Page 2
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM CAUTIONS IN ASSEMBLING PANEL DRIVE MECHANISM (A10-5171) Observe the instructions described in this document when you are going to replace the parts or components that are shown in this document. 1. Replacement of motor fl at spring • When mounting the flat spring that shall be in contact with the worm gear, press the spring toward the direction shown with an arrow so that there will be no gap be- tween the tip of the gear and the spring and then mount...
Page 3
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM CAUTIONS IN ASSEMBLING PANEL DRIVE MECHANISM (A10-5171) 2. Phase matching among gears • Monitor tilt is driven under the control of the rotary sensor and the phase matching among gears and sensor is required. The procedure for the phase matching is de- scribed in the rest of this subsection.
Page 4
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM CAUTIONS IN ASSEMBLING PANEL DRIVE MECHANISM (A10-5171) 3. Insertion of slider (Slider -Slide section inside of the unit) • This subsection describes cautions for inserting the slider (slide section inside of the unit) into the outer chassis. 1) On the rail at the left side of the slider, there is a part called a stabilizer that is used to minimize play in right and left sides.
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM GEAR POSITION IN A DVD MECHANISM In assembling the Traverse UD arm, Drive cam assembly, Traverse UD arm Drive gear 5 and Drive gear 4C, align register marks on these components. Drive cam assembly Inscriptions (register marks) on gears Align 6 marks as shown in the figure...
Page 6
(X15-) (A/2) P ON BU14V SW+14V u-COM P ON P PWM ACC DET MCNT BU DET P GOOD PARKING P ON SIR PON P START A8.5V BU5V SIR SW14V DCDC DCDC u-COM u-COM u-COM REVERSE ILLUMI (X35-) (B/2) W REMO P CON ANT CON BE A5V...
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM COMPONENTS DESCRIPTION ● VIDEO CONTROL UNIT (X15-110x-xx) Ref. No. Application / Function Operation / Condition / Compatibility 3-terminal regulator 9V→5V regulator 3-terminal regulator For AUDIO8.5V DC/DC converter IC MECHA7.5V/D5V control DC/DC converter IC USB5V/D3.3V control Motor driver Slide Motor driver Tilt 3.3V regulator...
Page 9
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM COMPONENTS DESCRIPTION Ref. No. Application / Function Operation / Condition / Compatibility Q357-360 Pre-Out_Mute circuit (AVOUT) Q361,362 ON when AM (TUNNER8.5V) Q370 KAB_RX error connection protection Q371-373 Tuner_Mute circuit (during ejection) Q451 BUFFER Q452 NT_PAL Q453 BUFFER DVD_V Q454,455 For KAB_TX control Q651...
Page 10
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM COMPONENTS DESCRIPTION Ref. No. Application / Function Operation / Condition / Compatibility Optical disc control IC in μ-com Optical DISC general control / ATAPI interface Voltage detection IC For system resetting of optical DISC control IC 3.3V power supply 5V→3.3V Voltage detection IC For 1.5V power supply IC voltage monitor...
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM MICROCOMPUTER’S TERMINAL DESCRIPTION ● SYSTEM MICROCOMPUTER: 30878MJBA22GP (X15-110: IC9) Pin No. Pin Name Application Processing Operation Description EVOL_SDA I/O Communication data with E-VOL EVOL_SDA/E2P_SDA Communication data with E2P Touch panel control SIR_PON SAT power supply ON/OFF H: ON, L: OFF VSYNC_DET Video external input detection Detects if there is VSYNC signal or not.
Page 12
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM MICROCOMPUTER’S TERMINAL DESCRIPTION Pin No. Pin Name Application Processing Operation Description PRE_MUTESW Pre-out mute (SW) H: OFF, L: ON POWER_PWM Frequency control of DC-DC_IC NAVI_RX Communication with navigation system NAVI_TX Communication with navigation system Data output to TV μ-com TV_MC_DATA/TV_MC_DATA (For other destination than K and R) TV_MC_DATA/NC...
Page 13
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM MICROCOMPUTER’S TERMINAL DESCRIPTION Pin No. Pin Name Application Processing Operation Description OPEN_CLOSE Z-MECHA OPEN/CLOSE Touch panel control INV_SW Inverter free run frequency switching BL_ENA Back light ON/OFF control H: ON, L: OFF Reserve Z_SWT Detection of panel mechanism SW_C Detection of panel mechanism SW_B...
Page 14
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM MICROCOMPUTER’S TERMINAL DESCRIPTION Pin No. Pin Name Application Processing Operation Description ILL_G ON/OFF of other GREEN illumination than variable illumination H: ON, L: OFF ILL_R ON/OFF of other RED illumination than variable illumination H: ON, L: OFF MCNT Switching of power supply voltage to the panel drive mechanism H: 7.5V, L: 5V PGOOD DC-DC power supply error detection...
Page 15
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM MICROCOMPUTER’S TERMINAL DESCRIPTION Destination settings of KVT/DDX/DNX KEY1 Settings MODEL Destination TYPE2 TYPE1 TYPE0 Power supply voltage Number of keys Pull up resistor μ-com setup value Name of Resister value KEY1 SCRN/ 0.00 0.69 KEY2 FNC/■ 0.70 1.92 KEY3 SRC/SRC 1.93...
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM ADJUSTMENT 1. Flicker adjustment 2. VCOM Amplitude and AGC and WB Automatic adjustments ● Condition Video source: VIDEO ● Adjustment Method Video: RAMP q Input 100% (white) in AV-IN. BRIGHT: MAX w Press Auto Adjust on the Test Mode Main screen. MODE: FULL ●...
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM ADJUSTMENT 3. Adjustment of Horizontal display start ● NAVI Adjustment screen Adjustment screen changes depending on what type position and pixel (model) of NAVI is connected. ● Video displayed on Adjustment screen Screen Position Proceed to the next GRAPHIC: Special screen used only for adjustment (See Adjustment key adjustment screen...
Page 18
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM ADJUSTMENT Enlarge OK w-2-1 NAVI (In case of KNA-DV3200) Adjust the Screen Adjustment key so that the NAVI screen becomes horizontally symmetrical. Enlarge NG w-2 Grafhic (HPOSI) Adjust the screen such that KEY (gap) at the right and left sides becomes symmetrical. Adjust the Screen Adjustment key so that the screen be- comes horizontally symmetrical.
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM ADJUSTMENT 4. Touch panel adjustment Enlarge OK ● Adjustment procedure q Press the Touch Key on the Test Mode Menu screen to enter the Touch panel adjustment screen. Enlarge OK w Touch the center of “+” mark below in the following or- der.
Page 20
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PC BOARD (COMPONENT SIDE VIEW) VIDEO CONTROL UNIT X15-110x-xx A/2 (J76-0505-12) CN351 C376 D367 R402 R385 R489 C379 C455 D369 D366 IC351 R453 D413 C424 D396 R452 C423 C425 D401 R454 D384 C456 R439 R428 CN352 R438 C383 R488 C472 C454...
Page 21
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM X15 B/2 D574 D552 SPDIF RESET R581 R579 D590 D561 R580 D589 D591 S551 R694 VOL- R693 D551 D572 D D D D CN353 D571 D681 S S S G R193 D382 Q350 X15-110x-xx R479 Ref. No. Address Ref.
Page 22
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PC BOARD (FOIL SIDE VIEW) X15 B/2 VIDEO CONTROL UNIT X15-110x-xx A/2 (J76-0505-12) TP556 R583 CN551 TP551 TP555 TP558 TP557 TP560 R471 R470 R33 R38 C428 C429 R472 C432 IC10 Q12 Q13 R203 C202 IC12 R103 R102 R108 C602 C605 C606...
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM EXPLODED VIEW (DVD MECHANISM) M1.7x2 : N09-6382-05 : N09-6408-15 φ1.7x4 M2x2 : N09-6426-15 : N09-6104-05 φ2x10 Parts with the exploded numbers larger than 700 are not supplied.
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PARTS LIST ✽ New parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohne Parts No. werden nicht geliefert. Desti- Desti- Ref. No. Parts No. Description Ref.
Page 50
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PARTS LIST DISPLAY ASSY Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation 2F ✽ D13-2457-04 GEAR W02-5121-05 ELECTRIC CIRCUIT MODULE W02-5122-05 ELECTRIC CIRCUIT MODULE 2F ✽ D21-2446-13 EXTENSION SHAFT DVD PLAYER ASSY E39-0665-05 FLAT CABLE N09-6227-15...
Page 51
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PARTS LIST VIDEO CONTROL UNIT (X15-110x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation CK73GB1C104K CHIP C 0.10UF C148 CK73HB1E103K CHIP C 0.010UF K C149 CK73EB1A106K CHIP C 10UF C64,65 CK73HB1H102K CHIP C 1000PF CK73EB1E225K CHIP C...
Page 52
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PARTS LIST VIDEO CONTROL UNIT (X15-110x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation C375 CK73EB1A106K CHIP C 10UF C462 CK73HB0J105K CHIP C 1.0UF C463 CC73GCH1H101J CHIP C 100PF C376 CK73HB1E103K CHIP C 0.010UF K C377 CK73GB1A474K...
Page 53
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PARTS LIST VIDEO CONTROL UNIT (X15-110x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation C734,735 CK73HB1H102K CHIP C 1000PF L12,13 L92-0319-05 CHIP FERRITE C741 CK73GB0J475K CHIP C 4.7UF L353 L41-4795-33 SMALL FIXED INDUCTOR (4.7U) C742-748 CK73HB1A104K CHIP C...
Page 54
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PARTS LIST VIDEO CONTROL UNIT (X15-110x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation RK73HB1J104J CHIP R 100K J 1/16W R105,106 RK73GH2A561D CHIP R D 1/10W R107 RK73HB1J000J CHIP R J 1/16W RK73HB1J473J CHIP R J 1/16W...
Page 55
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PARTS LIST VIDEO CONTROL UNIT (X15-110x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation R221,222 RK73HB1J473J CHIP R J 1/16W R370 RK73HB1J473J CHIP R J 1/16W R372 RK73HB1J223J CHIP R J 1/16W R223 RK73HB1J104J CHIP R...
Page 56
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PARTS LIST VIDEO CONTROL UNIT (X15-110x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation R447 RK73HB1J100J CHIP R J 1/16W E1E2M1 R568 RK73GB2A221J CHIP R J 1/10W R569 RK73GB2A561J CHIP R J 1/10W R447 RK73HB1J100J CHIP R...
Page 57
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PARTS LIST VIDEO CONTROL UNIT (X15-110x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation R732-738 RK73HB1J220J CHIP R J 1/16W UDZW6.2(B) ZENER DIODE D4,5 1SS355 DIODE R739,740 RK73HB1J000J CHIP R J 1/16W R742-747 RK73HB1J000J CHIP R...
Page 58
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PARTS LIST VIDEO CONTROL UNIT (X15-110x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation D413,414 UDZW6.2(B) ZENER DIODE DTA114EE DIGITAL TRANSISTOR DTC143ZE DIGITAL TRANSISTOR D415 1SS355 DIODE D571-591 CVS10A180M VARISTOR 2SB1188(R) TRANSISTOR KR1M1 D592 CVL10C270M300...
Page 59
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PARTS LIST VIDEO CONTROL UNIT (X15-110x-xx) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation DTA124XUA DIGITAL TRANSISTOR ✽ C93-1460-05 CHIP C 2200PF Q78,79 2SK3019 C93-1283-05 CHIP C 1.0UF DTA114EE DIGITAL TRANSISTOR C100 CC73GCH1H151J CHIP C 150PF...
Page 60
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PARTS LIST VIDEO UNIT (X35-4960-10) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation C322,323 CK73HB1E103K CHIP C 0.010UF K X300 L77-2963-05 CRYSTAL RESONATOR (12M) C324 CC73HCH1H101J CHIP C 100PF C325,326 CK73HB1E103K CHIP C 0.010UF K RK73HB1J512J CHIP R...
Page 61
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PARTS LIST VIDEO UNIT (X35-4960-10) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation R336 RK73HB1J105J CHIP R 1.0M J 1/16W IC300 S-1112B25MCG ANALOGUE IC IC302 R341-343 RK73HB1J000J CHIP R J 1/16W ✽ AT25F2048-4Z8 ROM IC R344,345 RK73HB1J101J...
Page 62
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PARTS LIST DVD UNIT (X37-1100-03) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation CK73HB1A104K CHIP C 0.10UF R28,29 R92-5147-05 CHIP R D 1/4W RK73HB1J102J CHIP R 1.0K J 1/16W CK73HB1A104K CHIP C 0.10UF C100 CK73FB0J226M...
Page 63
KVT-50DVDRY/512/522DVD /522DVDY/532DVD/532DVDM PARTS LIST DVD UNIT (X37-1100-03) Desti- Desti- Ref. No. Parts No. Description Ref. No. Parts No. Description nation nation R273 RK73HH1J122D CHIP R 1.2K 1/16W D13-2416-04 GEAR D14-1013-14 ROLLER R274 RK73HH1J682D CHIP R 6.8K 1/16W R275 RK73HH1J122D CHIP R 1.2K 1/16W D21-2487-24...
Page 64
Weight ............2.3 kg (5.1 lbs) Audio Decoder ........... MP3/ WMA/ AAC Video Decoder ..........MPEG1/ MPEG2 KENWOOD follows a policy of continuous advancements FM tuner section in development. For this reason specifications may be Frequency Range (200 kHz) ....87.9 MHz – 107.9 MHz changed without notice.
Page 65
Quieting Sensitivity (S/N : 46 dB) ..15.2 dBf (1.6 μV/ 75 Ω) Frequency Response (± 3.0 dB) .....30 Hz – 15 kHz KENWOOD follows a policy of continuous advancements S/N Ratio (dB) ..........70 dB (MONO) in development. For this reason specifications may be Selectivity (±...
Page 66
Quieting Sensitivity (S/N : 46 dB) .......1.6 μV/ 75 Ω Frequency Response (± 3.0 dB) .....30 Hz – 15 kHz S/N Ratio (dB) ..........65 dB (MONO) KENWOOD follows a policy of continuous advancements in development. For this reason specifications may be changed without notice.