Page 1
APPLY SERIAL NUMBER LABEL FROM CARTON Serial No. XXXXXX000000 MODEL NO. PG.21 PG.41 WARNING DANGER IF YOU SMELL GAS: Napoleon Group of Companies 214 Bayview Dr., Barrie, Ontario, Canada L4N 4Y8 Phone: 1-705-726-4278 Fax: (705)-725-2564 www.napoleongrills.com grills@napoleonproducts.com N415-0306 JAN 29.15...
Page 2
WARNING! was store building, garage, screened-in porch, gazebo or any other enclosed area. not in use. out of reach of children. Disconnected cylinders must not be stored in a building, garage or any other enclosed area. Natural gas units must be disconnected from the supply when being stored indoors. Inspect the fuel supply hose before each use.
Page 4
CSA 1.6b and ANSI WARNING! WARNING! death or serious injury may occur. WARNING! www.napoleongrills.com...
Page 5
WARNING! Do not route hose underneath the drip pan. Do not route hose over top of rear panel. found in the manual. www.napoleongrills.com...
Page 6
WARNING! Do not let the cord hang over the edge of a table or touch hot surfaces. the outlet. Never remove the grounding plug or use with an adapter of 2 prongs. WARNING! WARNING! hose, manifolds and valves. gas installer. www.napoleongrills.com...
Page 7
WARNING! WARNING! 1. Open grill lid. 1. Open grill lid. 1. Open grill lid. 1. Open burner cover. 2. Push and turn any main 2. Push and turn the side lights and then release. 3. If the pilot does not ignite, 3.
Page 8
Simply run the main burners on high for approximately one-half hour. gas grill. In extreme circumstances when consistent high winds come from directly behind the unit, heat the possibility of improper heat build up. NOTE! Napoleon www.napoleongrills.com...
Page 9
Your All Season Grill over infrared burners on high, medium, or low, turning food frequently, or place food over unlit burners, CAUTION! the counterbalance arm and weight so the arm is facing up. Slide the counterweight in or out to balance foods.
Page 10
soups etc. For best performance, the gas grill should be located with the side burner protected from the wind. WARNING! WARNING! WARNING! most of the heat in the beam fell into the spectral region just beyond the red end of the spectrum, where no visible light existed.
Page 11
5 min. – Medium side. 20-25 min. then medium-low to low thigh and the leg from the woodchips to your Napoleon Medium 6 min. per side for more tender results. Spare ribs 20 min. per side...
Page 12
Napoleon dealer. Never apply abrasive cleaners on any stainless surfaces, especially wire brush to remove the ash. Remove the sear plates and brush debris from the burners with the brass wire brush.
Page 13
clear from debris. WARNING! WARNING! light blue and occasionally yellow. are: Propane Full Open *Infra-Red burners have no air adjustment. installed. Burner Light Blue Burner Port Approximately www.napoleongrills.com...
Page 14
CAUTION! WARNING! them. Damage caused by failure to follow these steps is not covered by your grill warranty. thoroughly. way to escape the grill. If the hot air is not allowed to escape, the burners can become deprived of oxygen causing ing surface with solid metal (i.e., griddle or large pan).
Page 15
WARNING! surface to remove any residue and paint with high temperature barbecue paint. Protect surrounding areas WARNING! remove the lens from the housing, remove the Philips screw securing the housing in place. Snap the lens www.napoleongrills.com...
Page 16
when valve turned to procedure. high. on slowly to allow pressure to equalize. See For natural gas - undersized supply line. code. Preheat grill with both main burners on high for 10 to 15 minutes. Sear plates installed incorrectly. Ensure sear plates are installed with the holes uneven heat.
Page 17
Allow burner to cool and inspect very closely your authorized Napoleon dealer to order a replacement burner assembly. Contact your authorized Napoleon dealer for housing. assembly.
Page 19
CAUTION! ATTENTION! 1. Remove all cart panels, hardware, and grill head from carton. Raise lid and remove any components 3. Assemble the grill where it is to be used, lay down cardboard or a towel to protect parts from being lost or damaged while assembling.
Page 30
(included with most rear burner units) www.napoleongrills.com...
Page 31
CAUTION! panel of your grill as shown. Do not immerse cord or plugs in water or other liquid. Keep electrical cords out of pathways. Do not let the cord hang over the edge of a table or touch hot surfaces. the rear panel of your grill as shown.
Page 35
WARNING! WARNING! hose, manifolds and valves. gas installer. Propane Only www.napoleongrills.com...
Page 36
AVERTISSEMENT! AVERTISSEMENT! vous faites ce test. Consultez le schéma de test de fuites pour voir les endroits à tester. le tuyau et ses raccords. 3 - Des bulles indiqueront une fuite de gaz. Resserrez le joint ou remplacez la pièce avec une autre recommandée par le détaillant.
Page 39
ITEM N715-0098 N215-0014 N370-0136 N555-0061 N735-0021 N530-0050 N720-0072 N010-0811-SS N010-0810-SS N750-0028 N750-0029 N750-0031 N750-0032 N750-0034 N750-0035 N215-0016 N215-0017 68825 56018 56040 67731 x - standard x - compris p - propane units only p - appareils propane seulement n - natural gas units only n - appareils gaz naturel seulement ac - accessory ac - accessoires...
Page 42
ITEM N590-0242-GY1SG N570-0076 N185-0005 55110 62008 N570-0087 N735-0001 N200-0113-GY1SG N402-0016 N080-0318-GY1SG N160-0002 N710-0085-SER N370-0707 N370-0701P N370-0701N N555-0025 x - standard x - compris p - propane units only p - appareils propane seulement n - natural gas units only n - appareils gaz naturel seulement ac - accessory ac - accessoires www.napoleongrills.com...
Page 45
ITEM N735-0020 N305-0093 N570-0008 N325-0063 N325-0064 N385-0144 N010-0730 N385-0185 N120-0014G N335-0048-M02 N485-0009 N185-0003 N590-0189 N255-0061 x - standard x - compris p - propane units only p - appareils propane seulement n - natural gas units only n - appareils gaz naturel seulement ac - accessory ac - accessoires www.napoleongrills.com...