Table of Contents
Advertisement
Quick Links
CAUTION! Risk of Fire! DO NOT store instruction manuals inside fireplace cavity.
High temperatures could cause a fire.
INSTALLER: Leave this manual with the appliance, not inside the appliance.
CONSUMER: Retain this manual for future reference. Do not store inside the appliance.
Contact your dealer with questions regarding installation, operation or service.
NOTICE: DO NOT discard this manual!
Models:
This appliance may be installed as an OEM
installation in manufactured home (USA
only) or mobile home and must be installed
in accordance with the manufacturer's
instructions and the Manufactured Home
Construction and Safety Standard, Title 24
CFR, Part 3280 in the United States, or the
Standard for Installation in Mobile Homes,
CAN/CSA Z240 MH Series, in Canada.
This appliance is only for use with the type(s)
of gas indicated on the rating plate. This
appliance is not convertible for use with other
gases, unless a certified kit is used.
Heat & Glo • SL-5/5LP-IFT, SL-7/7LP-IFT, SL-9/9LP-IFT Owner's Manual • 2632-981 Rev. D • 1/21
Owner's Manual
Operation and Maintenance
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly
could result in serious injury, death, or
property damage.
• DO NOT store or use gasoline or other flam-
mable vapors and liquids in the vicinity of this
or any other appliance.
• What to do if you smell gas
- DO NOT try to light any appliance.
- DO NOT touch any electrical switch. DO
NOT use any phone in your building.
- Leave the building immediately.
- Immediately call your gas supplier from
a neighbor's phone. Follow the gas sup-
plier's instructions.
- If you cannot reach your gas supplier, call
the fire department.
• Installation and service must be performed
by a qualified installer, service agency, or the
gas supplier.
DANGER
DO NOT TOUCH GLASS
NEVER ALLOW CHILDREN
A barrier designed to reduce the risk of
burns from the hot viewing glass is provided
with this appliance and must be installed for
the protection of children and other at-risk
individuals.
Decorative barrier front must be ordered separately at
time of appliance purchase.
HOT GLASS WILL
CAUSE BURNS.
UNTIL COOLED.
TO TOUCH GLASS.
1
Advertisement
Table of Contents
Troubleshooting
Related Manuals for Heat & Glo SL-5LP-IFT
Summary of Contents for Heat & Glo SL-5LP-IFT
- Page 1 Owner’s Manual Operation and Maintenance CAUTION! Risk of Fire! DO NOT store instruction manuals inside fireplace cavity. High temperatures could cause a fire. INSTALLER: Leave this manual with the appliance, not inside the appliance. CONSUMER: Retain this manual for future reference. Do not store inside the appliance. Contact your dealer with questions regarding installation, operation or service.
-
Page 2: Welcome
Welcome Read this manual before operating this appliance. Please retain this Owner’s Manual for future reference. Read the Installation Manual before making any installation or finishing changes. A. Congratulations This owner’s manual should be retained for future reference. We suggest that you keep it with your other Congratulations on selecting a Heat &... -
Page 3: Table Of Contents
Safety Alert Key: • DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury. • WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury. • CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury. •... -
Page 4: Limited Lifetime Warranty
B. Limited Lifetime Warranty Hearth & Home Technologies LLC LIMITED LIFETIME WARRANTY Hearth & Home Technologies LLC (“HHT”) extends the following warranty for HHT gas, wood, pellet and electric hearth appliances (each a “Product” and collectively, the “Product(s)”) and certain component parts set forth in the table below (“Component Part(s)”) that are purchased from a HHT authorized dealer or distributor. - Page 5 B. Limited Lifetime Warranty (continued) WARRANTY CONDITIONS: • Because HHT cannot control the quality of any Products sold by unauthorized sellers, this Warranty only covers Products that are purchased through an HHT authorized dealer or distributor unless otherwise prohibited by law; a list of HHT authorized dealers is available on the HHT branded websites.
-
Page 6: Product Specific Information
Product Specific Information A. Appliance Certification B. Glass Specifications Hearth & Home Technologies appliances manufactured MODELS: SL-5-IFT, SL-5LP-IFT, SL-7-IFT, SL-7LP-IFT, with tempered glass may be installed in hazardous lo- SL-9-IFT, SL-9LP-IFT cations such as bathtub enclosures as defined by the LABORATORY: Underwriters Laboratories, Inc. -
Page 7: Important Safety And Operating Information
Important Safety and Operating Information • Consider not using the fireplace when children will be A. Appliance Safety present. WARNING! DO NOT operate fireplace before reading Contact your dealer for more information, or visit: www. and understanding operating instructions. Failure hpba.org/Product-Info/Fireplace-Stove-Heater/Glass- to operate fireplace according to operating instructions Fronts-Safety. -
Page 8: General Operating Parts
D. Wall and Mantel Temperatures B. General Operating Parts ANSI/CSA Standards Figure 3.2 references the general operating parts of the The American National Standards Institute (ANSI) and appliance and the section of this manual in which they are Canadian Standards Association (CSA) write the safety discussed. - Page 9 Good Faith Guidelines for TV Installations Above Appliance TV recessed into the wall TV on the wall TV Wall Bracket Item Minimum Dimensions 2.5 inches 2 inches minimum to 3 inches maximum 18 inches Wall Brkt + TV Thickness + 2.5 inches Mantel Appliance...
-
Page 10: Before Lighting Appliance
F. Before Lighting Appliance Before operating this fireplace for the first time, it is rec- ommended that a qualified service technician: • Verify all shipping materials have been removed from inside and/or underneath the firebox. • Review proper placement of logs, ember material and/ or other decorative materials. -
Page 11: Lighting Instructions (Ipi)
G. Lighting Instructions (IPI) Heat & Glo • SL-5/5LP-IFT, SL-7/7LP-IFT, SL-9/9LP-IFT Owner’s Manual • 2632-981 Rev. D • 1/21... -
Page 12: Appliance Break-In
I. Heat Management H. Appliance Break-In Heat Output NOTICE! Open windows for air circulation during fire- • Change hi/lo setting on valve place break-in. • Change fan speed • Some people may be sensitive to smoke and odors. • Smoke detectors may activate. If an optional fan is installed, the fan speed is controlled Follow the initial break-in procedure below to cure the by adjusting the speed control knob. -
Page 13: Operation During A Power Outage - Intellifire Touch
J. Operation During A Power Outage - IntelliFire Touch ® The IntelliFire Touch intermittent pilot ignition system To Return to Operation Using Electrical (AC) Power comes with a battery backup system that enables the Standard Wall Switch or Factory-Installed ON/OFF system to operate in a power outage. -
Page 14: Detailed Component Operating Instructions
K. Detailed Component Operating 3. The Pilot button on the IFT-ECM activates the Cold Climate function of the fireplace. This function lights Instructions - IntelliFire Touch the pilot flame ONLY to provide enough heat in the IFT-ECM Detailed Operating Instruction firebox to reduce condensation in cool, high humidity ambient conditions. - Page 15 - Wait five (5) minutes to allow possible Appliance ON/OFF: accumulated gas to clear. A wall control, thermostat or remote control may be used to control the ON/OFF function of the appliance. Follow - Set the IFT-ECM 3-position selector switch to ON instructions included with the installed control.
-
Page 16: Maintenance And Service
Maintenance and Service Glass Cleaning IMPORTANT! Any safety screen, decorative barrier front or guard removed for servicing must be replaced prior to Frequency: Seasonally operating the fireplace. By: Homeowner When properly maintained, your fireplace will give you Tools Needed: Protective gloves, gas fireplace glass many years of trouble-free service. - Page 17 Venting and Termination Cap • Carefully set fixed glass assembly in place on fireplace. Hold glass in place with one hand and secure all glass Frequency: Seasonally latches with the other hand. By: Homeowner • Inspect and operate all glass latches to ensure they Tools needed: Protective gloves and safety glasses.
-
Page 18: Maintenance Tasks - Qualified Service Technician
C. Maintenance Tasks - Qualified Service Pilot and Burner Ignition and Operation Technician Frequency: Annually By: Qualified Service Technician The following tasks must be performed by a qualified ser- vice technician. Tools needed: Protective gloves, vacuum cleaner, whisk broom, flashlight, voltmeter, indexed drill bit set, and a Gasket Seal and Glass Assembly Inspection manometer. - Page 19 Figure 4.2 IPI Pilot Flame Patterns Electrical Service and Repair WARNING! Risk of Shock! Label all wires prior to dis- connection when servicing controls. Wiring errors could cause improper and dangerous operation. Verify proper operation after servicing. WARNING! Risk of Shock! Replace damaged wire with type 105º...
-
Page 20: Frequently Asked Questions And Troubleshooting
Frequently Asked Questions and Troubleshooting A. Frequently Asked Questions - Appliance ISSUE SOLUTIONS This is a result of gas combustion and temperature variations. Prior to appliance being turned on, the inside of the glass has cooled below the dew point producing a byproduct of combus- tion: water in the form of condensation. -
Page 21: Frequently Asked Questions - Intellifire Touch Controls (Optional Ift-Rc400)
B. Frequently Asked Questions - IntelliFire Touch Controls (Optional IFT-RC400) Symptom Possible Cause Corrective Action The appliance does not respond to Batteries are depleted. Verify batteries are new. commands from the remote control display does not light up when Batteries are incorrectly Verify batteries are installed in correct orientation as shown on screen is touched. -
Page 22: Troubleshooting
C. Troubleshooting With proper installation, operation, and maintenance your gas appliance will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist a qualified service technician in the diagnosis of a problem and the corrective action to be taken. This troubleshooting guide can only be used by a qualified service technician. Contact your dealer to arrange a service call by a qualified service technician. - Page 23 IntelliFire Touch - (continued) Symptom Possible Cause Corrective Action Verify incoming gas line ball valve is ‘Open’. Verify inlet pres- No gas supply. sure is within requirement for gas type used. Contact gas sup- plier. Pilot sparks but does not light, after Verify wiring, check valve harness black wire is securely ECM has poor ground.
-
Page 24: Reference Materials
Reference Materials A. Accessories Install approved accessories per instructions included with accessories. Contact your dealer for a list of ap- proved accessories. WARNING! Risk of Fire and Electric Shock! Use ONLY Hearth & Home Technologies-approved optional acces- sories with this appliance. Using non-listed accessories could result in a safety hazard and will void the warranty. -
Page 25: Service Parts
SL-5-IFT, SL-5LP-IFT B. Service Parts Service Parts Beginning Manufacturing Date: March 2020 32” Gas Fireplace - DV Ending Manufacturing Date: Active Log Set Assembly IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. - Page 26 SL-7-IFT, SL-7LP-IFT Service Parts Beginning Manufacturing Date: March 2020 36” Gas Fireplace - DV Ending Manufacturing Date: Active Log Set Assembly IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor.
- Page 27 SL-9-IFT, SL-9LP-IFT Service Parts Beginning Manufacturing Date: March 2020 42” Gas Fireplace - DV Ending Manufacturing Date: Active Log Set Assembly IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor.
- Page 28 SL-IFT Service Parts Beginning Manufacturing Date: March 2020 Ending Manufacturing Date: Active #9 Valve Assembly 9.15 9.14 9.13 9.12 9.10 9.11 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor.
- Page 29 SL-IFT Service Parts Beginning Manufacturing Date: March 2020 Ending Manufacturing Date: Active IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
-
Page 30: Contact Information
C. Contact Information Heat & Glo, a brand of Hearth & Home Technologies 7571 215 Street West, Lakeville, MN 55044 www.heatnglo.com Please contact your Heat & Glo dealer with any questions or concerns. For the location of your nearest Heat & Glo dealer, please visit www.heatnglo.com.