Ignition Curve Plug Connection; Changing The Ignition Curve; Removing The Seat; Mounting The Seat - KTM 450 SMR Owner's Manual

MAINTENANCE WORK ON CHASSIS AND ENGINE

Ignition curve plug connection

9.79

Changing the ignition curve

9.80
Change the ignition curve from Performance to Soft.
–
Disconnect plug connection
Soft – better driveability
Change the ignition curve from Soft to Performance.
–
Connect plug connection
Performance – higher performance

Removing the seat

9.81

Mounting the seat

9.82

Removing the fuel tank

x
9.83
Danger
Fire hazard Fuel is highly flammable.
–
Never refuel the vehicle near open flames or burning cigarettes, and always switch off the engine first. Be careful that no
fuel is spilt, especially on hot vehicle components. Clean up spilt fuel immediately.
–
Fuel in the fuel tank expands when warm and can escape if the tank is overfilled. See the notes on refueling.
Warning
Danger of poisoning Fuel is poisonous and a health hazard.
–
Avoid contact between fuel and skin, eyes and clothing. Do not inhale fuel vapors. If fuel gets into your eyes, rinse immedi-
ately with water and contact a doctor. Wash affected skin areas immediately with soap and water. If fuel is swallowed, con-
tact a doctor immediately. Change clothing that has come into contact with fuel. Store fuel in a suitable canister according
to regulations and keep it out of the reach of children.
Plug connection
Possible states
Soft – The plug connection is disconnected to achieve better driveability.
•
Performance – The plug connection is connected to achieve better performance.
•
500218-10
. (Figure 500218-10

. (Figure 500218-10 p. 53)

–
Remove screw
above.
500080-10
–
Hook in the front of the seat at the collar sleeve of the fuel tank, lower it at the rear
and simultaneously push it forward.
–
Make sure that the seat is correctly locked in.
–
Mount and tighten the screw of the seat fixing.
Guideline
Remaining screws, chassis
500068-01
–
Remove the seat. (
is located in front of the fuel tank on the left side of the frame.

p. 53)
. Lift up the seat at the rear, pull it back and then remove from

p. 53)
M6 10 Nm (7.4 lbf ft)
53