Section 9: Installing The Accessories; Installing The Log Set - Montigo H42DF Installation & Maintenance Manual

Section 9: Installing the Accessories

Installing the Log set:

The H42DF* is supplied with a seven ceramic fibre log logset.
Unpack the logs and handle them very carefully.
Step 1. Remove the glass door as described in the previous
Instructions.
Rear / Bottom Log
Notch in Log
Pilot Assembly
Fireplace Base
Figure 27. Placing Bottom Rear Log.
Step 2. Place the bottom Rear log as shown in figure 27.
Align
Bottom Left Log
Fireplace Base
Figure 27a. Placing Bottom Right / Left Logs.
Step 3. Place the bottom Right and Left logs as shown in figure
27a.
Top
Left Log
Align Pins
Top Left
Log
Figure 27b. Top Left / Right Log.
Step 4. Place the Top Right log as shown in figure 27b. using the
(4) four alignment pins protruding from the top of the Right and
Left Bottom Logs, as shown in figure 27b. With these pins align the
Top Right and Left logs using the predetermined alignment holes
cast into the underside of the logs, as shown above, figure 27c.
XG0148 - 151123
Installation
Air Inlets
Bottom Right Log
Right Log
Align Pins
Notch in Log
Top Right
Step 5. Place the Centre Front log , Figure 27c below, as shown using
the notch cast in the Bottom Rear log as shown in figure 27b
Figure 27c. Placing Centre Front Log.
Step 7. Place the Right Centre log as shown in figure 27d.
Align
Figure 27d. Placing Right Center Log.
Step 8. Place the Right Centre log as shown using the notch in the
Top Right log as a guide, figure 27e.
Top
Figure 27e. Placing Embers.
Step 9. Place the Embers as shown in figure 27e.
Arrange the ember chips on top of the burner tray. Care should
Log
be taken when placing the embers, as blocked burner ports
may cause an incorrect flame pattern, carbon deposits and
delayed ignition. Also, the embers must never be placed in
a way that obstructs any of the air inlet ports, located at the
rear of the burner, as shown in figure 27a.
If logs are not placed properly, excessive sooting will result.
H*42DF Indoor Gas Fireplace
Center Front log
Centerline of Fireplace
Right Fr ont
Log
Rest Log
Place Embers in this area
NOTICE
Gr oove
in Log
Page 27