Harman P43 Owner's Manual
  1. Manuals
  2. Brands
  3. Harman Manuals
  4. Stove
  5. P43
  6. Owner's manual

Harman P43 Owner's Manual

Freestanding pellet stove
Hide thumbs Also See for P43:
Table of Contents

Advertisement

Quick Links

Download this manual
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
Contact your local dealer with questions on installation, operation or service.
NOTICE: SAVE THESE INSTRUCTIONS
Model(s):
P43, P61A & P68
Freestanding Pellet Stove
!
Check building codes prior to installation.
• Installation MUST comply with local, regional, state and
national codes and regulations.
• Contact local building or fire officials about restrictions
and installation inspection requirements in your area.
!
Tested and approved for wood pellets and or a mixture of
50-50 wood pellets / shelled corn mixture, burning of any
other type of fuel voids your warranty. When burning pellet/
corn blends more frequent cleanings may be required.
1
Owner's Manual
Care and Operation
CAUTION
CAUTION
Harman® • P-Series Owner's Manual_R23 • 2014 - ___ • 02/19
!
Please read this entire manual before
installation and use of this pellet fuel-
burning room heater.
Failure to follow these instructions could
result in property damage, bodily injury
or even death.
• Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
• Do not overfire - If any external part starts to glow, you
are overfiring. Reduce feed rate. Overfiring will void
your warranty.
• Comply with all minimum clearances to combustibles
as specified. Failure to comply may cause house fire.
!
HOT SURFACES!
Glass and other surfaces are hot
during operation AND cool down.
Hot glass will cause burns.
• Do not touch glass until it is cooled
• NEVER allow children to touch glass
• Keep children away
• CAREFULLY SUPERVISE children in same room as
stove.
• Alert children and adults to hazards of high temperatures.
High temperatures may ignite clothing or other
flammable materials.
• Keep clothing, furniture, draperies and other flammable
materials away.
NOTE
To obtain a French translation of this manual, please
contact your dealer or visit www.harmanstoves.com
Pour obtenir une traduction française de ce manuel, s'il
vous plaît contacter votre revendeur ou visitez www.
harmanstoves.com
WARNING
WARNING
3-90-436168c

Advertisement

Table of Contents
loading

Related Manuals for Harman P43

Summary of Contents for Harman P43

  • Page 1 Pour obtenir une traduction française de ce manuel, s’il other type of fuel voids your warranty. When burning pellet/ vous plaît contacter votre revendeur ou visitez www. corn blends more frequent cleanings may be required. harmanstoves.com Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 2: Welcome

    P.N. 3-90-08626_R11 loor protector LABEL TICKET ECO: 88378 LABEL SIZE: 4.375” H x 10.75” W Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c PART # / REV: 3-90-08626_R11 ADHESIVE: 3M 486 Adhesive ORIGINATOR: Spidlet MATERIAL: 24 Gauge Aluminum...

  • Page 3: Table Of Contents

    P43 ........

  • Page 4: Product Specific And Important Safety Information

    2015 particulate emission to cause birth defects or other reproductive harm. For standards. Not approved for sale after more information go to: www.P65Warnings.ca.gov May 15, 2020. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 5: Btu & Efficiency Specifications

    This wood heater needs periodic inspection and repair for proper operation. It is against federal regulations to operate this wood heater in a manner inconsistent with operating instructions in this manual. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 6: General Information

    • Unplug stove from receptacle. Connect the power cord to a 120 VAC, 60 Hz grounded receptacle. (A surge protector is recommended to protect the circuit board.) Be sure the polarity of the outlet the stove is plugged into is correct. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 7: Control Explanation

    Dealers exclusively. vary the distribution blower speed using the inner scale marked from 1 to 7. by turning the knob to the high or low side of each mode. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 8: Fuel Specification

    Damp pellet fuel could turn back into sawdust which does not flow properly through the feed system. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 9: General Operating Information

    • DO NOT USE CHEMICALS OF FLUIDS TO START THE FIRE. • Combustible materials may ignite. Figure 3.1 Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 10: Operating Instructions

    7-10 minutes. After this time, the igniter light should turn off and the unit should begin to operate per the settings at the control. Figure 4.2 Figure 4.3 Figure 4.4 Figure 4.5 Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 11: Ignition Cycles

    When this happens, the unit will need to be turned to the off position and restarted. If needed, follow the instructions in Section A “Starting Your First Fire”. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 12: Automatic Ignition

    1" or less ash bed is not obtainable, it is not a problem. The 1" ash bed is only at maximum burn rate and during normal operation, the ash bed will be larger. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...
  • Page 13 The best way to shut down the stove is simply let it run out of pellets, then the stove will shut down automatically. This setting will produce continuous maximum heat output with the distribution blower at full speed. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 14: Maintenance And Service

    • Risk of shock if appliance not unplugged before servicing appliance. Follow the detailed instructions found in this section for each step listed in the chart below. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 15: Quick Reference Maintenance Chart

    4. Yearly cleaning is also known as a Total Clean. This requires completing all the Daily, Weekly, Monthly and Yearly maintenance mentioned. This should be done before you begin burning the unit each heating season. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 16: Glass Maintenance

    Replace glass only with high temperature mirrored ceramic glass. Inspect door gasket during cleaning and inspection Glass Gasket P68 Freestanding Pellet Stove Glass Retainers and screws Door Frame Adhesive gasket Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 17: Burnpot Maintenance

    Note: The hot lead/cold lead connection must always Figure 5.3 - Viewed from below through the ash pan opening. be pulled to the rear of the feeder body before operation. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 18: Combustion Blower Chamber

    Combustion Intake Cover while cleaning this area. Figure 5.4 Exhaust Passage ESP Sensor Figure 5.7 Pull up on Intake Retainer Figure 5.5 Pull and slide to the right Figure 5.6 Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 19: Pellet Feeder Chamber

    NOTE: Views are shown with the rear motor covers removed. Feeder clean out cover 5/16" Wing Nut Figure 5.8 Pellet Metering Possible pellet fines Slide Plate buildup area. Figure 5.9 Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 20: Troubleshooting And Frequently Asked Questions

    7. This is normal. Flame will settle down once the fire is established. Contact your dealer for additional information regarding operation and troubleshooting. Visit www.harmanstoves. com to find dealer. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 21: Troubleshooting

    FIRE HAS GONE OUT- Check for status light. 1. No fuel in hopper. 2. Draft is too low, blocked flue. 3. Something is restricting fuel flow. 4. Hopper lid not closed properly. 5. Feed motor or combustion blower has failed. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 22: Reference Materials

    If a fire occurs, call the fire department, shut down the stove, and evacuate the residence. Before using the appliance, have the venting system thoroughly inspected and replace any damaged components. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 23: Motor And Component Location

    Sensor for faults. If a fault should occur, the control sends a status is connected into the AC (high voltage) wiring. alert and at the same time the unit goes down to minimum feed/ minimum burn as a safety condition. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 24: Loss Of Power Addendum

    4. Light pellet gel with a match, and close the door, turn Mode operation. Selector to Constant Burn. Operation will begin when the fire reaches the proper temperature. Contact your dealer if you have questions about UPS compatibility with your appliance. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 25: Service Parts

    Pre 008168147 1-10-08518 Hopper Lid w/Hinge, Knob Post 008168147 1-10-773900 Hopper Switch 48” Post 008084166 3-20-232108 Hopper Extension Switch Kit 1-00-06826 Additional service parts on following page. 2/19 Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...
  • Page 26 Pkg of 5 1-00-07381 Auger Motor Cover 2-00-773843P Auger Motor Shield 2-00-773815P Differential Switch 3-20-6866 Gasket, Burn Pot/Tailpipe Pkg of 5 1-00-07381 Additional service parts on following page. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...
  • Page 27 Airwash O-Rings Pkg of 10 1-00-939639 Arrow Burn Pot Scraper Pkg of 10 2-00-773850-10 Diagnostic Display Module 3-20-05401 DDM Replacement Cable 1-00-05402 Disconnect, Female Pkg of 25 1-00-00959 Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...
  • Page 28 Brushed Stainless 3-43-08400-7 Bright Nickel 3-43-08400-8 Gold 3-43-06729-4 Tile Frame Brushed Stainless 3-43-06729-7 Bright Nickel 3-43-06729-8 Spring Clips (Required for installation of Tile Frame) Pkg of 20 3-31-232547-20 Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 29: P61A

    Hopper Extension Switch Kit 1-00-06826 Hopper Knob Post 008093438 1-00-02000-1 Hopper Latch Assembly Post 008168147 1-00-773901 Hopper Switch 48” Post 008087704 3-20-232108 Additional service parts on following page. 2/19 Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...
  • Page 30 1-00-677150 Gasket, Feeder, Air Intake Pkg of 6 3-44-72224-6 Motor Bracket Grommet Pkg of 12 3-31-2761-12 Pillow Block Pkg of 4 3-31-3614087-4 Additional service parts on following page. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...
  • Page 31 Pkg of 2 1-00-142818 Motor Bracket Grommet Pkg of 12 3-31-2761-12 Pillow Block Pkg of 4 3-31-3614087-4 Silicone Tubing, 1/8” 5 Ft 1-00-5113574 Additional service parts on following page. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...
  • Page 32 Hopper Heat Shield 2-00-06471B Feeder Cover 2-00-773826L Circuit Board w/Knobs & Shafts 1-00-05886 Circuit Board Plate, Studded w/label 1-10-08327 Control Panel Label 3-90-07766 Knob, Contol Board/D-Shaft 25 Sets 1-00-015605 Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...
  • Page 33 Brushed Stainless 3-43-08400-7 Bright Nickel 3-43-08400-8 Gold 3-43-06729-4 Tile Frame Brushed Stainless 3-43-06729-7 Bright Nickel 3-43-06729-8 Spring Clips (Required for installation of Tile Frame) Pkg of 20 3-31-232547-20 Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 34: P68

    Hopper Extention Switch Kit 1-00-06826 Hopper Latch Assembly Post 008168147 1-00-773901 Hopper Knob Post 008295042 1-00-02000-1 Hopper Switch Post 008284286 3-20-232108 Additional service parts on following page. 2/19 Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...
  • Page 35 1-00-677150 Gasket, Feeder, Air Intake Pkg of 6 3-44-72224-6 Motor Bracket Grommet Pkg of 12 3-31-2761-12 Pillow Block Pkg of 4 3-31-3614087-4 Additional service parts on following page. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...
  • Page 36 Pkg of 2 1-00-142818 Motor Bracket Grommet Pkg of 12 3-31-2761-12 Pillow Block Pkg of 4 3-31-3614087-4 Silicone Tubing, 1/8" 5 Ft 1-00-5113574 Additional service parts on following page. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...
  • Page 37 1-00-777907 Fire Brick 4-1/2 x 9 x 1-1/4” Pkg of 7 1-00-900450125 Fire Brick , Full Skid 414 Pcs 3-40-900450-414 Hopper Heat Shield 2-00-06715B Feeder Opening Cover 2-00-773826L Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...
  • Page 38 Post 008281295 3-20-00844 Thermostat Extension 3-20-00607 Pre 008293174 3-42-1990 Touch up Paint, Black, 12 oz Can Post 008293174 3-42-19905 Wiring Harness 3-20-08727 Additional service parts on following page. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...
  • Page 39 Brushed Stainless 3-43-08400-7 Bright Nickel 3-43-08400-8 Gold 3-43-06729-4 Tile Frame Brushed Stainless 3-43-06729-7 Bright Nickel 3-43-06729-8 Pkg of 20 3-31-232547-20 Spring Clips (Required for the installation of Tile Frame) Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 40: Limited Lifetime Warranty

    Firebox and heat exchanger, Grate and Stainless Limited 3 years Steel Burners, FlexBurn® System (engine, inner Lifetime cover,access cover and fireback) 90 Days All replacement parts beyond warranty period Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c 4021-645J • 08-03-17...
  • Page 41 Consideration must be given to the appliance location and configuration, environmental conditions, insulation and air tightness of the structure. 4021-645J • 08-03-17 Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...
  • Page 42 EXCEPT TO THE EXTENT PROVIDED BY LAW, HHT MAKES NO EXPRESS WARRANTIES OTHER THAN THE WARRANTY SPECIFIED HEREIN. THE DURATION OF ANY IMPLIED WARRANTY IS LIMITED TO DURATION OF THE EXPRESSED WARRANTY SPECIFIED ABOVE. Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c 4021-645J • 08-03-17...
  • Page 43 Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

  • Page 44: Contact Information

    Printed in U.S.A. - Copyright 2012 Harman® • P-Series Owner’s Manual_R23 • 2014 - ___ • 02/19 3-90-436168c...

This manual is also suitable for:

P61aP68P61

Table of Contents