WELCOME Congratulations on your purchase and welcome to the Ariens family! Every machine in the Ariens lineup is designed for long-lasting and unsurpassed performance. We are confident your machine will be part of your family for many years to come.
The safety alert symbol above and signal penalties. Emission controls and components words below are used on decals and in this can only be adjusted by an Ariens dealer or manual. Read and understand all safety an authorized engine manufacturer's service messages.
5. Important ALWAYS replace missing or damaged safety decals. Replacement decal part numbers are IMPORTANT: Indicates general reference found in the parts manual for your machine information worthy of special attention. and may be ordered from your dealer. SAFETY DECALS See Figure 2 for safety decal locations.
Page 6
Safety Decal Descriptions 3. DANGER! 1. DANGER! Discharge Hazard - NEVER DANGER! operate unit without discharge chute in operating position. Thrown objects can cause injury or damage. Read and understand the DO NOT operate mower operator’s manual before unless all guards are in operating unit.
Page 7
3. Tipping Hazard Look behind when operating the unit in reverse. Avoid tipping hazard. 3. Loss of Traction Hazard If loss of traction is DO NOT operate on slopes experienced do the over 15°. following: DO NOT operate on slopes Disengage PTO.
SAFETY INSTRUCTIONS 6. HOT PARTS! The following safety instructions are based on B71.1, B71.4 specifications of the American National Standards Institute and DO NOT touch parts which are hot from operation. ISO 5395 in effect at the time of production. ALWAYS allow parts to cool.
Page 9
Children are often attracted to the machine explain it to them. Manuals are available in and the mowing activity. NEVER assume other languages at www.ariens.com. that children will remain where you last saw Only run the engine in well ventilated areas.
Page 10
Mow up and down slopes, NEVER across. Service Exercise caution when changing direction Keep machine in good working order. on slopes. Use caution while operating near Replace worn or damaged parts. dropoffs. Use caution when servicing blades. Wrap Avoid mowing wet grass. Wet surfaces can the blade(s) or wear gloves.
CONTROLS AND FEATURES Model 915285 Models 915281, 915283 Figure 3 1. Fuel Tank and Cap 11. Power Take-off (PTO) Knob 2. Fuel Level Window 12. Hour Meter 3. Oil Filter 13. Height-of-Cut Adjustment System 4. Oil Drain 14. Deck Lift Pedal 5.
Models 915281, 915283 WARNING: AVOID INJURY. See Figure 6. Read and understand the entire Safety section before proceeding. See Figure 3 for all controls and features Choke Off locations. IGNITION KEY See Figure 4. Controls power to the engine. The key cannot be removed when in run position.
PARKING BRAKE LEVER Blades On See Figure 10. Blades Off Controls the parking brake. The engine will not start with brake in the off position. Parking Brake Engaged (On) Figure 8 HOUR METER Hour meter measure engine runtime and cannot be reset. HEIGHT-OF-CUT ADJUSTMENT SYSTEM See Figure 9.
System by performing the tests in Check off. Engine will not run smoothly using partial Safety Interlock System on page 16. choke. Contact your Ariens dealer for repair if any of the tests fail. OPERATE UNIT 5. Set cutting height. See Figure 11.
• Do not allow grass or debris to collect WARNING: AVOID INJURY. inside of mower deck. Clean after each Move the steering levers use. slowly and keep the throttle at STOP THE ENGINE slow speed until you learn how to operate the unit. WARNING: AVOID INJURY.
MAINTENANCE WARNING: AVOID INJURY. Read and understand the Safety section before proceeding. Your Ariens dealer can provide service and adjustments to keep your unit operating at peak efficiency. Contact an authorized engine manufacturer’s service center for engine service. MAINTENANCE SCHEDULE...
SERVICE PARTS SERVICE POSITION See your Ariens dealer to purchase service Before starting any of the following parts for your unit. maintenance procedures: 1. Park unit on a flat, level surface. Description Qty. Part No. 2. Stop engine, remove key and wait for all HA Raw Laminated Belt –...
See Specifications on page 22 for recommended tire pressure. Check function of the Safety Interlock System by performing the tests below. Contact your Ariens dealer for repair if any of the tests fail. WARNING: AVOID INJURY. Explosive separation of tire Test Steering...
CHECK MOWER BLADES ADJUSTMENTS Check blades for wear and damage. Replace or sharpen as needed. WARNING: AVOID INJURY. CAUTION: AVOID INJURY. Use Read and understand the sturdy gloves or padding to Safety section before protect hands when working with proceeding. mower blades.
Page 20
Adjust Steering Level Reach See Figure 19. 1. Loosen hardware securing steering lever to upper control arm. 2. Pivot steering lever to desired position. 3. Ensure levers are aligned with each other. 4. Tighten hardware. 1. Adjusting Hole 2. Mounting Hole 3.
Connect spark plug wire(s) or replace spark plug(s) are faulty. spark plug(s). Refer to engine manual. Electrical system is faulty. Contact your Ariens dealer. Engine is faulty. Contact your Ariens dealer. Choke is in the on position. Move choke to the off position.
Page 22
TROUBLESHOOTING Problem Probable Cause Correction Mower blades not level or mower Level and adjust pitch of mower deck. deck pitch is incorrect. Refer to your unit’s Service Manual. Sharpen or replace mower blades. Refer Mower blades are dull or faulty. to your unit’s Service Manual.
ACCESSORIES 2. Tighten all hardware to correct specifications. See your Ariens dealer for a complete list of 3. Inspect unit for visible signs of wear or compatible accessories and attachments for damage. Repair as needed. your unit.
“Commercial Use.” If any product is rented or leased, then the duration of these warranties shall be 90 days after the date of purchase. An authorized Ariens dealer will repair any defect in material or workmanship, and repair or replace any defective part, subject to the conditions, limitations and exclusions set forth herein. Such repair or replacement will be free of charge (labor and parts) to the original purchaser;...
Page 26
Exclusions – Items Not Covered by This Warranty • Parts that are not genuine Ariens service parts are not covered by this warranty and may void the war- ranty if the parts result in premature wear or damage to the product.
Page 27
• Ensure that the maintenance and adjustments explained in the Operator’s Manual are routinely completed. • Promptly notify AriensCo or an authorized Ariens service representative of the need for warranty service. • Transport the product to and from the place of warranty service at owner’s expense.
Page 28
AriensCo shall not be held liable for damages, including premature wear and tear, or injuries caused by installation of unauthorized parts and accessories or for parts and accessories not installed by an authorized Ariens dealer. Australian Consumer Law The following applies solely to warranties subject to Subsection 102(1) of the Australian Consumer Law: Our goods come with guarantees that cannot be excluded by the Australian Consumer Law.
Page 30
655 West Ryan Street Brillion, WI 54110 www.ariens.com parts.ariens.com...