Harman TLC 2000 Installation And Operating Manual
  1. Manuals
  2. Brands
  3. Harman Manuals
  4. Stove
  5. TLC 2000
  6. Installation and operating manual

Harman TLC 2000 Installation And Operating Manual

Coal/wood stove
Hide thumbs Also See for TLC 2000:
Table of Contents

Advertisement

Quick Links

Installation & Operating manual
The harman TlC 2000 Coal/wood Stove
r13

SAFETY NOTICE

PlEASE rEAd ThIS ENTIrE mANuAl bEFOrE YOu INSTAll ANd uSE YOur NEw rOOm hEATEr. FAIlurE
TO FOllOw INSTruCTIONS mAY rESulT IN PrOPErTY dAmAgE, bOdIlY INjurY, Or EvEN dEATh.
FOr uSE IN ThE u.S. ANd CANAdA. dO NOT INSTAll IN A mObIlE hOmE.
IF ThIS STOvE IS NOT PrOPErlY INSTAllEd, A hOuSE FIrE mAY rESulT. FOr YOur SAFETY, FOllOw
INSTAllATION dIrECTIONS.
CONTACT lOCAl buIldINg Or FIrE OFFICIAlS AbOuT rESTrICTIONS ANd INSTAllATION INSPECTION
rEQuIrEmENTS IN YOur ArEA.
CONTACT YOur lOCAl AuThOrITY (SuCh AS muNICIPAl buIldINg dEPArTmENT, FIrE dEPArTmENT, FIrE
PrEvENTION burEAu, ETC.) TO dETErmINE ThE NEEd FOr A PErmIT.
CETTE guIdE d'uTIlISATION EST dISPONIblE EN FrANCAIS. ChEz vOTrE CONCESSIONNAIrE dE hArmAN.
SAvE ThESE INSTruCTIONS.
3-90-08691

Advertisement

Table of Contents
loading

Related Manuals for Harman TLC 2000

Summary of Contents for Harman TLC 2000

  • Page 1: Safety Notice

    TO FOllOw INSTruCTIONS mAY rESulT IN PrOPErTY dAmAgE, bOdIlY INjurY, Or EvEN dEATh. FOr uSE IN ThE u.S. ANd CANAdA. dO NOT INSTAll IN A mObIlE hOmE. IF ThIS STOvE IS NOT PrOPErlY INSTAllEd, A hOuSE FIrE mAY rESulT. FOr YOur SAFETY, FOllOw INSTAllATION dIrECTIONS.

  • Page 4: Table Of Contents

    Introduction Table of Contents Specifications Operation Building a Fire Maintenance Installation Chimney System Service Parts List Warranty Please read this entire manual before you install and use your new room heater. Failure to follow instructions may result in property damage, bodily injury, or even death. DO NOT INSTALL IN A MOBILE HOME.
  • Page 5 CO fumes are toxic and can be fatal. The TLC 2000 is a natural draft system which relies on a properly designed chimney to remove CO and other combustion by-products from the stove.

  • Page 6: Specifications

    Flue Size: Fuel: Fuel: uSA: Pea, Nut, or Stove coal, Cordwood with optional spark screen uSA: Pea, Nut, or Stove coal, Cordwood with optional spark screen Canada: Wood, or coal as above. Wood alone as local codes allow Canada: Wood, or coal as above. Wood alone as local codes allow...
  • Page 7 Top Load Door Arm Wood Air Control Side Shield Removable Shaker Handle Front Load Door Latch Ash Door Latch Top Load Door Grates (2) Clean-out Cover Top Load Opening Glass Door Coal Bars (3) Coal Air Control Ash Door...

  • Page 8: Operation

    NEvEr OPErATE wITh mOrE ThAN ONE dOOr OPEN AT A TImE The glass used in your TLC 2000 is manufactured to exact standards to withstand the high heat of the fire, but like all glass, it must be treated with common sense and care.

  • Page 9: Building A Fire

    2"- 3" (50 mm - 80 mm) is formed; (You may need to leave the ash door open a crack to get the blaze going properly, but never leave the stove unattended with a door open.) Add more wood to create a deeper charcoal base 3"...
  • Page 10 Operating as a Fireplace The TLC 2000 is tested and approved to be burned with the front load door open. In this mode of operation you get a true fire sound as well as appearance. Due...
  • Page 11 Do not burn the stove continuously at the maximum setting. If maximum heat is required day after day, the stove is too small for the area you are trying to heat. Never leave the stove unattended if either the ash or load door is open.
  • Page 12 Handle Cooking Grill TLC 2000 with cooking grill in action Disposal of Ashes. The TLC 2000 was designed to provide access to the ash pan without the need for opening the main door. Wearing heavy protective gloves, open the ash door and remove the ash pan by pulling it forward by the handle.

  • Page 13: Maintenance

    Like all fine equipment, your TLC 2000 requires some routine maintenance and inspection. Follow the guidelines in this section to guarantee safe, efficient operation. The Stove Surface The stove’s exterior surface should be dusted periodically with a soft cloth. For more thorough cleaning, wait until the stove is cool before using a damp cloth to clean any blemishes.
  • Page 14 On the doors to provide airtight closure. On the lid. handle The handle on the front door of your TLC 2000 is attached to a threaded shaft. After a period of time, you may find that the front door does not close as firmly as when your stove was new.

  • Page 15: Installation

    Blower Variable Speed knob Installation blower ( Optional ) Bolt the blower to the bottom rear of the stove with four 1/4-20 bolts. Tighten the bolts, but do not over- tighten. The blower speed can be adjusted using the knob that is built-in to the power cord.
  • Page 16 Parallel versus Corner Installations A parallel installation is one in which the back and sides of the stove are parallel to the walls behind and to the side of the stove. A corner installation is one in which the back of the stove is positioned diagonally across a corner of the room.

  • Page 17: Chimney System

    Chimney System When installed and operated according to this manual, the TLC 2000 will produce enough hot gases to keep the chimney warm so that adequate draft is maintained throughout the burn cycle.

  • Page 18: The Chimney

    Residential Type and Building Heating Appliances, UL 103, or (2) a code-approved masonry chimney with a flue liner. In Canada, the TLC 2000 is listed for use with prefabricated chimneys tested and listed to the high temperature (650 degrees C) chimney standard, ULC S-629, or with a code approved masonry chimney.
  • Page 19 UL 103 or ULC-629. wArNINg: dO NOT INSTAll IN SlEEPINg rOOm. The Harman TLC 2000 was tested with the fuel door open and closed. If you operate with the door open, be sure to install the optional fire screen, and be sure the bypass damper is open.

  • Page 20: Service Parts List

    1-70-08690-10 (mojave red) Ending manufacturing date jan 2010 1-70-08690-12 (Forest green) Ending manufacturing date jan 2010 Part number list on following page. Service Parts Top load Coal/wood Stove 1-90-08690-1 (black w/door) retired units 1-70-08690-1 (black) Ending manufacturing date: june 2011...
  • Page 21 IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authorized dealer. ITEm dESCrIPTION Top Air Grill Assembly (Option) Top, Rear Top Load Door Assembly Gasket, Bulb black 1-1/2”...
  • Page 22 IMPORTANT: THIS IS DATED INFORMATION. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in this manual may be ordered from an authorized dealer. ITEm dESCrIPTION Air grill trim Air Adjuster, Left and Right Bolt (ash door hinge) Brass Elbow Brick Backer...

  • Page 23: Warranty

    Hearth & Home Technologies Inc., on behalf of its hearth brands (”HHT”), extends the following warranty for HHT gas, wood, pellet, coal and electric hearth appliances that are purchased from an HHT authorized dealer. WARRANTY COVERAGE: HHT warrants to the original owner of the HHT appliance at the site of installation, and to any transferee taking ownership of the appliance at the site of installation within two years following the date of original purchase, that the HHT appliance will be free from defects in materials and workmanship at the time of manufacture.
  • Page 24 WARRANTY CONDITIONS: • This warranty only covers HHT appliances that are purchased through an HHT authorized dealer or distributor. A list of HHT authorized dealers is available on the HHT branded websites. • This warranty is only valid while the HHT appliance remains at the site of original installation. •...
  • Page 25 Service & maintenance log Date Of Service Performed By Description Of Service...
  • Page 26 Proudly Printed On 100% Recycled Paper...

Table of Contents