Table Of Contents - Graco Sherwin-Williams ULTIMATE Mx 795 Owner's Manual

Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Component Function and Identification
Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Startup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shutdown and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Flushing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Spin Test . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Repair Information
Motor Brush Replacement
Power Supply Cord Replacement
On/Off Switch Replacement
Pressure Control Repair
Warning Symbol
WARNING
his symbol alerts you to the possibility of serious
injury or death if you do not follow the instructions.
EQUIPMENT MISUSE HAZARD
Equipment misuse can cause the equipment to rupture or malfunction and result in serious injury.
INSTRUCTIONS
This equipment is for professional use only.
Read all instruction manuals, tags, and labels before operating the equipment.
Use the equipment only for its intended purpose. If you are not sure, call your Graco distributor.
Do not alter or modify this equipment. Use only genuine Graco parts.
Check equipment daily. Repair or replace worn or damaged parts immediately.
Do not exceed the maximum working pressure of the lowest rated system component. Refer to the
Technical Data on page 31 for the maximum working pressure of this equipment.
Use fluids and solvents which are compatible with the equipment wetted parts. Refer to the Tech-
nical Data section of all equipment manuals. Read the fluid and solvent manufacturer's warnings.
Do not use 1,1,1-trichloroethane, methylene chloride, other halogenated hydrocarbon solvents or
fluids containing such solvents in pressurized aluminum equipment. Such use could result in a
chemical reaction, with the possibility of explosion.
Do not use hoses to pull equipment.
Route hoses away from traffic areas, sharp edges, moving parts, and hot surfaces. Do not expose
Graco hoses to temperatures above 82 C (180 F) or below -40 C (-40 F).
Do not lift pressurized equipment.
Comply with all applicable local, state, and national fire, electrical, and safety regulations.

Table of Contents

. . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
Symbols
WARNING
2 Bearing Housing & Connecting Rod Replacement
5
Drive Housing Replacement
6
Motor Replacement
7
Displacement Pump Repair
9
Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
10
Technical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
11
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
17
Parts Drawing - Sprayer
16
Parts List - Sprayer
18
Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
19
Graco Phone Number
19
21 Sherwin-Williams Warranty
Caution Symbol
This symbol alerts you to the possibility of damage to
or destruction of equipment if you do not follow the
instructions.
. . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
CAUTION
. 24
25
27
29
31
31
31
32
33
35
36
36