General Information - HUSTLER TrimStar General Service Manual

®
Hustler TrimStar Service Program
This manual is part of a service package for the Hustler
TrimStar mowers. Use of this manual in conjunction with other
®
Hustler TrimStar mower and component manuals will provide
the information necessary to service and maintain Hustler
TrimStar mowers.
This maintenance manual is a service guide for use by Service
Technicians. It provides the necessary information needed to
perform normal maintenance requirements on these units.
The Parts Manual provides a complete parts listing for the
unit. Use this manual when ordering parts.
The Operator's Manual provides fundamental operational
information and operational safety that is needed when operat-
ing the mower.
The component manuals are furnished by the various manu-
facturers to be used for the troubleshooting and servicing of
their products.
Maintenance Introduction
Regular maintenance is the best prevention for costly down-
time or expensive, premature repair. The following pages con-
tain suggested maintenance information and schedules which
the operator/mechanic should follow on a routine basis.
Remain alert for unusual noises, they could be signaling a
problem. Visually inspect the machine for any abnormal wear or
damage. A good time to detect potential problems is while per-
forming scheduled maintenance service. Correcting the problem
as quickly as possible is the best insurance.
Clear away heavy build-up of grease, oil and dirt, especially
114674_0512

GENERAL INFORMATION

in the engine and hydraulic reservoir areas; minute dust particles
are abrasive to close-tolerance engine and hydraulic assemblies.
Daily inspect mower for grass clippings and wire and string
®
tangles. The underside of the mower deck will collect a build-up
of grass clippings and dirt, especially when grass is wet or has
high moisture content. This build-up will harden, restricting
®
blade and air movement and will probably show a poorer quality
of cutting. Therefore it should be removed routinely.
To do this it will be necessary to raise and block the deck,
using jack stands or blocks, in the full up position and scrape the
build-up from underneath.
Some repairs require the assistance of a trained service
mechanic and should not be attempted by unskilled personnel.
Consult your Hustler
assistance is needed.
Information included in this manual was current at the time of
printing, but subsequent production changes may cause your
machine to vary slightly in detail. Hustler
reserves the right to redesign and change the machine as deemed
necessary, without notification. If a change has been made to
your machine which is not reflected in this service manual con-
tact the Customer Service Department at Hustler
ment for additional information.
Warranty
Warranty repair must be performed by a Hustler
ment Authorized Dealer before warranty credit can be allowed.
Work performed by anyone other than an Authorized Dealer
will invalidate the warranty claim and warranty credit will not
be approved.
1-1
®
Turf Equipment service center when
®
Turf Equipment
®
Turf Equip-
®
Turf Equip-
REV B