Table of Contents
Advertisement
INSTALLATION AND
OPERATION MANUAL
SUNFIRE ELECTRIC
CONVECTION OVENS MODELS:
ICO-E-10M & ICO-E-20M
FOR YOUR SAFETY:
DO NOT STORE OR USE GASOLINE
OR OTHER FLAMMABLE VAPORS OR
LIQUIDS IN THE VICINITY OF
THIS OR ANY OTHER
WARNING:
IMPROPER INSTALLATION, ADJUSTMENT,
ALTERATION, SERVICE OR MAINTENANCE
CAN CAUSE PROPERTY DAMAGE, INJURY,
OR DEATH. READ THE INSTALLATION,
OPERATING AND MAINTENANCE
INSTRUCTIONS THOROUGHLY
BEFORE INSTALLING OR
SERVICING THIS EQUIPMENT
Users are cautioned that maintenance and repairs must be performed by a Garland authorized service agent
using genuine Garland replacement parts. Garland will have no obligation with respect to any product that has been
improperly installed, adjusted, operated or not maintained in accordance with national and local codes or installation
instructions provided with the product, or any product that has its serial number defaced, obliterated or removed,
or which has been modified or repaired using unauthorized parts or by unauthorized service agents.
For a list of authorized service agents, please refer to the Garland web site at http://www.garland-group.com.
The information contained herein, (including design and parts specifications), may be superseded and is subject
to change without notice.
Manufactured by
Cleveland Range
1333 East 179th Street, Cleveland, Ohio 44110
USA
Part # 4520415 (07/12/11)
Part # 4520415 (07/12/11)
APPLIANCE
PLEASE READ ALL SECTIONS OF THIS MANUAL
AND RETAIN FOR FUTURE REFERENCE.
THIS PRODUCT HAS BEEN CERTIFIED AS
COMMERCIAL COOKING EQUIPMENT AND
MUST BE INSTALLED BY PROFESSIONAL
PERSONNEL AS SPECIFIED.
INSTALLATION AND ELECTRICAL CONNECTION
MUST COMPLY WITH CURRENT CODES:
IN CANADA - THE CANADIAN ELECTRICAL
CODE PART 1 AND / OR LOCAL CODES.
IN USA – THE NATIONAL ELECTRICAL CODE
ANSI / NFPA – CURRENT EDITION.
ENSURE ELECTRICAL SUPPLY CONFORMS WITH
ELECTRICAL CHARACTERISTICS SHOWN ON
THE RATING PLATE.
GARLAND COMMERCIAL RANGES, LTD.
1177 Kamato Road, Mississauga, Ontario L4W 1X4
CANADA
Phone: 905-624-0260
Fax: 905-624-5669
© 2005 Garland Commercial Industries, Inc.
Page 1
Advertisement
Table of Contents
Related Manuals for Sunfire SUNFIRE ICO-E-10M
Summary of Contents for Sunfire SUNFIRE ICO-E-10M
-
Page 1: For Your Safety
Users are cautioned that maintenance and repairs must be performed by a Garland authorized service agent using genuine Garland replacement parts. Garland will have no obligation with respect to any product that has been improperly installed, adjusted, operated or not maintained in accordance with national and local codes or installation instructions provided with the product, or any product that has its serial number defaced, obliterated or removed, or which has been modified or repaired using unauthorized parts or by unauthorized service agents. -
Page 2: Important Information
IMPORTANT INFORMATION WARNING: This product contains chemicals known to the state of California to cause cancer and/or birth defects or other reproductive harm. Installation and servicing of this product could expose you to airborne particles of glass wool/ceramic fibers. Inhalation of airborne particles of glass wool/ceramic fibers is known to the state of California to cause cancer. -
Page 3: Table Of Contents
TABLE OF CONTENTS IMPORTANT INFORMATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 DIMENSIONS AND SPECIFICATIONS . -
Page 4: Dimensions And Specifications
DIMENSIONS AND SPECIFICATIONS Height Oven Interior Dimensions Combustible Wall Clearance Width Depth ICO-E-10 ICO-E-20 Height Depth Width Sides Rear 40" 44-1/2" 60" 72" 20-1/2" 28-1/2" 29" 6" 6" (1016mm) (1130mm) (1524mm) (1829mm) (520mm) (723mm) (736mm) (152mm) (152mm) Shipping Information Nominal Amperes Per Line Model Total kW Lbs. -
Page 5: Introduction
In the event you have questions concerning this installation, Range products are not approved or authorized for home or use, care or service of this or any other Garland/US Range residential use, but are intended for commercial applications (Sunfire) product, contact our Product Service Department. -
Page 6: Installation Of Legs, Stand
INSTALLATION Continued Installation Of Legs, Stand Assembly Instructions For Open Base Verify that all parts are present before beginning assembly. 1. Raise the unit or lay it on its left side. Tools required for Assembly 2. For foot versions take a hammer and lightly tap a square foot insert (2) into each leg. -
Page 7: Assembly Instructions For Legs
INSTALLATION Continued Parts List ITEM # DESCRIPTION Legs Square Foot Inserts (Foot Version Only) Heavy Duty Casters W/O Brakes (Caster Version Only) Heavy Duty Casters W/Brakes (Caster Version Only) Caster Pad Assembly (Caster Version Only) Open Stand Upper Support (Open Base Versions Only) Rack Guides (Open Base Version Only) Open Stand Lower Rack Support Rack Support Clips (Top) -
Page 8: Assembly Instructions For Double Deck Casters
INSTALLATION Continued 9. Level the oven using a 1” wrench and adjust the feet or Assembly the casters. 1. Raise the unit or lay it on its left side. NOTE: Ovens supplied with casters must be installed with an 2. Attach each caster pad (1) with two 3/8” bolts and flat approved restraining device washers and two 1/4”... -
Page 9: Stacking Of Ovens
INSTALLATION Continued Stacking Of Ovens Rear View of Ovens Remove the lower front shroud from the unit that is to be the top deck. To remove-open the oven doors and remove four (4) #10 sheet metal screws located in front of the lower door seal. -
Page 10: Cable Entrance And Connection Point
INSTALLATION Continued Cable Entrance and Connection Point Commissioning The service line enters though the rear of the unit and is Input voltage and phasing must match the unit’s voltage and connected to the terminal block (Located behind the “flip phasing. A wiring diagram is attached to the main back of down”... -
Page 11: Operation
OPERATION Explanation Of Controls Power/Mode Switch: In the “COOL DOWN” position, the fan motor will run continuously only when the open door is in 1 Oven Light Switch the OPEN POSITION. In the “COOK POSITION” the fan & heat will stop when the doors are open. In the “OFF” position, all power is off. -
Page 12: Energy Conservation
OPERATION continued Energy Conservation 2. If the unit is to be shut down for an extended period of time, turn the appliance main circuit breaker to the “OFF” Do not waste energy by leaving the controls at high position, (located behind the lower front shroud). temperature settings during idle periods. -
Page 13: Problems/Solutions
PERFORMANCE RECOMMENDATIONS continued NOTE: Moisture will escape around the doors when baking All units have a controllable moisture vent. The vent control products with heavy moisture content, such as: chicken, is located at the inner front top of the oven cavity. Movement potatoes, and etc. -
Page 14: Cooking Guide
COOKING GUIDE PRODUCT TEMPERATURE TIME Sheet Cakes (5 lb each) 325°F (164°C) 18 min. Soda Biscuits 400°F (207°C) 6 min. Yeast Rolls 325°F (164°C) 20 min. Corn Bread 350°F (197°C) 20 min. Gingerbread 300°F (151°C) 18 min. Chocolate Cake 325°F (164°C) 20 min. -
Page 15: Cleaning And Maintenance
CLEANING AND MAINTENANCE NOTE: Disconnect line cord from the power supply before 2. Lift rack guides on either side of oven off of holders, pull cleaning or servicing. the top away from the cavity wall, when it’s cleared the clips push down and remove. Racks and guides may Break in Period be run through the dishwasher while the oven cavity is being cleaned. - Page 18 Intérieurg Nettoyage Moteur Entretien Extérieur Nettoyage Rodage Période ENTRETIEN NETTOYAGE...
- Page 19 TEMPS TEMPÉRATURE PRODUIT CUISSON GUIDE...
- Page 20 Solutions Problèmes SOLUTIONS PROBLÈME (suite) D’UTILISATION RECOMMANDATIONS...
- Page 21 D’UTILISATION RECOMMANDATIONS D’extinction Instructions D’énergie Économies DOWN COOL Automatique Refroidissement Fonction (suite) FONCTIONNEMENT...
- Page 22 empérature tion Sé Commande Chauffage émoin COOK Commandes Utilisation Minuterie Commande température Commande chauffage Témoin d’alimentation Témoin imentation/Mode) Power/Mode Commutateur imentation D’a émoin ateur Venti Vitesse Commutateur (Minuterie) Timer ventilateur) (vitesse Speed Commutateur COOK Four airage D’é Interrupteur DOWN COOL Power/Mode Commutateur commandes...
- Page 23 Bornier trique É imentation Câb tion Doub À Entrée Ventilation Fours Pour Option Câb Entrée/sortie Service Mise Connexion Point Câble Entrée (suite) INSTALLATION...
- Page 24 Retiréd Avant Carénage Côté Montage Équerre Avant Inférieur Carénage Électriques Connexions Montage Supports Fours Arrière Fours Empilage (suite) INSTALLATION...
- Page 25 Nomenclature Double Section Roulettes Montage Instruction Montage montage pour nécessaires Outils (suite) INSTALLATION...
- Page 26 Pieds Montage Instructions DESCRIPTION QTÉ PIÈCE Nomenclature (suite) INSTALLATION...
- Page 27 ôté ustré ’apparei héma montage pour nécessaires Outils Ouverte Base Montage Instructions Socle Pieds, Installation (suite) INSTALLATION...
- Page 28 COMBUSTIBLES MURS RAPPORT DÉGAGEMENTS Emplacement Dégagements INSTALLATION Signalétique Plaque INTRODUCTION...
- Page 29 Déballé caisse Modèle D’entrée Dégagements Totale Modèle Volume 3Ø* 240V 3Ø* 208V Puissance Modèle Lignee Nominal Ampérage D’expédition Informations Arrière Côtés Largeur Profondeur Hauteur ICO-E-20 ICO-E-10 Profondeurh Largeur Combustibles Murs Four Intérieures Dimensions Hauteur Rapport Dégagements SPÉCIFICATIONS DIMENSIONS...
- Page 30 ENTRETIEN NETTOYAGE CUISSON GUIDE SOLUTIONS. PROBLÈME D’UTILISATION. RECOMMANDATIONS FONCTIONNEMENT INSTALLATION INTRODUCTION. SPÉCIFICATIONS DIMENSIONS IMPORTANTES INFORMATIONS MATIÈRES TABLE...
- Page 31 combustibles produits stocker dégagés l’appareil abords Maintenir cancer. causant comme Californie l’état reconnue céramiques fibres verre laine particules L’inhalation céramiques. verre/fibres laine poussières exposer vous peut produit l’entretien L’installation reproduction. problèmes d’autres congénitales malformations et/ou cancer causant comme Californie l’état reconnus chimiques produits...
- Page 32 L’ÉQUIPEMENT. RÉPARER D’INSTALLER AVANT D’ENTRETIEN D’UTILISATION D’INSTALLATION, INSTRUCTIONS MENT SOIGNEUSE- LIRE MORT. SURES BLES- MATÉRIELS, DOMMAGES CAUSER PEUVENT FAITS ENTRETIEN RÉPARATIONS MODIFICATIONS, RÉGLAGES, INSTALLATION, AVERTISSEMENT APPAREIL AUTRE TOUT APPAREIL PROXIMITÉ À INFLAMMABLES LIQUIDES VAPEURS D’AUTRES D’ESSENCE UTILISER STOCKER SÉCURIT: VOTRE POUR ICO-E-20M ICO-E-10M...