Material Safety Data Sheet - Oki MC160MFP Safety And Warranty Manual

Material Safety Data Sheet

# 5839580
Black Toner: P/N 442506
For more information, contact Oki Data at: 2000 Bishops Gate
Boulevard, Mount Laurel, NJ 08054-4620 .
Emergency Information: call 1-800-654-3282; US and Canada
only .
Emergency First Aid Procedures _______
Toner inhaled .
Remove person to fresh air . Seek medical attention .
Toner swallowed (ingested)
Immediately seek medical attention . Never give anything by
mouth to an unconscious person . If possible, rinse out mouth
and give one or two glasses of water or milk to drink .
Toner gets in the eyes .
Flush eyes with large quantities of cool water for 15 minutes,
keeping the eyelids open with fingers. If necessary, seek
medical attention .
Toner gets on the skin .
Wash toner off the skin with plenty of cool water and soap . If
necessary, seek medical attention .
Note: Small amounts of toner on skin or clothing can easily
be removed with soap and cold water . Hot water
makes toner harder to remove .
Hazardous Ingredients ______________
Carbon Black (-0% by weight)
CAS#: 1333-86-4
OSHA TWA: 10 mg/m
3
ACGIH TLV: 10 mg/m
3
Other Major Ingredients (non-hazardous):
Styrene Acrylic Resin (5-85% by weight)
CAS#: Trade Secret .
OSHA TWA: Trade Secret .
ACGIH TLV: Trade Secret .
Wax 0-20% by weight)
CAS#: Trade Secret .
OSHA TWA: Trade Secret .
ACGIH TLV: Trade Secret .
Amorphous Silica (-0% by weight)
CAS#: 7631-86-9
OSHA TWA: Trade Secret .
ACGIH TLV: Trade Secret .
Physical Data ______________________
Physical State: Solid .
Melting/Freezing Point: Not available .
Boiling Point: Not applicable .
PH: Not applicable .
Vapor Pressure: Not applicable .
Vapor Density (Air=): Not applicable .
Evaporation Rate (Butyl Acetate=): Not applicable .
Specific Gravity (H
Solubility in Water: Insoluble in water .
Solubility in Solvents: Not available .
Coefficient of water/oil Distribution: Not available .
Appearance and Odor: Black powder, Almost odorless
Odor Threshold: Not available .
Fire and Explosion Hazard Data ________
Minimal fire hazard. Large quantities may cause risk of dust
explosion .
Flash Point (Method Used): Not applicable .
Flammable Limits
Lower Explosive Limit: Not available .
Upper Explosive Limit: Not available .
Auto-Ignition Temperature: Not available .
Explosion Data
Sensitivity to Mechanical Impact: Not available .
Sensitivity to Static Discharge: Not available .
Extinguishing Media: CO
chemical .
Special Fire Fighting Procedures: Fight fire from upwind
position . Avoid inhalation of smoke or gases . Wear self-
contained breathing apparatus .
Hazardous Combustion Products: Not available .
Toxicological Properties ______________
Routes of Entry: Inhalation, Ingestion, Eyes, Skin .
Effects of Acute Exposure:
Ingestion: LD
50
Dermal: LD : Not available .
50
Inhalation: LC
50
Eye Irritation: Non-Irritant (Rabbit)
Skin Irritation: Non-Irritant (Rabbit)
Exposure Limits: Not available .
Irritancy: Not available .
Sensitivity: Not available .
Effects of Chronic Exposure: No lung changes at all in the
lowest exposure level (1 mg/m
to potential human exposures . A minimal to mild degree
of fibrosis was noted in 22% of the animals at the middle
exposure level (4 mg/m
of fibrosis was observed in 92% of the rats at the highest
exposure level (16 mg/m
the higher exposure groups are interpreted in terms of "lung
overloading", a series of generic responses to the presence
of large quantities of respirable, insoluble and relatively
benign dusts retained for extended time periods in the lungs .
Lung tumor frequency was unchanged among rats exposed
to toner at the three exposure levels, and for air-only control
rats .
 - English
O=): 1 .2
2
, water spray, foam and dry
2
: >2 .500 (Rat)
: >5 .10 (Rat, 4 hour)
), the most relevant level
3
), and a mild to moderate degree
3
) . The lung changes observed in
3