Periodic Service Schedule - Bad Boy RECOIL iS Owner's Manual

MAINTENANCE
Read all of this manual to become thoroughly familiar with this vehicle. Pay particular attention to all Notices, Cautions, Warnings, and Dangers.

PERIODIC SERVICE SCHEDULE


- CHECK
REMARKS
Tires - pressure, condition of tires and rims
Hardware - loose or missing
Overall Vehicle Condition
Batteries - state of charge, condition, loose terminals, corrosion,
5
hold down and hardware
Batteries* - check electrolyte level, fill after charging if required (if
plates are exposed before charging add only enough water to
cover any exposed plates and fill after charging)
Brakes - check fluid level in master cylinder
Brakes - smooth operation of pedal, stopping distance
Park Brake - does brake hold on a hill
Accelerator - smooth operation
Wiring - loose connections, broken or missing insulation
Charger Receptacle - inspect and clean receptacle at each charge
Steering Assembly - excessive play, loose or missing hardware
Tie Rods - excessive play, bent rods, loose or missing hardware
Front and Rear Axle - oil leakage, noise, loose or missing hardware
Front and Rear Axle - drain and replace fluid
Front Suspension - strut oil leakage, excessive play in hubs or king-
pins, worn bushings, loose or missing hardware
Front and Rear Wheel Alignment - unusual tire wear
Rear Suspension - strut oil leakage, worn bushings, loose or miss-
ing hardware
*Use only distilled or purified water that is free of contaminants to fill batteries.
NOTE: Some maintenance items must be serviced more frequently on vehicles used under severe driving conditions.
Page 5 - 18
C&A - CHECK & ADJUST CL - CLEAN R - REPLACE
    
    
    

CL CL CL
C&A C&A C&A C&A
   
    
C&A C&A C&A C&A
    
   
CL CL CL CL
   
   
   
   
C&A C&A C&A
  
3000 mi/5000 km
5000 mi/8000 km