Maintenance - Woods TURF BATWING TBW150C Operator's Manual

ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED!
stopped when anyone comes within 300 feet (92
m).
• This shielding is designed to reduce the risk of
thrown objects. The mower deck and protective
devices cannot prevent all objects from escaping
the blade enclosure in every mowing condition. It
is possible for objects to ricochet and escape,
traveling as much as 300 feet (92 m).
• Check that chain shielding is in good condi-
tion and replace any damaged chain links.
 Do not put hands or feet near rotating parts or
under the machine. Keep clear of the discharge
opening at all times.
 Avoid discharging material against a wall or
obstruction. It is possible for objects to ricochet
and escape, traveling as much as 300 feet (92 m).
 Stop the blade(s) when crossing gravel sur-
faces.
 Do not operate machine when shields or guards
are removed.
 Always comply with all state and local lighting
and marking requirements. Turn on flashing warn-
ing lights whenever traveling on a public roadway.
 Tragic accidents can occur if the operator is not
alert to the presence of children. Children are often
attracted to the machine and the mowing activity.
Never assume that children will remain where you
last saw them.
 Keep children out of the operating area and
under the watchful care of a responsible adult
other than the operator.
 Do not carry children, even with the blade(s)
shut off. Children could fall off and be seriously
injured or interfere with safe machine operation.
Children who have been given rides in the past
could suddenly appear in the mowing area for
another ride and be run over or backed over by the
machine.
 Never direct discharge toward people, animals,
or property.
 Do not operate or transport equipment while
under the influence of alcohol or drugs.
 Operate only in daylight or good artificial light.
 Keep hands, feet, hair, and clothing away from
equipment while engine is running. Stay clear of all
moving parts.
 Never allow riders on power unit or attachment.
(Rev. 7/29/2021)
TBW Safety Rules (Rev. 12/5/2008)
SAFETY RULES
 Power unit must be equipped with ROPS or
ROPS cab and seat belt. Keep seat belt securely
fastened. Falling off power unit can result in death
from being run over or crushed. Keep foldable
ROPS system in "locked up" position at all times.
 Always sit in power unit seat when operating
controls or starting engine. Securely fasten seat
belt, place transmission in neutral, engage brake,
and ensure all other controls are disengaged
before starting power unit engine.
 Operate tractor PTO at 540 RPM. Do not exceed.
 Connect PTO driveline directly to power unit
PTO shaft. Never use adapter sleeves or adapter
shafts. Adapters can cause driveline failures due to
incorrect spline or incorrect operating length and
can result in personal injury or death.
 Do not operate mowers on terrain that raises
mowers beyond 25 degrees. Exceeding this design
limit will result in U-joint "knocking noise" and
potential driveline failure and could cause driveline
to pull apart.
 Look down and to the rear and make sure area
is clear before operating in reverse.
 Do not operate or transport on steep slopes.
Refer to tractor manual for proper ballasting and
slope recommendations.
 Do not stop, start, or change directions sud-
denly on slopes.
 Use extreme care and reduce ground speed on
slopes and rough terrain.
 Watch for hidden hazards on the terrain during
operation.
 Stop power unit and implement immediately
upon striking an obstruction. Dismount power unit,
using proper procedure. Inspect and repair any
damage before resuming operation.
 Always connect safety chain from equipment to
towing vehicle when transporting.

MAINTENANCE

 Before dismounting power unit or performing
any service or maintenance, follow these steps:
disengage power to equipment, lower the 3-point
hitch and all raised components to the ground,
operate valve levers to release any hydraulic pres-
sure, set parking brake, stop engine, remove key,
and unfasten seat belt.
 Before performing any service or maintenance,
disconnect driveline from tractor PTO.
Safety 7