Battery Installation - Suzuki DF150AP Owner's Manual

BATTERY INSTALLATION

Secure the battery in a dry area of the boat,
away from vibration.
NOTE:
• It is recommended that the battery be
installed in an enclosed battery case.
• When connecting batteries, hexagon-nuts
must be used to secure battery leads to bat-
tery posts.
To hook up the battery, first connect the red
lead from the motor to the positive battery ter-
minal, then connect the black lead to the nega-
tive battery terminal.
Red lead
Sub battery
cable
White lead
Hexagon-nut
 WARNING
If you place the battery near the fuel tank,
a spark from the battery may ignite the
gasoline, causing a fire and/or an explo-
sion.
Do not place the fuel tank in the same
compartment/area as the battery.
To remove the battery, first disconnect the black
lead from the negative terminal, then discon-
nect the red lead from the positive terminal.
Connecting and disconnecting the battery as
described above will help minimize the chance
of creating an accidental short circuit and
sparks.
Suzuki recommends that you install the termi-
nal cap on the positive battery terminal to pre-
vent an accidental short circuit of battery
terminals.
If a terminal cap is required, contact your autho-
rized Suzuki marine dealer.
Batteries produce flammable hydrogen
gas and may explode if they are near
Black
lead
flames or sparks.
Never smoke or cause sparks when work-
ing near the battery. Keep the battery
away from open flames. To avoid creating
a spark when charging the battery, con-
nect the battery charger cables to the
proper terminals before turning the
charger on.
Battery acid is poisonous and corrosive.
It can cause severe injury and can dam-
age painted surfaces.
Avoid contact with eyes, skin, clothing,
and painted surfaces. If battery acid
comes in contact with any of these, flush
immediately with large amounts of water.
If acid contacts the eyes or skin, get
immediate medical attention.
 WARNING
 WARNING
13