Superior Fireplaces VRT3536WS Installation And Operation Instructions Manual page 13

Installation Instructions -
FBK-100 or FBK 200 Blower Kits and JBK Junction Box Kit
IMPORTANT
All electrical wiring must be performed by licensed Elec-
tricians. Electrical wiring must comply with the National
Electrical Code ANSI/ NFPA 70 - latest edition
Step 1. Follow the instructions below for the model you are installing:
Models VRT3536WS, VRT3536WH, VRT3542WS & VRT3542WH:
Lift out the bottom refractory panel (see Figure 16).
Step 2. Remove the rectangular knock-out (for J-Box) on the right side
of unit (see Figure 7 for location). Install the Junction Box & Electrical
outlet below the firebox floor into the rectangular opening on the right
side cabinet panel where you removed the knock-out (see Figures 18
and 19). The Junction Box / Electrical Kit is sold separately (see Page
15 for ordering information).
• Squeeze the J-Box flanges together to fit into the opening shown in
Figures 18 and 19.
• Wires will need to be passed through the hole shown in Figure 17.
• An approved strain relief bushing (not supplied with the kit), is required
to restrain the wires (see Figure 17).
Step 3. Loosely tie a knot in the power cord to take up slack (see Figure 20).
Step 4. Locate the tabs shown in Figure 21. Position the blower assembly
so that the tabs (located on the cabinet base) are seated in the notches of
the blower bracket. Bend the tabs over to secure the blower assembly (see
Figure 22).
Step 5. Plug power cord into the electrical outlet as illustrated in Figure 14.
Lift Out Bottom Refractory Panel
Models: VRT3536WS,
VRT3536WH, VRT3542WS
& VRT3542WH
Figure 16
Remove knock-out
(strain relief bush-
ing [not supplied]
presses into this
hole around romex
wires - see Step 8 on
Page 14).
Figure 17 -
Firebox
floor
Figure 18 -
J-Box Flanges
Figure 19
NOTE: DIAGRAMS & ILLUSTRATION ARE NOT TO SCALE.
Cover Plate
Screw
Junction Box Kit (all models)
J-Box & Electrical Outlet
Install into side wall rectanular opening
Model VRT3542WS Shown
Right Outside Cabinet Panel
Wires
J-Box &
Receptacle
J-Box Flange
J-Box &
Electrical
Outlet
13