Volvo Penta TAMD71B Instruction Manual page 6

Never use start spray or similar agent to start the engine, it could cause an explosion in the inlet
manifold. Danger of personal injury.
Avoid opening the coolant filler cap when the engine is hot. Steam or hot coolant can spray out
and the system pressure will be lost. Open the filler cap slowly and release coolant system pres-
sure, if the filler cap or a drain cock/venting cock must be opened, or if a plug or engine coolant
line must be removed on a hot engine. Steam or hot coolant can spray out.
Stop the engine and close the seacock valve before carrying out operations on the engine cool-
ing system.
Only start the engine in a well-ventilated area. If operating the engine in a closed area ensure
that there is exhaust ventilation leading out of the work area to remove exhaust gases and
crankcase ventilation emissions.
Anti-corrosion agents are hazardous to health. Read the instructions on the product packaging!
Anti-freeze agents are hazardous to health. Read the instructions on the product packaging!
Certain engine conservation oils are inflammable. Some of them are also dangerous if breathed
in. Ensure good ventilation in the work place. Use a protective mask when spraying.
Hot oil can cause burns. Avoid getting hot oil on the skin. Ensure that the lubrication system is
not under pressure before carrying out any work. Never start or operate the engine with the oil
filler cap removed, otherwise oil could be ejected.
Never allow an open flame or electric sparks near the batteries. Never smoke in proximity to the
batteries. The batteries give off hydrogen gas during charging which when mixed with air can
form an explosive gas -oxyhydrogen. This gas is easily ignited and highly volatile. Incorrect con-
nection of the battery can cause a single spark which is sufficient to cause an explosion with re-
sulting damage. Do not shift the connections when attempting to start the engine (spark risk)
and do not lean over any of the batteries. Refer to instructions in the Instruction Book.
Always ensure that the Plus (positive) and Minus (negative) battery leads are correctly installed
on the corresponding terminal posts on the batteries. Incorrect installation can result in serious
damage to the electrical equipment. Refer to the wiring diagrams.
Always use protective goggles when charging and handling the batteries. Battery electrolyte
contains sulfuric acid which is highly corrosive. Should the battery electrolyte come into contact
with unprotected skin wash off immediately using plenty of water and soap. If battery acid comes
in contact with the eyes, immediately flush with plenty of water and obtain medical assistance
without delay.
Turn the engine off and turn off the power at the main switches (breakers) before carrying out
work on the electrical system.
If mounted: Block the starting valve (hydraulic starter). Shut off air supply to air starter.
4 AB Volvo Penta / Diesel Engine TAMD71B