Table of Contents
Advertisement
30
en | Installing Roof Parapet and Pipe Mounts
2.6
Installing the VG4-A-9543 Pipe Mount
This section details the installation steps for the VG4-A-9543 Pipe Mount. If you are installing
the Roof Parapet mount, see Figure 2.9 on page 28 for instructions.
NOTICE! Customer must supply 1-1/2 inch (NPS) pipe threaded on both ends with a minimum
i
length of 5 inches (12.7 cm).
Fig. 2.11 Pipe Mount
1.
Before installing the Top-Mounting Flange, ensure there is an adequate opening in the
ceiling or mounting structure for the wires to pass through.
2.
Secure the pipe Flange with supplied gasket to the ceiling or other supporting structure
using four (4) 10-mm (3/8-inch) diameter fasteners.
NOTICE! Each fastener must have a minimum pullout strength of 275 kg (600 lbs). The
i
mounting material must be able to withstand this pull out force. For example, 19-mm
(3/4-inch) minimum for plywood.
3.
Attach pipe (not supplied) to the Top-Mounting Flange and secure it with the set screw.
WARNING! You must thread the pipe onto the Top-Mounting Flange until it is tight, then
!
secure it with the set screw. Failure to do so can result in damage, serious injury or death.
4.
Route the power, video, control, and alarm wires through the Top-Mounting Flange and
down the pipe.
5.
Apply the supplied thread sealant to the threads on the Pipe.
a.
b.
c.
6.
Thread the Pipe Cap onto the down pipe and tighten securely to prevent leaks. Then
secure it with the set screw. See Figure 2.10 on page 29.
WARNING! You must thread the Dome Cap onto the pipe until it is tight, then secure it with
!
the set screw. Failure to do so can result in damage or serious injury or death.
F01U010921 | 1.0 | 2006.10
Gasket
GASKET
Flange
FLANGE
5 in.
5 in.
min.
12.7 cm min.
12.7 cm
CAP
Cap
Make sure all surfaces are clean and dry.
Apply a bead of sealant completely around the leading threads of the male fitting.
Force the adhesive into the threads to thoroughly fill all voids.
Installation Manual
AutoDome Modular Camera System
Bosch Security Systems, Inc.
Advertisement
Table of Contents
