Optional Filter Wand - Wells WVAE55F Owner's Manual

OPERATION - OPTIONAL FILTER WAND
DANGER:
BURN HAZARD
Contact with hot oil will cause
severe burns.
Always wear protective clothing
and heat resistant gloves when
using the oil wand.
IMPORTANT:
Be sure the wand is properly
installed, and that the discharge
nozzle of the oil wand is directed
either:
into the frypot, or
into the disposal container, before
pressing the FRYER-OFF-FILTER
switch to the FILTER position.
CAUTION:
BURN HAZARD
Contact with hot oil may cause
burns. DO NOT fill fryer beyond
MAX OIL line on frypot.
For disposal of oil use only a
container specifically designed
for the disposal of hot oil.
DO NOT fill hot oil disposal
container beyond MAX OIL line.
NOTE:
If the discharge from the nozzle is
not a steady stream, the filter is
clogged with breading and/or filter
powder:
a. Close the frypot drain valve
by turning the drain valve
handle to the horizontal
position. When all oil is
returned to the frypot,
press the FRYER-OFF-
FILTER to OFF.
b. Allow the filter reservoir to
cool. Refer to the Operation
Manual for instructions on
cleaning the filter and filter
reservoir.
OPEN
DRAIN " "
(HANDLE VERTICAL)
3-WAY VALVE
O T
Y P
WAND"
TO "
F R
T O
(HANDLE
HORIZONTAL)
FRYER
QUICK-
DISCONNECT
FITTING
OPTIONAL OIL WAND
WASH OUT FRYPOT or DISCARD OIL
1. If discarding oil, be sure a suitable hot oil disposal container
is available. Otherwise, prepare filter reservoir pan for
filtering (see page 25).
2. Turn DRAIN VALVE HANDLE vertical to open the drain and fill
filter reservoir.
3. Connect wand (female) fitting to the fryer (male) fitting:
a. Slide locking ring of wand female fitting fully toward the
hose.
b. Seat wand fitting fully onto fryer fitting.
c. Allow locking ring to return to its original position.
d. Check to verify that wand fitting is held securely by pulling
on the hose. It must NOT "pop" off of fitting.
4. Turn 3-WAY VALVE HANDLE to horizontal position to direct
the pump output to wand.
5. Direct discharge nozzle of wand into the frypot, or into a
suitable hot oil disposal container. DO NOT fill beyond
the MAX OIL line.
6. Press FRYER-OFF-FILTER switch to FILTER position.
7. Wand may be used to wash down sides of the frypot during
filtering, or to pump oil into a container for disposal.
20
D R
A I N
F R
O M
F I L
T E
R
I S C
K D
U I C
O Q
I N T
I N G
I T T
D F
A N
T W
E R
I N S
C T
N E
O N
LOCKING
RING
FRYER
OFF
FILTER