Table of Contents
Advertisement
0 - 8
LUBRICATION AND MAINTENANCE
FLUID CAPACITIES
C O O L I N G SYSTEM
QUARTS
LITERS
POWER S T E E R I N G
PINTS
LITERS
3.9L ENGINE
15.1
14.3
ALL
2.7
1.28
5.2L ENGINE (Except AWl50)
17.0
16.1
REAR A X L E
PINTS
LITERS
5.2L ENGINE (AWl 50)
16.5
15.6
CHRYSLER BVA Inch (210 mm)
4.4
2.08
5.9L ENGINE (Except AWl 50)
15.5
14.7
CHRYSLER 9VA Inch (235 mm)
4.5
2.13
5.9L ENGINE (AWl 50)
15.0
14.2
DANA 60
6.0
2.84
E N G I N E C R A N K C A S E
QUARTS
LITERS
DANA 70
7.0
3.31
3.9L ENGINE
4.0
3.8
FRONT A X L E
PINTS
LITERS
5.2L & 5.9L (no Filter change)
4.0
3.8
Spicer 44 FBJ
5.6
2.65
5.2L & 5.9L (with Filter change)
5.0
4.7
Spicer 60 F
6.5
3.07
FUEL T A N K
G A L L O N
LITERS
TRANSMISSION-AUTOMATIC
Q U A R T S
LITERS
STANDARD 3.9L & 5.2L ENGINES
22.0
83.0
A 727 (5.9L ENGINE)
8.4
7.9
OPTIONAL 3.9L & 5.2L ENGINES
30.0
113.0
A 998 (3.9L ENGINE)
8.6
8.1
STANDARD 5.9L ENGINE
30.0
113.0
A 999 (5.2L ENGINE)
8.6
8.1
AD100& AW100
34.0
128.0
TRANSMISSION-MANUAL
Q U A R T S
LITERS
TRANSFER CASE
PINTS
LITERS
NP-435 (4 Speed)
3.5
3.3
NP-205
4.5
2.13
NP-2500 (5 Speed)
2.0
1.9
NP-241
6.0
. 2.84
ASSIST (JUMP) STARTING
WARNING: DO NOT ATTEMPT TO PUSH OR TOW A
VEHICLE TO GET IT STARTED. UNBURNED FUEL
COULD ENTER THE CONVERTER AND, ONCE THE
ENGINE HAS STARTED, IGNITE AND CAUSE THE
CONVERTER TO OVERHEAT AND RUPTURE.
BOOSTER
BATTERY
WARNING: TO PREVENT PERSONAL INJURY OR
DAMAGE TO CLOTHING, DO NOT ALLOW BAT-
TERY FLUID TO CONTACT EYES, SKIN OR FAB-
RICS. DO NOT LEAN OVER A BATTERY WHEN
CONNECTING JUMPER CABLES OR ALLOW CA-
BLE
CLAMPS TO TOUCH EACH OTHER. KEEP
OPEN FLAMES OR SPARKS AWAY FROM BAT-
TERY VENT HOLES. ALWAYS WEAR EYE PROTEC-
TION WHEN WORKING WITH BATTERIES.
I f i t becomes necessary to use a booster battery,
w i t h j u m p e r cables, t o s t a r t a vehicle's engine be-
cause i t s battery is discharged, t h e following proce-
dure should be followed:
(1) Set p a r k i n g brake and place automatic trans-
mission i n P A R K ( N E U T R A L for manual transmis-
sion).
(2) T u r n off l i g h t s , heater
and other
electrical
loads.
J9000-62
(3) Observe charge indicator. I f indicator i s l i g h t or
yellow replace battery. D O N O T a t t e m p t j u m p start-
i n g w h e n indicator is l i g h t or yellow. I f charge i n d i -
cator has a green dot i n the center, f a i l u r e t o s t a r t is
not due t o a discharged battery and the c r a n k i n g sys-
tem should be checked. I f charge indicator appears
dark i n the center, proceed as follows:
(4) A t t a c h one end of one j u m p e r cable t o positive
t e r m i n a l o f booster battery and the other end o f same
cable to positive t e r m i n a l of discharged b a t t e r y (Fig.
4).
BATTERY NEGATIVE
CABLE TERMINAL
POSITIVE
JUMPER
CABLE
BATTERY
§ § J 9 0 0 0 - 3 7
Fig. 4 Connecting Positive Jumper Cable
Advertisement
Table of Contents
