Table Of Contents; Specifications; Read Carefully; Before Installing - COZY VC501A Installation And Operation Instructions Manual

TABLE OF CONTENTS
SPECIFICATIONS............................ 2
INTRODUCTION............................. 3
VENTING....................................... 3,4
GAS StJPPLY.................................. 5
LOCATION & SPECIAL PRECAUIIONS 5
COMBUSTION & VENTILATION AIR .... 6
CLEARANCES................................ 7
DRAFTD1VERTER.......................... 7
I_ORKNOB ................................. 7
PILOTADJUSTMENT ...................... 8
RADIANTS & GLASS PANELS........... 8
BURNER ORIFICE & ORIFICE CHART.......... 8
PROPER BURNER FLAME .......................... 9
MAINTENANCE ..................................... 9
LIGHTING INSTRUCTIONS ....................... 10
TROUBLE SHOOTING CHART ............ 11,12
BLOWER INSTRUCTIONS .................. 13
PARTSDRAWING............................. 14
PARTSPRICE LIST............................ 15
WARRANTY.................................... 17
READ CAREFULLY BEFORE INSTALLING UNIT
These installation instructions are a general guide and do not supersede applicable local codes and ordinances. Before
planning or making the installation be sure it complies with all phases of the local heating code. (Or, in the absence of
local codes, with the latest edition of National Fuel Gas Code, ANSI.Z223.1, or CAN1-B 149).
The appliance, when installed, must be electrically grounded in accordance with local codes, or in the absence of local
codes, with the latest edition of National Electrical Code ANSI/NFPA 70, or Canadian Electrical Code CSA-C22.1.
All of the ANSI and NFPA standards referred to in these installation instructions are the ones that were applicable at
the time the design of this appliance was certified. The ANSI standards are available from the American Gas Association,
1515 Wilson Blvd., Arlington, VA. 22209.
The NFPA standards are available from the national Fire Protection Association, 60 Batterymarch Street, Boston,
Massachusetts 02110.
Canadian standards are available from International Approval Services, 178 Rexdale Boulevard, Etobicoke, Ontario,
Canada M9W 1R3.
The design of this appliance was certified to comply with ANSI Z21.11.1 vented room heaters and CAN1-2.1-M86.
Installer must leave these instructions with the consumer, have them complete, and return the warranty card.
ROOM HEATER SPECIFICATIONS
Your room heater comes packed in a single carton. Before installation, check the rating plate to verify that the Model Number is
correct and that the room heater is equipped t\_r the type gas you intend to use.
SPECIFICATIONS
TYPE CONTROL GAS MODEL NUMBERS
CLOSED FRONT THERMOSTAT BULB NATURAL VC201A VC351A VC501A VC701A
CLOSED FRONT THERMOSTAT BULB L.P VC202A VC352A VC502A VC702A
RADIANTFRON1 THERMOSTAT BULB NATURAL N/A VCR351A VCR501A VCR701A
RADIANTFRON1 THERMOSTAT BULB L.R N/A VCR352A VCR502A VCRT02A
HEIGHT 20" 26" 26" 30"
WIDTH 24" 30" 30" 36"
DEPTH 15-1/4" 15-1/4" 19-1/4" 19-1/4"
INPUT (BTU/HR.) 20,000 35,000 50,000 70,000
GAS INLET/OUTLET SIZE
VENT SIZE
CENTER OF VENT TO FLOOR
NUMBER OF RADIANTS ("VCR" SERIES)
NUMBER OF RADIANT GLASS _"VCR" SE___.ES_
APPROX. SHIPPING WEIGHT ("VC" SERIES)
APPROX. SHIPPING WEIGHT ("VCR" SERIES)
*OPTIONAL BLOWER MODEL
1/2X3/8"
3"
16-1/2"
N/A
N/A
55 LBS.
N/A
N/A
1/2X3/8"
4"
21-1/2"
5
2
84 LBS.
96 LBS.
CHB-3
1/2X3/8"
4"
21-1/2"
5
2
ll2LBS.
124 LBS.
CHB-3
1/2X3/8"
5"
25-1/2"
5
2
138 LBS.
150 LBS.
CHB-3
*Blowers also available factory mounted on 50M Btu units. All 70M Btu units come with blower mounted only.
Page 2