Operating Instructions - Pentair Pool Products PacFab MiniMax 100 User & Installation Manual

Users Section
MINIMAX 100 DIRECT-SPARK IGNITION LIGHTING/OPERATION-
NATURAL GAS & PROPANE
FOR YOUR SAFETY: READ BEFORE LIGHTING
If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal
injury or loss of life.
A. This appliance is equipped with an ignition device
which automatically lights the burner. Do not try to
light the burner by hand.
B. BEFORE OPERATING smell all around the
appliance area for gas. Be sure to smell next to the
floor because some gas is heavier than air and will
settle on the floor.
SAFETY INFORMATION - IF YOU SMELL GAS, FOLLOW THESE RULES
1.
Shut off gas line or propane tank.
2.
Immediately call your gas supplier from a
neighbour's phone.
3.
Follow the gas supplier's instructions.
4.
If you cannot reach your gas supplier, call the fire
brigade.
STOP! HAVE YOU READ THE SAFETY INFORMATION?

OPERATING INSTRUCTIONS

1. Make sure pump is running and primed.
2. Push power switch on.
3. Set thermostat to desired setting.
4. The unit should spark and the burner should ignite.
5. In new installations where the gas line hasn't been
bled, the ignition sequence may require resetting by
interrupting the electrical supply following each
failed ignition.
1. Set the thermostat to lowest setting and turn off
power switch.
2. Turn off all electric power to the appliance if
service is to be performed, (if applicable).
Rev. A 2-4-2000
WARNING
TO LIGHT THE APPLIANCE
TO TURN THE APPLIANCE OFF
C. Do not use this appliance if any part has been
under water. Immediately call a qualified
service technician to inspect the appliance and
to replace any part of the control system and
any gas control which has been under water.
D. Never store any materials within the vicinity of
the appliance or ventilation openings.
5.
Do not light matches or lighter.
6.
Do not try to light any appliance.
7.
Do not touch any electric switch; do not use any
phone in your building.
8.
Open all doors and windows. (Indoor)
6. If the heater does not operate as it should, in a
reasonable amount of time, read the
Troubleshooting Guide portion of this manual or
isolate gas supply and call a service technician at
your gas supplier.
3. If the appliance is to be turned off during a period
when frost is likely, consult your service
engineer/gas supplier to take the appropriate
action. (Drain the system.)
2
P/N 471438