Installation And Gas Boiler Data Collection Sheet - Weil-McLain SlimFit 2 Series Manual

SlimFit Series 2
®

Installation and Gas Boiler Data Collection Sheet

Boiler Model / Series SlimFit ________ / Series _______
CP Number: __________________
Flame signal on control display at HIGH fire: _________________
Was venturi changed? YES___ NO___
Boiler Settings
Boiler Model: SlimFit __________
Control Type: _________
High Altitude: YES___ NO___
Manual Reset High Limit Temp: ____˚F
WWSD Temp: ____˚F
Adjust Outdoor: ____˚F
Circulator Exercising
Circulator 1: ON___ OFF___
Circulator 2: ON___ OFF___
Circulator 3: ON___ OFF___
Boiler Circ: ON___ OFF___
Freeze Protection
Circulator 1: ON___ OFF___
Circulator 2: ON___ OFF___
Circulator 3: ON___ OFF___
Boiler Circ: ON___ OFF___
Assign Inputs
Input 1: Priority___ Aux___ OFF___
Source: TT1 ___ OR 0-10V ___
Input 2: Priority___ Aux___ OFF___
Input 3: Priority___ Aux___ OFF___
Max Rate Volts: __________V
Min Rate Volts: __________V
Temp Dependent: YES___ NO___
ODT Setpoint: ____˚F
Activate Contact
below setpoint: 1st____ 2nd____
118
commercial condensing gas
Fuel Type: Natural___
Was gas valve throttle adjusted? YES___ NO___
Network Settings
Boiler Address: ____
Net Max On Time: _____Min
Net Min On Time: _____Min
Max Rate On Net: _____%
Min Rate On Net: _____%
Rotation & Sequence
Sequence Type: ______
Base Rate High: _____%
Base Rate Low: _____%
Boiler Rotation Type: _________
Rotate Frequency: ____Days
Force Lead Rotation: YES or NO
Modbus Settings
Enable: YES___ NO___
Address: __________
Parity Bit: __________
Baud Rate: _________bps
Stop Bit: YES___ NO___
— Boiler Manual
-
fired water boiler
Date Installed: ___________________
BTU Input: ____________
Flame signal on control display at LOW fire: ____________
Was gas valve offset adjusted? YES___ NO___
Priority 1 Settings
System Type:
Target Mod Sensor:
Target Adjust:
Supply Max:
Supply Min:
OD Reset Max:
OD Reset Min:
Volts For Max:
Volts For Min:
Boost Time:
System Off Diff:
System On Diff:
Add BLR Diff:
Drop BLR Diff:
Mod Delay Time:
Stabilization Time:
Add Delay Time:
Drop Delay Time:
Max BLR Temp:
Boiler On Diff:
Boiler Off Diff:
Max On Time:
Run Boiler Pump:
Run Aux Pump/Output:
Pre Pump:
Post Pump:
Max Rate:
Min Rate:
Max System BTUs:
Min Boilers On:
Additional Heat Demand:
Response Time:
ODT
___________
___________
___________
___________˚F
___________˚F
___________˚F
___________˚F
___________ V
___________ V
___________ Mins
___________˚F
___________˚F
___________˚F
___________˚F
___________ Mins
___________ Mins
___________Sec
___________Sec
___________˚F
___________˚F
___________˚F
___________ Mins
YES___ NO___
YES___ NO___
___________Sec
___________Sec
___________%
___________%
__________ MBUTs
___________
1st___ 2nd___ OFF__
___________ Mins
YES___ NO___
Part number 550-100-561/0224