Troubleshooting; Specifications - Briggs & Stratton 030670-00 Manual

Troubleshooting

Problem
Engine is running, but no
AC output is available.
Engine runs well at no-load
but "bogs down" when
loads are connected.
Engine will not start; starts
and runs rough or shuts
down when running.
For all other issues, see a Briggs & Stratton Authorized Dealer.

Specifications

Model 1200A
Starting Surge . . . . . . . . . . . . . . . . . . . . . . . . 1,125 Watts
Wattage* . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 900 Watts
AC Voltage at 230 Volts . . . . . . . . . . . . . . . . . . 3.9 Amps
Frequency. . . . . . . . . . . . . . . . . . . . . . . 50 Hz at 3600 rpm
Phase . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Single Phase
Displacement . . . . . . . . . . . . . . . . . . 79.8 cc (4.87 cu. in.)
Spark Plug Gap . . . . . . . . . . . . . . . . . 0.76 mm (0.030 in.)
Fuel Capacity . . . . . . . . . . . . 5.7 Liters (1.5 U.S. Gallons)
Oil Capacity . . . . . . . . . . . . . . . 0.35 Liters (11.8 Ounces)
Model 2200A
Starting Surge . . . . . . . . . . . . . . . . . . . . . . . . 2,125 Watts
Wattage* . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1,700 Watts
AC Voltage at 230 Volts . . . . . . . . . . . . . . . . . . 7.4 Amps
Frequency. . . . . . . . . . . . . . . . . . . . . . . 50 Hz at 3600 rpm
Phase . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Single Phase
Displacement . . . . . . . . . . . . . . . . . . 196 cc (11.96 cu. in.)
Spark Plug Gap . . . . . . . . . . . . . . . . . 0.76 mm (0.030 in.)
Fuel Capacity . . . . . . . . . . . . .11.4 Liters (3 U.S. Gallons)
Oil Capacity . . . . . . . . . . . . . . . . . .0.6 Liters (20 Ounces)
Common Service Parts
Engine Oil Bottle . . . . . . . . . . . . . . .100005E or 100007E
Synthetic Oil Bottle . . . . . . . . . . . . . . . . . . . . . . 100007W
Fuel Stabilizer . . . . . . . . . . . . . . . . . . . 992380 or 992381
For a full list of parts and diagrams, please visit BRIGGSandSTRATTON.COM.
Power Ratings: The net torque rating for individual gasoline engine models is labeled in accordance with SAE (Society of
Automotive Engineers) code J1940 Small Engine Power & Torque Rating Procedure, and is rated in accordance with SAE J1349.
Net torque values are derived at 3600 RPM and are taken with exhaust and air cleaner installed. Given the wide array of conditions
in which they are placed, the gasoline engine may not develop the rated net torque when used in a given piece of power equipment.
This difference is due to a variety of factors including, but not limited to, the variety of application limitations, ambient operating
conditions (temperature, humidity, altitude), and engine-to-engine variability. Due to manufacturing and capacity limitations, Briggs
& Stratton may substitute an engine of higher rated torque for this engine.
* Generator per ISO 8528 Performance class G1 Reciprocating internal combustion engine driven alternating current generating sets.
8
Cause
1. One of the circuit breakers is open.
2. Poor connection or defective cord set.
3. Connected device is bad.
1. Generator is overloaded.
1. Engine switch set to OFF (0) position.
2. Fuel valve is in OFF (0) position.
3. Low oil level.
4. Dirty air cleaner.
5. Out of fuel.
6. Spark plug wire not connected to
spark plug.
7. Flooded with fuel.
Correction
1. Reset circuit breaker.
2. Check and repair.
3. Connect another device that is in
good condition.
1. Remove loads from generator.
1. Set switch to ON (I) position.
2. Turn fuel valve to ON (I) position.
3. Fill crankcase to proper level or
place generator on level surface.
4. Clean or replace air cleaner.
5. Fill fuel tank.
6. Connect wire to spark plug.
7. Wait 5 minutes and re-crank engine.
Model 3200A
Starting Surge . . . . . . . . . . . . . . . . . . . . . . . . 3,125 Watts
Wattage* . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2,500 Watts
AC Voltage at 230 Volts . . . . . . . . . . . . . . . . . 10.9 Amps
Frequency. . . . . . . . . . . . . . . . . . . . . . . 50 Hz at 3600 rpm
Phase . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Single Phase
Displacement . . . . . . . . . . . . . . . . . .196 cc (11.96 cu. in.)
Spark Plug Gap . . . . . . . . . . . . . . . . . 0.76 mm (0.030 in.)
Fuel Capacity . . . . . . . . . . . . .11.4 Liters (3 U.S. Gallons)
Oil Capacity . . . . . . . . . . . . . . . . . .0.6 Liters (20 Ounces)
Model 6200A
Starting Surge . . . . . . . . . . . . . . . . . . . . . . . . 6,125 Watts
Wattage* . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4,900 Watts
AC Voltage at 230 Volts . . . . . . . . . . . . . . . . . 21.3 Amps
Frequency. . . . . . . . . . . . . . . . . . . . . . . 50 Hz at 3600 rpm
Phase . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Single Phase
Displacement . . . . . . . . . . . . . . . . . .389 cc (23.73 cu. in.)
Spark Plug Gap . . . . . . . . . . . . . . . . . 0.76 mm (0.030 in.)
Fuel Capacity . . . . . . . . . . . . .18.9 Liters (5 U.S. Gallons)
Oil Capacity . . . . . . . . . . . . . . . . . .1.1 Liters (37 Ounces)
BRIGGSandSTRATTON.COM