Generac Power Systems PRIMEPACT 50 04164-3 Owner's Manual page 47

ITEM PART NO. QTY.
1 0C9675 1
2 0A5649H 1
3 0A5646H 1
4 073159 1
5 031971 1
6 0C9674 1
7 0A6529 4
8 052858 4
9 066386 1
10 066849 3
11 0A8475 3
12 0C3818 1
13 075234 1
14 022473 2
15 022097 5
16 055816 1
17 090141 2
18 0A1658 2
19 074906 4
20 0922340SRV 1
21 0H3224 1
22 022129 4
23 027756 4
24 086316 1
25 053650 1
26 0C4258 1
27 075244 1
28 094071 1
29 094070 1
30 075476 3
31 022264 4
32 065795 1
33 090987 2
34 086317A 1
Alternator and Panel (Model 04164-3) – Drawing No. 0D1776-J
DESCRIPTION
LOWER BEARING CARRIER
ROTOR ASSEM.
STATOR ASSEM.
BALL BEARING
BALL BEARING
UPPER BEARING CARRIER
STUD-STATOR
M8-1.25 FLANGE LOCK NUT
BRUSH HOLDER
M5-0.8 X 16 LG. TAPTITE
SPECIAL LOCK WASHER, M5
GENERATOR TOP HOUSING
RESISTOR1R 5% 25 WLVG
¼"/ M6-FLAT WASHER
¼"/ M6-LOCK WASHER
M6-1.0 X 70 LG. CAPSCREW
GROUND CABLE
SPECIAL LOCK WASHER, M6
M6-1.0 X 20 LG. TAPTITE
CONTROLLER P .C.B.
DECAL, MAINTENANCE SCHEDULE
RV
5/16" –M8 LOCK WASHER
NYLON WASHER
PANEL SHEET METAL
4-PIN CONNECTOR
CONDUIT ASSEMBLY
ASSEMBLY, REMOTE CABLE
M5-.08 X 110 LG. PPHMS
SPACER-PLASTIC
M4-0.7 X 16 LG. CAPSCREW
#8/ M4-LOCK WASHER
BATTERY CHARGE RECTIFIER
M3-0.5 X 12 LG. PPHMS
PANEL SUPPORT BRACKET
Section 6 — Exploded Views and Parts Lists
Recreational Vehicle Generator
ITEM PART NO. QTY.
35 075235
36 082737
37 049813
38 055440
39 043182
40 045771
41 053623
42 023484S
43 0F9719
44 022152
45 051716
46 090144
47 090145
48 025105
49 086315
50 090734
51 022985
52 032300
53 022676
54 087798
55 092113
56 075210A
57 0A8475A
58 051715
59 090157
60 090156
61 074908
62 031791
63 023897
64 0D2724
65 031879
66 049815
DESCRIPTION
2 M5-0.8 X 30 LG. CAPSCREW
4 VIBRATION MOUNT
4 M6-1.0 HEX NUT
2 M5-08 X 25 LG. HEX HD. CAPSCR.
2 M3-LOCK WASHER
4 HEX NUT, M8
1 C/BREAKER 2.5A.-ON
1 BUSHING
1 REGULATOR VOLTAGE
5 LOCKWASHER, #10
3 M5-0.8 HEX NUT
1 C/BREAKER 20A.
1 C/BREAKER 30A.
4 #6-32 SCREW W/LOCK WASHER
1 PANEL COVER
4 M4-0.7 X 12 LG. CAPSCR.W/LOCK-
WASHER & FLAT WASHER
1 #6-FLAT WASHER
1 FUSE HOLDER
1 FUSE AGC-15A.
1 SWITCH S.P .D.T. (START-STOP)
1 SWITCH S.P .D.T.-(FUEL PUMP)
1 TERMINAL BLOCK
1 SPECIAL LOCK WASHER, M4
1 M4-0.7 HEX NUT
1 DECAL, CB RATING 30A.
1 DECAL, CB RATING 20A.
2 M5-0.8 X 10 LONG TAPTITE
1 CLAMP , HOSE
2 #10/ M5-FLAT WASHER
2 BOOT, ROCKER SWITCH
2 WASHER FLAT #4
1 HHCS M5-0.8 X 16
45