Maintenance - Briggs & Stratton 100000 Operating & Maintenance Instructions

I:BR.GGS MAINTENANC E
MAINTENANCE
Regular maintenance will improve the performance and
extend the life of the engine. See any Authorized Briggs &
Stratton Dealer for service. Use only genuine Briggs &
Stratton parts. Other parts may not perform as well,
may damage the engine, and may result in injury. In
addition, use of other parts may void your warranty.
EMISSION CONTROL
Maintenance, replacement or repair of the emission
control devices and systems may be performed by any
nonroad engine repair establishment or individual.
However, to obtain no charge repairs under the terms and
provisions of the Briggs & Stratton warranty statement, any
service or emission control part repair or replacement must
be performed by a factory authorized dealer.
Follow the instructions and schedules indicated below.
CHANGING OIL
Task _ o u_ _ o =
Perform task at hourly oo a 0 0 €I) o
or calendar interval, >, _. -r" _ _ _ "1" >, o
whichever comes first. _ 0 u'_ • _ o_
Check Oil Level _/
Change Oil _/*
Service Oil-Foam® air _/**
cleaner element
Inspect spark arrester _/
(if equipped)
Replace spark plug _/
Clean cooling system _/**
Clean combustion _/
chamber
* Change oil after first 5 to 8 hours of use, then every
50 hours or every season. Change oil every 25 hours
when operating the engine under heavy load or in high
temperatures.
** Clean more often under dusty conditions or when
airborne debris is present. Replace air cleaner parts, if
very dirty.
CAUTION: Used oil is a hazardous waste
product. Dispose of used oil properly. Do not
discard with household waste. Check with your
local authorities, service center, or dealer for safe
disposal/recycling facilities.
TOP OIL DRAIN
SPARK
PLUG
SIDE OIL DRAIN
(IF EQUIPPED)
BOTTOM OIL DRAIN
OIL
4
PLUGS
o
3/8"
PiPE SQUARE
WARNING
[3]
[4]
[1] Run engine until it runs
out of fuel. Otherwise,
fuel can leak out, creating
a fire/explosion hazard,
when you tip engine in
Step 4.
[2] Disconnect spark plug
wire and keep it away
from spark plug.
With engine OFF but still warm remove dipstick.
Top oil drain, keep spark plug side up. Bottom or
side oil drain (if equipped), keep engine level. Drain
oil into appropriate receptacle.
CAUTION
If engine is tipped to transport equipment, remove grass,
drain oil, etc., keep spark plug side of engine u__.
Tipping engine with spark plug down may cause:
KEEP SPARK PLUG UP .-.._,,,,_
• Smoking, @
• Hard starting,
• Spark plug fouling,
• Oil saturation of air filter.
Note: Top oil drain is recommended method, however
oil can drain from side (if equipped) or bottom as shown.
[5] Place engine level. Add about 5/8 quart
(20 ounces: 0.6 liter) new oil. Fill to FULL line on
dipstick. Do not overfill. Replace dipstick.
High Oil Fill _-_
(if equipped)
Low Oil Fill i/_-_
(if equipped) _ /
11