Table of Contents
Advertisement
DANGER: For fire safety, installation of a generator into a recreational vehicle must comply strict-
ly with article 551, NFPA 70; ANSI C1-1975; AND, ANSI A119.2-1975/NFPA 501C "Standard for
Recreational Vehicles" (Part 3, "Installation of Electrical Systems"). In addition, installation must com-
ply with the manufacturer's instructions and recommendations.
NOTICE TO INSTALLER
These Installation Instructions have been published by the manu-
facturer to aid in the installation of the products described in this
manual. The manufacturer assumes that installation personnel
are familiar with the procedures for installing such products, or
similar products manufactured. The manufacturer also assumes
that personnel have been trained in the recommended installation
procedures for these products and that such training includes (a)
use of common hand tools, (b) use of special tools, and (c) use of
any tools and/or equipment from other suppliers.
The manufacturer cannot possibly know of and advise the rec-
reational vehicle trade of all conceivable methods, procedures or
techniques by which to perform an installation. Nor can the manu-
facturer anticipate every possible hazard that might result from
each installation method, procedure or technique. The manufactur-
er has not undertaken any such wide evaluation. Therefore, people
who use a method, procedure or technique that the manufacturer
does not specifically recommend must first completely satisfy
themselves that their safety, the safety of the vehicle's occupants
and the product's safety is not endangered by the method, proce-
dure or technique selected.
Information, illustrations, specifications, etc., contained in these
Installation Instructions are based on the latest information avail-
able at the time of publication. Every effort has been expended
to be sure that such data is both accurate and current. However,
the manufacturer reserves the right to change, alter or otherwise
improve this product at any time without prior notice.
DANGER
Despite the safe design of this generator,
operating this equipment imprudently, neglect-
ing its maintenance or being careless can cause
possible injury or death. Permit only responsible
and capable persons to operate or maintain this
equipment.
Potentially lethal voltages are generated by
these machines. Ensure all steps are taken to
render the machine safe before attempting to
work on the generator.
Parts of the generator are rotating and/or hot
during operation. Exercise care near running
generators.
Generator exhaust gases contain DEADLY
carbon monoxide gas. This dangerous gas, if
breathed in sufficient concentrations, can cause
unconsciousness or even death.
18
Safety Rules
Recreational Vehicle Generator
GENERAL HAZARDS
•
For safety reasons, the manufacturer recommends that the
installation, initial start-up and maintenance of this equipment
is carried out by an Authorized Service Dealer.
•
Keep hands, feet, clothing, etc., away from drive belts, fans,
and other moving or hot parts. Never remove any drive belt or
fan guard while the unit is operating.
•
When working on this equipment, remain alert at all times.
Never work on the equipment when physically or mentally
fatigued.
•
Inspect the generator regularly, and contact the nearest
Authorized Service Dealer immediately for parts needing repair
or replacement.
•
Inspect the generator regularly, and contact the nearest
Authorized Service Dealer immediately for parts needing repair
or replacement.
•
Before performing any maintenance on the generator, discon-
nect its battery cables to prevent accidental start up. Disconnect
the cable from the battery post indicated by a NEGATIVE, NEG
or (–) first. Reconnect that cable last.
•
Never use the generator or any of its parts as a step. Stepping
on the unit can stress and break parts, and may result in dan-
gerous operating conditions from leaking exhaust gases, fuel
leakage, oil leakage, etc.
ENGINE EXHAUST HAZARDS
•
Generator engine exhaust contains DEADLY carbon monox-
ide, an odorless, colorless poisonous gas. Breathing carbon
monoxide can cause: dizziness, throbbing temples, nausea,
muscular twitching, headache, vomiting, weakness and sleepi-
ness, inability to think clearly, fainting, unconsciousness or
even death. If you experience any carbon monoxide poisoning
symptoms, move into fresh air and immediately seek medical
attention.
•
Never operate the generator set with the vehicle inside any
garage or other enclosed area.
•
Adequate, unobstructed flow of cooling and ventilating air
is critical for expelling toxic carbon monoxide gas and fuel
vapors from the generator compartment and for proper genera-
tor operation. Without sufficient cooling airflow, deadly carbon
monoxide gas can accumulate and the engine/generator may
quickly overheat, causing serious damage to the generator. Do
not operate the genset in any confined space.
•
The exhaust system must be installed in accordance with the
genset installation manual. Do not alter the installation or permit
even partial blockage of ventilation systems, as this can seri-
ously affect the safe and proper operation of the generator.
Hide quick links:
Advertisement
Table of Contents
