CAUTION Danger of explosion if battery is incorrectly replaced. Replaced only with the same or equivalent type recommended by the manufacture. Discord used batteries according to the manufacture's instructions. DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be u163 installed before shipment. Please be sure to follow this method especially if it is specified in this manual. DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
2. SPECIFICATIONS 3 7 63 1515 0 2.1 SPECIFICATIONS DEH-P4100SD/XS/EW5 Bass boost: General Gain ......... +12 dB to 0 dB Power source......14.4 V DC (10.8 V to 15.1 V allowable) CD player Grounding system....Negative type System ........Compact disc audio system Max.
Page 7
LW tuner Frequency range....153 kHz to 281 kHz Usable sensitivity....28 μV(S/N: 20 dB) Signal-to-noise ratio..... 62 dB (IEC-A network) Notes Specifications and the design are subject to modifications without notice due to im- provements. L 13942296513 u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Page 8
Slope........–12 dB/oct (Windows Media Player) Subwoofer (mono): AAC decoding format..MPEG-4 AAC (iTunes en- Frequency....... 50/63/80/100/125 Hz coded only) (.m4a) Slope........–18 dB/oct u163 (Ver. 7.7 and earlier) Gain ......... +6 dB to –24 dB Phase ......Normal/Reverse DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Page 9
Signal-to-noise ratio..... 62 dB (IEC-A network) Infrared remote control Wavelength......940 nm ±50 nm Output ........typ; 12 mw/sr per Infrared Notes Specifications and the design are subject to modifications without notice due to im- L 13942296513 provements. u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Page 10
3 7 63 1515 0 DEH-4150SD/XS/CN5 Backup current .......2.8 mA to 3.1 mA L 13942296513 u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
USB storage device is projected forward from the unit, it is dangerous to connect directly. Pioneer CD-U50E USB cable is also avail- able. For details, consult your dealer. 1 SRC/OFF button This unit is turned on by selecting a source.
Page 13
Band and frequency are displayed. • RDS Program service name, PTY information and other literal information are dis- played. • Built-in CD player, external storage de- vice (USB, SD), iPod Elapsed playback time and literal infor- mation are displayed. u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Page 14
Appears when loudness is on. (TA) indicator Appears when TA (traffic announcement standby) function is on. (TP) indicator Appears when a TP station is tuned in. (AF) indicator Appears when AF (alternative frequencies search) function is on. u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Page 15
1 SRC/OFF button directly. This unit is turned on by selecting a source. Pioneer CD-U50E USB cable is also avail- Press to cycle through all the available (ES) able. For details, consult your dealer.
Page 16
1 Main display section Displays band, frequency, elapsed playback time and other settings. • Tuner Band and frequency are displayed. • Built-in CD player, external storage de- vice (USB, SD), iPod Elapsed playback time and literal infor- mation are displayed. u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
(loudness) indicator Appears when loudness is on. Screw (stereo) indicator Screw Parts No. Appears when the selected frequency is being broadcast in stereo. DEH-P4100SD/XS/EW5 BPZ20P080FTC (SD memory card) indicator DEH-4150SD/XS/ES CXX2204 Appears when SD/SDHC memory card is in- DEH-4150SD/XU/CN5 (Service) serted.
See the table below for the items to be checked regarding audio: Item to be checked regarding audio Distortion Noise Volume too low Volume too high Volume fluctuating Sound interrupted L 13942296513 u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
: (CN5) Unit Name : Keyboard Unit Unit Number : YWM5391 Unit Name : SD Unit Unit Number : CWX3678(EW5, ES) Unit Number : CWX3727(CN5) Unit Name : CD Core Unit(S10.5COMP2-iPod-C3)(EW5, ES) Unit Name : CD Core Unit(S10.5iPod-C3-CLASS1)(CN5) u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning L 13942296513 tools: Portions to be cleaned Cleaning tools CD pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008 u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Source keys with Grille microcomputer may fail. operative If the time interval is not 300 msec, the oscillator may be defective. Source ON SYSPW <- H Pin 48 u163 Completes power-on operation. (After that, proceed to each source operation) DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Remarks: Mechanical errors are not displayed (because a CD is turned off in these errors). Unreadable TOC does not constitute an error. An intended operation continues in this case. Upper digits of an error code are subdivided as shown below: 1x: Setup relevant errors, 3x: Search relevant errors, Ax: Other errors. u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
CH1 - CH4 : Usage condition of ROM Correction CH (using:X / Not used:0) When ROM Correction itself didn't exist: When check sum is a disagreement: *3) LCD check mode 1 *4) LCD check mode 2 *5) LCD check mode 3 u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
3 Press the C key to change display/non-display of key names. When the non-display mode is selected for the K1 - K6 key names, "A key" and "B key" are invalid. C key *) Pressing the A key or B key does not work. u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Page 33
• When the power is turned on/off the jump mode is reset to the Single TR (91) while the gain of the RFAMP is reset to 0 dB. At the same time all the self-adjusting values shall return to the default setting. DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
- Removing the Tuner Amp Unit(EW) / Tuner Amp Assy(ES, CN5) (Fig.2) Remove the three screws. Remove the screw. Straighten the tabs at four locations indicated and then remove the Tuner Amp Unit /Tuner Amp Assy. u163 Tuner Amp Unit /Tuner Amp Assy Fig.2 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
1k ohms in series. The load and eject operation is not guarantied with the mechanism upside down. If the mechanism is blocked due to mistaken eject operation, reset the product or turn off and on the ACC to restore it. u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the average angle. Hint u163 Reloading the disc changes the clamp position and may decrease the "wobble". DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
STEST IC601(Pin 63) terminal to H. The clock signal is output from the PCL1 terminal IC601(Pin 39). The frequency of the clock signal is 468.750 Hz that is one 32th of the fundamental frequency. L 13942296513 u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) 9.1 PACKING DEH-4150SD/XS/ES DEH-4150SD/XU/CN5 L 13942296513 DEH-4150SD/XS/ES DEH-4150SD/XU/CN5 DEH-P4100SD/XS/EW5 DEH-4150SD/XU/CN5 u163 DEH-P4100SD/XS/EW5 DEH-4150SD/XS/ES DEH-4150SD/XU/CN5 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Page 41
CNV3930 21-5 Owner's Manual See Contrast table (2) Polyethylene Bag CEG-162 Unit Box See Contrast table (2) (2) CONTRAST TABLE DEH-P4100SD/XS/EW5, DEH-4150SD/XS/ES and DEH-4150SD/XU/CN5 are constructed the same except for the following: Mark Description DEH-P4100SD/XS/EW5 DEH-4150SD/XS/ES DEH-4150SD/XU/CN5 Cord Assy CDP1015...
Page 43
CKX1070 Transistor(Q702, Q911) 2SD2396 FM/AM Tuner Unit See Contrast table (2) Holder CND4324 L 13942296513 (2) CONTRAST TABLE DEH-P4100SD/XS/EW5, DEH-4150SD/XS/ES and DEH-4150SD/XU/CN5 are constructed the same except for the following: Mark Description DEH-P4100SD/XS/EW5 DEH-4150SD/XS/ES DEH-4150SD/XU/CN5 CD Mechanism Module(S10.5) CXK5777 CXK5777...
ROT1 ROT0 R812 R805 R815 2.2k ROT0 KYDT R806 the importance of the safety factor of the part. 2.2k KYDT DPDT 2.2k 2.2k Therefore, when replacing, be sure to use parts of DPDT DSEN R807 DSENS identical designation. DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
10.3 CD MECHANISM MODULE(GUIDE PAGE) 3 7 63 1515 0 PICKUP UNIT(P10.5)(SERVICE) L 13942296513 SWITCHES: CD CORE UNIT(S10.5COMP2-IPOD-C3) S901:HOME SWITCH..ON-OFF S903:DSCSNS SWITCH..ON-OFF S904:12EJ SWITCH...ON-OFF S905:8EJ SWITCH.....ON-OFF M1 CXC7134 SPINDLE MOTOR M2 CXC4026 LOADING/CARRIAGE MOTOR u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Page 57
3 7 63 1515 0 CD CORE UNIT(S10.5COMP2-iPod-C3) (EW5, ES) CD CORE UNIT(S10.5iPod-C3-CLASS1) (CN5) SIGNAL LINE FOCUS LINE TRACKING LINE CARRIAGE LINE SPINDLE LINE L 13942296513 CN701 341S2162(EW5, ES) 341S2159(CN5) u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Page 65
Mode: Mode: Normal Normal Normal 1 V/div 50 ns/div 2 V/div 50 ms/div 2 V/div 50 ms/div 1 V/div 2 V/div 2 V/div USB Play USB device inserting to USB connector. CD Play with USB(iPod) device connecting. u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
11.3 CD CORE UNIT (S10.5COMP2-iPod-C3) 3 7 63 1515 0 CD CORE UNIT(S10.5COMP2-iPod-C3)(EW5, ES) SIDE A CD CORE UNIT(S10.5iPod-C3-CLASS1)(CN5) PICKUP UNIT(P10.5) (SERVICE) CN701 REFO1 L 13942296513 HOME LOADING/CARRIAGE MOTOR SPINDLE MOTOR u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Page 75
3 7 63 1515 0 CD CORE UNIT(S10.5COMP2-iPod-C3)(EW5, ES) SIDE B CD CORE UNIT(S10.5iPod-C3-CLASS1)(CN5) 12EJ DSCSNS L 13942296513 u163 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
(B,135,85) IC PML018A D 809 (B,80,13) Varistor EZJZ1V270RM IC 251 (B,46,65) IC BD6538G D 810 (B,97,16) Varistor EZJZ1V800AM IC 301 (A,104,139) IC PAL007C D 811 (B,68,13) Varistor EZJZ1V800AM IC 401 (B,165,30) IC NJM2885DL1-33 D 812 (B,41,10) Varistor EZJZ1V270RM DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Page 79
R 615 (B,110,51) RS1/16S222J R 304 (B,135,109) RS1/16S471J R 616 (B,35,28) RS1/16S473J R 306 (B,130,110) RS1/16S471J R 617 (B,99,52) RS1/16S0R0J R 309 (A,98,107) RD1/4PU153J R 618 (B,71,60) (EW5) RS1/16S102J R 351 (B,159,115) RS1/16S821J R 619 (B,112,74) (EW5) RS1/16S0R0J DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Page 80
R 936 (B,59,99) RS1/16S473J C 407 (B,159,68) CKSRYB103K50 C 408 (A,157,31) CEJQ220M10 R 937 (B,62,118) RS1/16S472J C 410 (B,154,27) (ES) CKSRYB474K10 R 938 (B,59,126) RS1/4SA102J R 951 (B,106,107) RS1/16S473J C 411 (B,167,93) (ES) CCSRCH470J50 R 952 (B,106,105) (EW5) RS1/16S102J DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Page 81
CKSRYB472K50 u163 (A,147,40) LED CL-197HB1-D(CDE) (B,152,37) (EW5,ES) CCSRCH101J50 (A,6,34) LED CL-197HB1-D(CDE) (B,149,37) (EW5,ES) CCSRCH102J50 (B,151,37) (EW5,ES) CKSRYB103K50 (A,7,40) LED CL-197HB1-D(CDE) C 10 (B,137,23) (EW5,ES) CKSRYF104Z25 (A,6,9) LED CL-197HB1-D(CDE) D 10 (A,13,9) LED CL-197HB1-D(CDE) D 11 (A,16,31) LED CL-197HB1-D(CDE) DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
(B,22,55) RS1/16SS473J C 1809 (B,14,40) CKSSYB104K10 R 249 (B,14,50) RS1/16SS103J R 250 (B,19,50) RS1/16SS101J C 1810 (B,12,40) CKSQYB475K10 R 252 (B,18,47) RS1/16SS101J C 1901 (B,4,31) CKSQYB225K10 R 254 (A,25,64) RS1/16SS104J C 1902 (B,27,36) CCSSCH100D50 R 255 (A,26,63) RS1/16SS104J DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...
Page 83
CKSSYB104K10 C 226 (A,42,59) CCSSCH680J50 C 227 (A,42,61) CCSSCH470J50 C 228 (B,41,61) CKSSYB103K16 C 229 (B,48,60) CKSSYB104K10 u163 C 236 (A,49,58) CKSSYB104K10 C 239 (B,46,51) CCSSCH220J50 C 240 (A,38,61) CKSSYB104K10 C 243 (B,22,41) CKSQYB475K10 C 250 (A,52,48) CKSSYB102K50 DEH-P4100SD/XS/EW5 http://www.xiaoyu163.com...