Suzuki WagonR Manual page 116

67L-74E
Interval: This interval should be judged
by odometer reading or months,
whichever comes first.
FUEL
1.
Air cleaner filter element
2. Accelerator cable and Throttle shafts
3. Fuel tank cap, fuel lines and connections (Leakage, Damage)
4. Fuel Filter (Leakage)
CLUTCH AND TRANSMISSION
1. Clutch Pedal (Play)
2. Clutch slipping (Dragging or Excessive Damage)
3. Transmission oil (Level Leakage)
DRIVE SHAFTS
1. Drive shaft boots (boot cut / damage)
2. Noise from drive shafts
BRAKE
1. Brake Fluid (Level, Leakage)
2. Brake pedal (pedal-to-ball clearance)
3. Parking brake lever and cable (Play, Damage)
a. Brake discs and pads (Wear)
4.
b. Brake drums and shoes
5. Brake hoses and pipes (Fluid leakage, Damage)
Master cylinder, wheel cylinder and caliper piston
6.
(Fluid leakage, boot/seal damage)
WHEEL
1. Tyres (air pressure, abnormal wear, crack and rotation)
2. Wheels (Damage)
3. Front wheel bearing (Loose, Damage, Noise)
4. Rear wheel bearing (Loose, Damage, Noise)
FREE INSPECTION
km (x 1,000)
1 5
months
1 6
Paved-road Clean every 5,000 KM. Replace every 40,000 KM.
Dusty Condition Clean after every 2,500 KM or as required. Replace every 40,000 KM. More
frequent replacement if dust condition is severe.
– l&L
– –
I I
I I
l l
l l
Replace every 1,60,000kms or 10 years, whichever comes earlier
– l
I I
I I
I I
I I
– I
– –
I I
I I
I I&O
I I
– I
– I
INSPECTION AND MAINTENANCE
PERIODIC MAINTENANCE SERVICE AT COST
10 20 30 40 50 60
12 24 36 48 60 72
l&L l&L l&L l&L l&L l&L
– – – I – –
I I I R I I
I I I I I I
l I l I l I
l l l l l l
l l l l l l
I I I I I I
I R I R I R
I I I I I I
I I I I I I
I I I I I I
I I I I I I
I I I I I I
I I I I I I
I&O I&O I&O I&O I&O I&O
I I I I I I
I I I I I I
I I I I I I
70 80
84 96
l&L l&L
– I
I R
I I
l I
l l
l l
I I
I R
I I
I I
I I
I I
I I
I I
I&O I&O
I I
I I
I I
7-3
67LH3-74E