User Manuals: Primus DAM 9 Tumble Dryer Marine

Manuals and User Guides for Primus DAM 9 Tumble Dryer Marine. We have 1 Primus DAM 9 Tumble Dryer Marine manual available for free PDF download: Service Manual

Primus DAM 9 Service Manual (128 pages)

INDUSTRIAL DRYERS

Brand: Primus | Category: Dryer | Size: 6 MB

Table of Contents
3
Section 1 - Safety Information

5
- Locating an Authorized Servicer
  6
Section 2 - Introduction

7
- Customer Service
  7
- Nameplate Location
  7
- Model Identification
  8
- How Your Dryer Works
  10
Section 3 - Troubleshooting

11
Section 4 - Grounding

21
18 Ground Wires from Dryer Base to Wire Harness and to Ignition Control (Gas Models with Silicon Nitride Ignition System)

23
Section 5 - Service Procedures

25
19 Access Panel

25
20 Control Panel and Controls (Metered and Nonmetered)

25
- To Test Push-To-Start Switch
  25
21 Graphic Overlay

27
- To Test Fabric Selector Switch
  27
22 Timer (Nonmetered Models)

28
- To Test Timer Contacts (Nonmetered Models)
  28
23 Accumulator (Metered Models)

30
- To Test Accumulator (Metered Models)
  31
24 Electronic Control

32
25 Coin Drop

34
26 Meter Case (Metered Models)

39
27 Timer Case (Nonmetered Models)

41
28 Security Case and Card Reader

42
29 Control Hood

45
30 Cabinet Top (Nonmetered Models)

45
31 Cabinet Top (Metered Models)

46
32 Lint Filter

47
33 Loading Door and Door Hinge

47
- Reversing Door Procedure
  48
34 Inner and Outer Door Panels and Door Pull

49
35 Door Strike

49
36 Door Seal

50
37 Front Panel and Panel Seal

51
38 Door Switch

51
- To Test Door Switch
  51
39 Door Catch

51
40 Door Hinges

53
41 Hold-Down Clips and Locators

53
42 Burner System Components (Gas Models)

54
- To Test Gas Valve Coils (Gas Models)
  56
- To Test Igniter (Gas Models)
  57
- Ignition Control Grounding Check
  57
- To Test Electrical Circuit to Ignition System (Gas Models)
  57
- To Test Sensor (Gas Models)
  57
- 43 Burner Housing and Heat Shroud (Gas Models)
  
  59
- 44 Limit Thermostat
  
  59
  - To Test Heater Assembly (Electric Models)
    59
- 45 Heating Element (Electric Models)
  
  60
- 46 Thermistor or Thermostat
  
  61
  - To Test Thermal Fuse (Electric Models)
    61
  - To Test Cycling or Limit Thermostat
    62
- 47 Air Duct
  
  62
- 48 Motor and Exhaust Assembly
  
  62
  - To Test Drive Motor
    66
- 49 Front Bulkhead Assembly
  
  69
- 50 Cylinder Belt
  
  71
- 51 Cylinder Assembly
  
  72
- 52 Rear Seal
  
  73
- 53 Cylinder Rollers
  
  75
- 54 Outlet Cover
  
  75
- 55 Rear Bulkhead and Heater Box
  
  76
- 56 Terminal Block or Power Cord
  
  78
Section 6 - Adjustments

87
- 58 Leveling Legs
  
  87
- 59 Burner Flame (Gas Models)
  
  88
Section 7 - Internal Wiring of Dryer Motor Switch

91
Section 8 - Wiring Diagrams

93
- Model SDE707*F1500
  94
- Model SDE607*F1500
  95
- Models SDE407*F1500 and SDE507*F1500
  96
- Models SDE107*F1500, SDE107*F1724 and SDE307*F1500
  97
- Model SDG409*F3058
  98
- Model SDE009*F3058
  99
- Model SDE407*F4350
  100
- Model SDE407*A3000
  101
- Model SDE107*F4350
  102
- Model SDE007*F4350
  103
- Model HDG709*F1102
  104
- Model HDG509*F1102
  105
- Models HDG109*F3000, SDG109*F3000 and SDG109*F5412
  106
- Models HDG109*F1102 and SDG109*F1124
  107
- Models HDG009*F3000, SDG009*F3000 and UDG009*F3000
  108
- Models HDG109*G3013 and SGG109*G3013
  109
- Model HDG009*F1102
  110
- Model HDG009*G3008
  111
- Models HDE707*F1502 and HDE707*F1702
  112
- Models HDE507*F1502 and HDE507*F1702
  113
- Models HDE107*F3000, SDE107*F3000 and SDE107*F5412
  114
- Models HDE107*F1502 and HDE107*F1702
  115
- Models HDE107*G3003, HDE107*G3018 and SDE107*G3018
  116
- Model HDE007*F1702
  117
- Models HDE007*F3000, SDE007*F3000 and UDE007*F3000
  118
- Models HDE007*G3003, HDE007*G3008, HDE007*G3010 and SDE007*G3018
  119
- Model UDE007*F3025
  120
- Model UDG009*F3025
  121
- Models HDEB07*J1502, HDEB07*J1702, HDEF07*J1502, HDEF07*J1702, SDEA07*J1500, SDEB07*J1500 and SDEF07*J1500
  122
- Models HDGB09*J1102 and HDGF09*J1102
  123
- Model SDEA07*J3000
  124
- Model SDEA07*J4350
  125

Primus Categories

Stove

Washer Camping Equipment Lantern

Dryer

More Primus Manuals

User Manuals: Primus DAM 9 Tumble Dryer Marine

Primus DAM 9 Service Manual (128 pages)

Table of Contents

Section 1 - Safety Information

Section 2 - Introduction

Section 3 - Troubleshooting

1 Motor Does Not Run

2 Unit Stops in Cycle; Quits after the First few Loads; Has a Burning Smell; Cycles on Motor Thermal Protector

3 Motor Runs but Cylinder Does Not Turn

4 Motor Does Not Stop

5 Heating Assembly Does Not Heat or Burner Does Not Ignite

6 Igniter Does Not Glow (Gas Supply Sufficient) - Gas Models

7 Burner Ignites and Goes out Repeatedly - Gas Models

8 Igniter Glows but Burner Does Not Ignite - Gas Models

9 Heater Assembly or Burner Shuts off Prematurely

10 Heater Assembly or Burner Repeatedly Cycles off on Limit Thermostat

11 Heater Assembly or Burner Does Not Shut off

12 Clothes Do Not Dry

13 Clothes Are too Hot When Removed from Dryer

14 Ignition Control Flashes

Section 4 - Grounding

15 Ground Wires from Terminal Block or Power Cord to Rear Bulkhead and from Rear Bulkhead to Control Housing

16 Metered and Nonmetered Models - Ground Wires from Rear Bulkhead to Accumulator Bracket or Timer (Depending on Model) and from Cabinet Top to Control Panel

17 Ground Wires from Rear Bulkhead to Timer Mounting Bracket and to Dryer Cabinet Top

18 Ground Wires from Dryer Base to Wire Harness and to Ignition Control (Gas Models with Silicon Nitride Ignition System)

Section 5 - Service Procedures

19 Access Panel

20 Control Panel and Controls (Metered and Nonmetered)

21 Graphic Overlay

22 Timer (Nonmetered Models)

23 Accumulator (Metered Models)

24 Electronic Control

25 Coin Drop

26 Meter Case (Metered Models)

27 Timer Case (Nonmetered Models)

28 Security Case and Card Reader

29 Control Hood

30 Cabinet Top (Nonmetered Models)

31 Cabinet Top (Metered Models)

32 Lint Filter

33 Loading Door and Door Hinge

34 Inner and Outer Door Panels and Door Pull

35 Door Strike

36 Door Seal

37 Front Panel and Panel Seal

38 Door Switch

39 Door Catch

40 Door Hinges

41 Hold-Down Clips and Locators

42 Burner System Components (Gas Models)

43 Burner Housing and Heat Shroud (Gas Models)

44 Limit Thermostat

45 Heating Element (Electric Models)

46 Thermistor or Thermostat

47 Air Duct

48 Motor and Exhaust Assembly

49 Front Bulkhead Assembly

50 Cylinder Belt

51 Cylinder Assembly

52 Rear Seal

53 Cylinder Rollers

54 Outlet Cover

55 Rear Bulkhead and Heater Box

56 Terminal Block or Power Cord

Section 6 - Adjustments

58 Leveling Legs

59 Burner Flame (Gas Models)

Section 7 - Internal Wiring of Dryer Motor Switch

Section 8 - Wiring Diagrams

Related Products

Primus Categories