Start Up Sheet - Johnson Controls TM8E Installation Manual

SECTION XII: START UP SHEET
Start-Up Date
Technician Performing Start-Up
Owner Information
Name
City
Equipment Data
Furnace Model
Indoor Coil Model
Outdoor Unit Model
Furnace Configuration
Filter, Thermostat, Accessories
Filter Type
Thermostat Type
Connections -- All Per Installation Instructions and Local Code
Unit is level Gas piping is connected (including drip leg)
Vent system is connected
Venting: B Vent
Vertical Termination
Horizontal Term. (with External Power Vent)
Venting: Lined Masonry Chimney
B Vent Connector
# of 90 Degree Ells
Venting system is the proper size, within the limitations of the chart in the
installation instructions, properly connected to the furnace, and properly pitched
Electrical: Line Voltage
Polarity is correct (black is L1 (hot), white is N (neutral)
Electrical: Low Voltage
Thermostat wiring is complete
Low voltage value between "R" and "C" on furnace control board (volts AC)
Johnson Controls Ducted Systems
33" 80% AFUE Single Stage Gas Furnace Start Up Sheet
Proper furnace start up is critical to customer comfort and equipment longevity
State or Province
Horizontal Left
Filter Size
Other System Equipment and Accessories
Vent Pipe Size # of 90 Degree Ells
Connector Size Connector Length
Vent Pipe Size
Single Wall Connector Connector Size
# 0f 45 Degree Ells
Thermostat heat anticipator set to .45 (if present)
Installing Contractor Name
Address
Furnace Serial
Indoor Coil Serial
Outdoor Unit Serial
Horizontal Right
Filter Location(s)
Supply plenum and return air are connected
# 0f 45 Degree Ells
# of 90 Degree Ells
Connector Length
Other appliances in same common vent:
Water Heater BTUH Input
Furnace BTUH Input
Other BTUH Input
Ground wire is connected
5594752-UIM-C-1119
Zip or Postal Code
Total Height
# 0f 45 Degree Ells
Chimney Height
Fan Assisted?
Fan Assisted?
Fan Assisted?
Line voltage to furnace (AC)
Continued on next Page
Y N
N
Y
Y N
27