Safety Rules - Snapper Simplicity ZT3000 Dealer Setup & Adjustment Instructions Manual

Simplicity / Snapper ZTR
Read these safety rules and follow them closely. Failure to obey these rules could result in loss of control of equipment, severe
personal injury or death to you, yourself or bystanders, or damage to property or equipment. This mowing deck is capable of
amputating hands and feet and throwing objects. The triangle
followed.
IMPORTANT – Safe operation practices for riding mowers.
I. General operation
1. Read, understand, and follow all instructions in the manual and on
the unit before starting.
2. Only allow responsible adults, who are familiar with the
instructions, to operate the unit.
3. Clear the area of objects such as rocks, toys, wire, etc., which
could be picked up and thrown by the blade(s).
4. Be sure the area is clear of other people before mowing. Stop the
unit if anyone enters the area.
5. Never carry passengers.
6. Do not mow in reverse unless absolutely necessary. Always look
down and behind before and while backing.
7. Be aware of the mower discharge direction and do not point it at
anyone. Do not operate the mower without either the entire grass
catcher or the guard in place.
8. Slow down before turning.
9. Never leave a running unit unattended. Always turn off blades, set
parking brake, stop engine, and remove keys before dismounting.
10. Turn off blades when not mowing.
11. Stop engine before removing grass catcher or unclogging chute.
12. Mow only in daylight or good artificial light.
13. Do not operate the unit while under the influence of alcohol or
drugs.
14. Watch for traffic when operating near or crossing roadways.
15. Use extra care when loading or unloading the unit into a trailer or
truck.
II. Slope operation
Slopes are a major factor related to loss-of-control and tip-over
accidents, which can result in severe injury or death. All slopes require
extra caution. If you cannot back up the slope or if you feel uneasy on
it, do not mow it.
WARNING – SLOPE OPERATION
Never operate on slopes greater than 15° which is a rise of 5.4 feet
(1,6 m) vertically in 20 feet (6 m) horizontally. Select slow ground
speed before driving onto slope. In addition to front and rear
weights, use extra caution when operating on slopes with rear-
mounted grass catcher. Mow UP and DOWN the slope, never
across the face, use caution when changing directions and DO
NOT START OR STOP ON SLOPE.
DO
• See your authorized dealer for recommendations of wheel weights
or counterweights to improve stability.
• Mow across slopes, not up and down.
• Remove obstacles such as rocks, tree limbs, etc.
• Watch for holes, ruts, or bumps. Uneven terrain could overturn the
unit. Tall grass can hide obstacles.
• Use slow ground speed so that you will not have to stop or change
speeds while on the slope.
• Use extra care with grass catchers or other attachments. These
can change the stability of the unit.
TP 300-7337-01-CH-SMN

SAFETY RULES

in text signifies important cautions or warnings which must be
• Keep all movement on the slopes slow and gradual. Do not make
sudden changes in speed or direction.
• Avoid starting or stopping on a slope. If tires lose traction,
disengage the blade(s) and proceed slowly straight down the
slope.
DO NOT
• Do not turn on slopes unless necessary, and then, turn slowly and
gradually downhill, if possible.
• Do not mow near drop-offs, ditches, or embankments. The unit
could suddenly turn over if a wheel is over the edge of a cliff or
ditch, or if an edge caves in.
• Do not mow on wet grass. Reduced traction could cause sliding.
• Do not try to stabilize the unit by putting your foot on the ground.
• Do not use grass catcher on steep slopes.
III. Children
Tragic accidents can occur if the operator is not alert to the presence
of children. Children are often attracted to the unit and the mowing
activity. Never assume that children will remain where you last saw
them.
1. Keep children out of the mowing area and under the watchful care
of another responsible adult.
2. Be alert and turn unit off if children enter the area.
3. Before and when backing, look behind and down for small
children.
4. Never carry children. They may fall off and be seriously injured or
interfere with safe unit operation.
5. Never allow children to operate the unit.
6. Use extra care when approaching blind corners, shrubs, trees, or
other objects that may obscure vision.
IV. Service
1. Use extra care in handling gasoline and other fuels. They are
flammable and vapors are explosive.
a) Use only an approved container.
b) Never remove gas cap or add fuel with the engine running.
Allow engine to cool before refueling. Do not smoke.
c) Never refuel the unit indoors.
d) Never store the unit or fuel container inside where there is an
open flame, such as a water heater.
d) Clean up oil and fuel spills immediately.
2. Never run a unit inside a closed area.
3. Keep nuts and bolts, especially blade attachment bolts, tight and
keep equipment in good condition.
4. Never tamper with safety devices. Check their proper operation
regularly.
5. Keep equipment free of grass, leaves, or other debris build-up.
6. Stop and inspect the equipment if you strike an object. Repair, if
necessary, before restarting.
7. Never make adjustments or repairs with the engine running.
8. Grass catcher components are subject to wear, damage, and
deterioration, which could expose moving parts or allow objects to
be thrown. Frequently check components and replace, when
necessary, with manufacturer's recommended parts.
9. Mower blades are sharp and can cut. Wrap the blade(s) or wear
gloves, and use extra caution when servicing them.
10. Check brake operation frequently. Adjust and service as required.
11. Allow the unit to cool before storing.
2 8/2007