10. Service technicians should remove their watches while repairing an MWO. 16. Always connect a test instrument's ground lead to the instrument chassis ground before connecting the positive lead; always remove the instrument's ground lead last. Samsung Electronics...
PRECAUTION with the oven energized. Servicemen should remove their watches whenever DO NOT measure the voltage in the high voltage circuit working close to or replacing the magnetron. including filament voltage of magnetron. Samsung Electronics...
2. Specifications 2-1 Table of Specifications G639C POWER SOURCE 230V 50Hz, AC POWER CONSUMPTION MICROWAVE : 1,350W GRILL : 1,000W OUTPUT POWER FROM 120W TO 800W (9 LEVEL POWER) (IEC-705 TEST PROCEDURE) OPERATING FREQUENCY 2450MHz TIMER 60 MINUTES COOLING METHOD...
3. Set the time to 4 to 5 minutes by turing TIMER knob. Important : If any problem is experienced in the operation of the oven, please refer to the section on page 4 "what to do if you are in doubt or have a problem." Samsung Electronics...
Serving Size Power level Standing Time 2. Turn the COOKING POWER CONTROL knob to Max Power. 100% 2~3mins. Drink 150ml 3. Turn the TIMER knob to select instant cook, drinks or jacket potatoes. Soup/ 200~300 100% 2~3mins Sauce Fresh 200~300 100% 2~3mins Vegetables Samsung Electronics...
There exists HIGH VOLTAGE ELECTRICITY with high current capabilities in the circuits of the HIGH VOLTAGE TRANSFORMER secondary and filament terminals. It is extremely dangerous to work on or near these circuits with the oven energized. DO NOT measure the voltage in the high voltage circuit including filament voltage of magnetron. Samsung Electronics...
1. Insertion depth of the thin metal plate should be 0.5mm or less. 4-3-4 Removal of Key Door & Spring Door "E" Remove pin hinge from Door "E" Detach spring from Door "E" and key door. Door Key Spring Key Samsung Electronics...
Page 10
2. Disconnect the connectors from the heater ceramic and wire leade. 3. Remove two(3) screws securing the bracket upper to Bracket Upper the oven cavity. 4. Remove one screw securing the bracket heater. Ceramic Bracket Heater Heater Screw Samsung Electronics...
2. Isolate the magnetron from the circuit by disconnecting its leads. 3. A continuity check across the magnetron filament terminals should indicate one ohm or less. 4. A continuity check between each filament Cooling Fins terminal and the magnetron case should read "open". Samsung Electronics...
Door Closed 5. Confirm that the gap between the switch housing and the switch actuator is no more than 0.5mm ∞ Primary switch when door is closed. ∞ Monitor switch (COM-NC) ∞ Monitor switch (COM-NO) ∞ Secondary switch Samsung Electronics...
5. After heating for 2 minutes, measure the temperatures of water in each beaker. 6. Microwave heat distribution rate can be caicviated as follows : Minimum Temperature Rise Heat Distribution = X 100(%) Maximum Temperature Rise The result should exceed 65%. Samsung Electronics...
; CENTRAL SERVICE CENTER 5-11-2 At least once a year have the microwave energy survey meter checked for accuracy by its manufacturer. Samsung Electronics...
2) Defective con- The oven lamp does not light and fan motor Replace the timer. tacts of timer does not operate. NOTE: Interlock monitor switch must be replaced when the fuse is blown out. Samsung Electronics...
Page 16
3) Too small a If a small amount of food is heated repeatedly over To increase the oven load or no a long period of time, microwave turns off during load, place a glass of load operation. water into the oven. Samsung Electronics...
1) If there is no continuity in forward, direction the H.V.Diode is open. Replace. 2) If there is continuity in reverse direction, it's shorted. Fan motor Fan motor Check if the motor coil is open. Replace. does not rotate. Samsung Electronics...
S/W3 S/W3 PRIMARY GREEN LATCH SWITCH LATCH YELLOW/GREEN MWO MODE CYCEL MODE GRILL MODE SWITCH SWITCH High Voltage Circuit MAGNETRON HIGH VOLTAGE DIODE TO CHASSIS HIGH VOLTAGE CAPACITOR H.V.FUSE SYMBOL COLOR ORANGE BROWN BLACK BLUE HIGH VOLTAGE TRANSFORMER Samsung Electronics...