Bradford White RG130T N Series Service Manual page 5

It is intended for this manual to be used by qualified service personnel for the primary purpose
of troubleshooting and repair of the Bradford White DV Series water heaters.
The Honeywell Icon Gas Control will display status codes in the event of abnormal operation.
Status codes are listed in the troubleshooting charts found in this service manual. The
troubleshooting charts will also indicate the probable cause for the status code and direct the
service professional to a service procedure to properly diagnose the abnormal operation.
In some difficult to diagnose conditions, it may be necessary to isolate the heater from the vent
system to determine the problem.
Contact the Bradford White technical support group immediately if diagnosis cannot be made
using the methods described in this service manual.
Manometer: A liquid "U" tube type or a digital (magnahelic) type can be
Multi-Meter: A digital type is strongly recommended. This device is used
Electronic Probes: In some cases, standard multi-meter probes will damage or
Thermometer: Used to measure water temperature. An accurate
Water Pressure Gage: Used to measure water supply pressure. Also used to
Various Hand Tools: Pipe wrench, channel locks, open end wrenches (3/8", 7/16",
Tools Required for Service
used. This device is used to measure gas and/or air pressure
and vacuum.
to measure electrical values. The meter you select must have
the capability to measure volts AC, volts DC, amps,
micro-amps, and ohms.
simply not be effective to obtain certain voltage and ohm
readings. It will be necessary to have special electronic "pin"
type multi-meter probes. These probes are available at most
electronic wholesale outlets.
thermometer is recommended.
determine tank pressure by adapting to the drain valve of the
heater.
1/2"), 12" crescent wrench, allen wrench set, screw drivers
(common & Phillips), 1/4" nut driver, pliers (common & needle
nose), socket set, side cutters, wire cutters, wire strippers,
wire crimpers, torpedo level, small shop vacuum, step ladder,
flashlight, and 5-gallon pail.
5
5