Battery Safety; Section 3 - Instructions - Powermate ALUMINUM L Series Operating Manual

SAFETY IN MOTION
Stay alert. Should something break, loosen, or malfunction, on your machine, stop
work and seek qualified assistance to correct the condition. When going down a
ramp or incline, always walk ahead of the machine and use the open/close controls
to engage the rubber guard (foot) with the ground to act as a brake. Do not allow
the loaded PowerMate
®
PowerMate unit down a stair without a load, always push the wheels off the step
before lowering the wheels to the next step.
Do not compress the top urethane bumper when the machine is under load.

BATTERY SAFETY

Lead-acid batteries contain hydrogen-oxygen gases that can be explosive and
sulphuric acid that can cause severe burns. To help avoid risk of danger and injury,
observe these precautions when handling or working with a lead-acid battery.
Wear ANSI approved safety glasses or goggles and a face shield. Wear proper
clothing to protect hands, and body. Wear appropriate rubber gloves and apron.
Never lean over a battery when testing or charging. Cigarettes, flames or sparks,
could cause a battery to explode. Keep all ignition sources away from battery. Do
not strike the sides of a battery with any spark producing item. Make sure work
area is well-ventilated.
Never touch both battery terminals with bare hands at the same time. Remove
rings, watches and dangling jewelry when working with batteries. The metal in the
jewelry can cause a shock and burns if contacted with the battery terminals.
Only use insulated/non-conducting tools when making connections on a battery.
Never lay tools or other parts on top of a battery.
Because the batteries used in L P International products are of the sealed type,
the battery should be replaced if there is evidence of spillage. If there is spilled
sulphuric acid present, neutralize with baking soda. Never remove vent caps on a
sealed battery. In the event of an accident, flush with water and call a physician
immediately. If venting gas is significantly inhaled, seek immediate medical
attention.
Never store batteries with explosives, flammable materials, chemicals, or food.
Protect batteries from crushing, punctures and shorting.
Do not charge or use booster cables or adjust battery connections without proper
instructions and training.
Keep batteries out of reach of children.
Do not accumulate used batteries. Dispose used batteries in accordance with
local environmental laws.
continued
®
to attain an un-controllable speed. When moving a
2.07
®
PowerMate Operation Manual
PN 010140 Rev.E
Eng. 04/ 25/ 14