Single-stage 4-way multipoise condensing gas furnace (87 pages)
Summary of Contents for Payne PG9YAB Series
Page 1
Owner's Manual NOTE INSTALLER: THIS MANUAL MUST BE LEFT WITH THE EQUIPMENT USER. USER: Please read all instructions in the manual and retain manuals for future reference. FIRE OR EXPLOSION HAZARD Failure to follow safety warnings could result in injury, death, As an ENERGY S TAR ®...
Page 2
Combustion Air (Your Safety) Vent Pipe /_,_/ Draft Hood CARBON MONOXIDE POISONING HAZARD Failure to follow this warning could result in personal iniury or death. All fuel-burning appliances must be provided with enough A07688 fresh air for proper combustion and ventilation of flue gases.
Page 3
form this test i nthe kitchen, cooking vapors may produce Thermostat inaccurate results.) There are many types and styles of thermostats. Most thermostats A good r elative humidity isone justhigh enough tobarely start control both heating and cooling functions and have a Fan Switch condensation along thelower edges or lower corners of the with...
Page 4
The off-delay is set by moving jumper on the control. Should overheating occur or the gas control valve fail to shut Wiring Diagram located on the inside of the blower door shows the off, shut off the manual equipment shutoff valve to the furnace various...
Page 5
Pressure Switches Single Stage During regular yearly maintenance, check for cracks in any tubes on the pressure switches. ELECTRICAL SHOCK HAZARD Failure to follow this warning could result in personal iniury On\Off toggle or death. switch Turn off electrical power to furnace before performing any maintenance or removing panels or doors.
Page 6
Filter rack(s) attached to the outside of the furnace is made so the filter simply slides out one end for removal. Center Clip , side-to-side "\ PROPERTY DAMAGE HAZARD Failure to follow this warning could result in increase furnace operating temperatures and shorten the life of the furnace.
Page 7
Table I - Recommended Filter S izes Recommended Filter Sizes Nominal Air Flow Nominal Size (inches/mm) Cubic Feet per Minute (CFM) Cleanable Filters Disposable Filters 800-900 20 x 25 (508.0 x 635.0) (1 Req.) 14 x 25 (355.6 x 635.0) (1 Req.) 1100-1300 14 x 25 (355.6 x 635.0)
Page 8
'?2009 Payne Heating & Cooling Systems • 7310 W. Morris St. • Indianapolis, IN 46231 Printed in U,S,A, Edition Date: 05/09 Catalog No: OG-PG9YAB-01 Replaces: Manufacturer reserves the right to change, at any time, specification8 and design8 without notice and without obligations,...