Troubleshooting - Toyotomi KS-27A Operation And Maintenance Instructions

PROBLEM
Wick fails to ignite
Smoke or odor
Flickering, dying or
low flame

TROUBLESHOOTING

CAUSE
Out of fuel
Water in kerosene/poor quality
kerosene
Heat chamber tilted or improperIy
seated
Wick set too high
Dirty wick
Drafts
Contaminated fueI/poor quality
kerosene
Dirty wick
Water in kerosene/poor quality
kerosene
Wick too low to sustain good
flame
SOLUTlON
Check fuel gauge; add fuel if necessary.
Drain tank. Install new wick.
Refill with fresh and clean kerosene.
Move wire handle until heat chamber is
properly seated and moves smoothly left and
right.
Reduce wick height by turning wick adjuster
knob counterclockwise.
Clean wick as described under "Care and
Maintenance".
Relocate heater.
Drain tank and rinse with clean kerosene. lnstall
new wick and refill with fresh and clean
kerosene.
Clean wick as described under "Care and
Maintenance". lf necessary, install new wick.
Drain tank and rinse with clean kerosene.
lnstall new wick and refill with fresh, clean
kerosene.
Replace wick.
PAGE
7
11
8
9
10
2
10
11
10
11
10
11
9
11