engine oil, in first 25 hours of operation and every 1. Remove and clean the spark plug (Figure 26). 50 to 100 hours afterwards. 2. Adjust the spark gap to 0.028 ~0.031 inch (0.6~0.7 mm). This 2.
Page 23
MVH-406GH—MAINTENANCE Vibrator Oil Level Check Checking and Replacing the V-Belt and Clutch 1. After 200 hours of operation, remove the belt cover to check CAUTION the V-belt tension (Figure 30). Tension is proper if the belt bends about 3/8”(10 mm) when depressed strongly with Always clean the area around the vibrator oil level check plug finger between shafts.
MVH-406GH—MAINTENANCE 2. Push the travel lever back and forth to drain the hydraulic oil CAUTION from the hand pump (hydraulic oil reservoir). Make sure hydraulic oil is at a normal safe operating level. DO NOT over fill. Over filling (excessive oil) will cause excess oil to blow out of bleeder plug.
Page 25
MVH-406GH—TROUBLESHOOTING diagnosis based on the Engine Troubleshooting (Table 8) Practically all breakdowns can be prevented by proper handling and maintenance inspections, but in the event of a information shown below. If the problem cannot be remedied, please leave the unit just as it is and consult our company's breakdown, please take a remedial action following the business office or service plant.
Page 26
MVH-406GH—TROUBLESHOOTING diagnosis based on the Compactor Troubleshooting (Table 9) Practically all breakdowns can be prevented by proper information shown below. If the problem cannot be remedied, handling and maintenance inspections, but in the event of a please leave the unit just as it is and consult our company's breakdown, please take a remedial action following the business office or service plant.
Page 27
MVH-406GH—TROUBLESHOOTING t u l p i l s u j u l c p i l s u j . t l e v i l i o b i v l l i F e r r v e l .
Multiquip. A blank entry generally indicates that the item is not sold separately or is not sold by Multiquip. Other entries will be clarified in the “Remarks” Column. PAGE 28 — MVH406GH PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (02/04/14)
Page 34
MVH-406GH — BASE AND ENGINE ASSY. BASE AND ENGINE ASSY. 16 14 PAGE 34 — MVH406GH PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (02/04/14)
Page 35
MVH-406GH — BASE AND ENGINE ASSY. BASE AND ENGINE ASSY. PART NO. PART NAME QTY. REMARKS 465118420 BASE 912239011 ENGINE ASSY., GX390U1SMX2 0105051045 BOLT 10X45 T 030210250 WASHER, LOCK M10 031110160 WASHER, FLAT M10 465217030 BELT COVER (IN) 001121025 BOLT 8X25 T 030210250 WASHER LOCK M10 031110160...
MVH-406GH — HAND PUMP ASSY. HAND PUMP ASSY. PAGE 42 — MVH406GH PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (02/04/14)
Page 43
MVH-406GH — HAND PUMP ASSY. HAND PUMP ASSY. PART NO. PART NAME QTY. REMARKS 465910070 ACCUMLATOR 464910080 O-RING DUST,SEAL,SET ......1 ..... INCLUDES ITEMS W/# 464010040 CONTROL SHAFT 464010050 BUSH 464010060 464010070 STOPPER 099205005 SOCKET HEAD SCREW 5X5 T 464010080 PLUG 464010090 PIN,STOPPER 464010100...
Page 44
GX390U1SMX2 ENGINE — AIR CLEANER ASSY. AIR CLEANER ASSY. PAGE 44 — MVH406GH PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (02/04/14)
Page 45
GX390U1SMX2 ENGINE — AIR CLEANER ASSY. AIR CLEANER ASSY. PART NO. PART NAME QTY. REMARKS 16271ZE2010 PACKING, ELBOW 17210ZE3505 AIR CLEANER ELEMENT ...... 1 ... INCLUDES ITEMS W/ # 17218ZE3505 FILTER, OUTER 17231ZE3W01 COVER, AIR CLEANER 17232891000 GROMMET, AIR CLEANER 17235ZH9N01 NOISE SILENCER 17238ZE2310...
Page 49
GX390U1SMX2 ENGINE — CARBURETOR ASSY. CARBURETOR ASSY. PART NO. PART NAME QTY. REMARKS 16010ZE2812 GASKET SET 16011ZA0931 VALVE SET, FLOAT 16013ZA0931 FLOAT SET 16015ZE8005 CHAMBER SET, FLOAT ......1 ... INCLUDES ITEMS W/ % 16016ZH7W01 SCREW SET, PILOT 16024ZE1811 DRAIN SCREW SET 16028ZE0005 SCREW SET 16044ZE3W20...
Page 50
GX390U1SMX2 ENGINE — CONTROL ASSY. CONTROL ASSY. PAGE 50 — MVH406GH PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (02/04/14)
Page 51
GX390U1SMX2 ENGINE — CONTROL ASSY. CONTROL ASSY. PART NO. PART NAME QTY. REMARKS 16551ZE3000 ARM, GOVERNOR 16555ZE3000 ROD, GOVERNOR 16561ZE3000 SPRING, GOVERNOR 16562ZE3000 SPRING, THROTTLE RETURN 16570ZE3W10 CONTROL ASSY. (REMOTE) ....1 ..INCLUDES ITEMS W/ # 16571ZE3W00 LEVER, CONTROL 16574ZE1000 LEVER SPRING 16575ZE2W00...
Page 63
GX390U1SMX2 ENGINE — FLYWHEEL ASSY. FLYWHEEL ASSY. PART NO. PART NAME QTY. REMARKS 19511ZE3000 28450ZE3W11 PULLEY 28451ZE3W01 PULLEY 90201ZE3V00 90741ZE2000 MVH406GH PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (02/04/14) — PAGE 63...
Page 64
GX390U1SMX2 ENGINE — FUEL TANK ASSY. FUEL TANK ASSY. PAGE 64 — MVH406GH PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (02/04/14)
Page 65
GX390U1SMX2 ENGINE — FUEL TANK ASSY. FUEL TANK ASSY. PART NO. PART NAME QTY. REMARKS 16854ZH8000 RUBBER, SUPPORT (107MM) 16955ZE1000 JOINT, FUEL TANK 17510ZE3020ZB TANK CP, FUEL/BLACK/GX390 17620Z0T305 FUEL TANK CAP CP ......... 1 ..INCLUDES ITEM W/ # 17631Z0T812 PACKING, FUEL FILLER CAP 17672ZE2W01 FUEL FILTER...
TERMS AND CONDITIONS OF SALE — PARTS PAYMENT TERMS Parts must be in new and resalable con- Multiquip reserves the right to quote and sell dition, in the original Multiquip package (if direct to Government agencies, and to Original Terms of payment for parts are net 30 days.
Page 77
NOTES MVH406GH PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #3 (02/04/14) — PAGE 77...