TROUBLESHOOTING
POINTS
CAUSE
CORRECTION
PROBLEM
wet netstart
Hard to start
Engine wit! not turn over
Engine clicks but wtg net
start
Loss of power
Excessive vibration
1
Out of fuel
2
Engine not "CHOKED" preper;y
3
Engfne flooded
4
Bad spark plug
&
Dirly aft fit{or
8
Dirty fuel f_Itar
7,
Waler In fuel
8
Loose or damaged w]dng,
g
Carburetor oul af adjustment
tO,
Engine valves out of adjusLmenl,
1
Dirty air f_ter,
2
Bad spark plug
3
Weak or dead battery
4
Dirty fuel filter
5
Stale or didy fuel,
8
Loose or damaged wldng
7
Carbu rater oul of adjustment,
8
Englne valves out of adjustment
1
Clutchrorake podaf net dapresaod
2
Attachment cMch is engaged
3
Spa_k plug wire Is disconnected
4
Weak or dead batlery
5,
Blown fuse
6
Corroded battery terminate
7
Loose or damaged wiring
8
Faulty _gntOoeswitch
g
Faully so}enid
or starter
tO
Foully operator presence ewtlah(ea)
t
Weak or dead battery
2
Corroded battery terrain!!B.
3
Loose or damaged wldng
4
Foully _otanafd or atader
1
Culling too mec:_ grass/too fast
2
Throttle tn "CHOKE" poelIIoo.
3
Bulid.,up of grass, leaves end trash under mower
4
Ditty air filter,
5
Low ell tavafldirty oli
6
Faufty spark plug
7
Didyfuel filler
B
Stale or dirty fuel
g
Watarlnfuel
10.
Spark ptug wire loose
11,
Dirty aegina air sareentflns
12.
Dlrty/elagged muffler,
t3,
Loose or damaged wiring
!4
Carburetor out of adjustment
15,
Engine valves out of adIustreent
1
Worn, bent or loose blade
2,
Sent blade maedret,
3,
Looee/demaged part(s)
t
Flfl feet tank,
2
See TO START ENGINE In operation eecDon
&
Watt several minutes before attempting to start
4
Replace spark plug.
&
Clean#eplace air filler.
6.
Replace feet filer.
7.
Dr_n feet task and carburetor, refill tank wlLhfresh
gaaaiina and replace fuel filler
8
Check aft widng.
g-
Contact Sears Service Center,
10
Contast Se are Service Center,
1,
Claan#aplace air frier.
2
Reptace spark ptug
3,,
Recharge or replace batter/
4
Replace fuel f}fter
5.
Drain fuel tank end refill
wl_ fresh gasollna
6
Check a}I wldng,
7.
Contact Seam Service Center
8
Contact Sears Service Center
1
DepressCIulch/bmkepedat,
2
Disengage attachment clutch
3
Connect wire to spark ptug
4
Recharge or repiece batteq/,
G
Replace fuse
6
Clean batter./I_rminala
7
Check alt wiring
8
Chsckheplace Ignition swkch
9
Check/replace sofenold orstader
t0
Contact Sears Servtce Center
1
Recharge or replace baltory
2,
Clean baltary terminals
3
Check ellwidng,
4,
Cheddreplace aolanold or starter
I
Set In "Higher Cut" positlon#educe speed
2
Adjuat throtge control
3
Clean underside of mower housing
4
Cleanlrepleaa air fl11_r
5
Check olI level/c,hange ell
O
Clean and regap or change spark plug
7
Replace fuel lIltar
B
Drafn fuel t_k and refillwith fresh gasoline,
g
Drain fuel lank end carburetor, relill lankw}th #esh
gasoline and replace fue! filler
10
Connect and _ghtee spark plug wife
I t,
Clean engine alrecrean/flns
t
2r
CleanHepleoe muffler,
13
Check all wiring,
14
Contact Seat's Service Canter
15
Contact Seats Service C_nter
1
Replace blade, Tighten blade boll.
2
Replace blade mandret,
3
Tighten loose part(a), Replace damaged parts
26