Diamond Aircraft DA 40 NG Data Logger Manuals

Manuals and User Guides for Diamond Aircraft DA 40 NG Data Logger. We have 3 Diamond Aircraft DA 40 NG Data Logger manuals available for free PDF download: Airplane Maintenance Manual, Airplane Flight Manual, Manual

Diamond Aircraft DA 40 NG Airplane Maintenance Manual (1765 pages)

Brand: Diamond Aircraft | Category: Tools | Size: 38 MB

Table of Contents

35
- Chapter 0 1 Introduction
  37
- General
  37
- Revision Service
  37
- Warnings, Cautions and Notes
  37
- Manual Configuration
  38
- Figures
  42
- List of Effective
  42
- Page Numbering System
  42
- Record of Revisions
  42
Table of Contents

45
- Applicability
  47
- Chapter 0 2 Organization and Handling of the Manual
  47
- General
  47
- Revisions
  47
- Temporary Revisions
  47
- Service Bulletins
  48
- Concession-Reports and Non-Conformance-Reports
  49
- Service Information
  49
- Abbreviations
  50
- Conversion Factors and Abbreviations
  52
- Torque Conversion Graphs
  54
Table of Contents

59
- Chapter 0 1 Chapter 0 3
  61
- Description
  61
- General
  61
- Equipment Data
  64
- Handling of Identification Data
  67
Table of Contents

81
- Chapter 0 5 Time Limits and Maintenance Checks
  85
- Chapter Configuration
  85
- General
  85
- Definitions
  88
- General
  91
- Scheduled Maintenance Time Limits
  91
- Time Limits
  91
- Component Time Limits
  93
- Component Time Tracking
  97
- General
  99
- Scheduled Maintenance Checks
  99
- Maintenance Checklist Organization
  100
- Major Structural Inspection
  101
- Flight-Line Checks
  103
- General
  103
- Post-Flight Check
  103
- Drain Holes Inspection Checklist and Report
  105
- General
  105
- Drain Holes Inspection Checklist
  106
- General
  115
- Maintenance Checklist da 40 NG
  115
- Maintenance Checklist Engine
  115
- Preparation
  116
- Engine Ground Test
  117
- Engine Maintenance Checklist
  118
- Propeller
  125
- Front Fuselage
  127
- Maintenance Checklist Airframe
  127
- Cockpit
  134
- Center Fuselage, Internal
  139
- Rear Fuselage
  143
- Tail
  145
- Wings
  149
- General
  154
- Maintenance Report
  157
- General
  165
- Major Structural Inspection Check Findings Report
  165
- General
  169
- Hard Landing Check
  169
- Unscheduled Maintenance Checks
  169
- Propeller Strike
  175
- Engine Fire
  176
- Lightning Strike
  178
- High Oil Consumption
  184
- Over Temperature
  184
- Hang Start
  185
- Oil Pressure Loss
  185
Table of Contents

247
- General
  249
- CHAPTER 10 Parking and Storage
  251
- General
  251
- Storage
  254
- General
  255
- Mooring
  255
- General
  257
- Return to Service
  257
- Return to Service Procedure
  257
Scheduled Servicing

281
- Chapter 12 Servicing
  283
- General
  283
- Fuel System
  285
- General
  285
- Replenishing
  285
- Refueling/Defueling
  287
- Fuel Contamination Test
  288
- Engine Oil System
  289
- Gearbox Oil
  290
- Engine Coolant
  293
- Brake System
  296
- Tires
  297
- General
  299
- Scheduled Servicing
  299
- Lubrication Schedule
  300
- Canopy Cleaning
  305
- Exterior Cleaning
  305
- Engine Cleaning
  306
- Interior Cleaning
  306
- Snow and Ice Removal
  307
- Conservation of Exterior Parts
  308
Table of Contents

325
- Chapter 20 Standard Practices - Airframe
  327
- General
  327
- Bolt and Nut Types Used in the Airplane
  329
- General
  329
- Standard Practices - Airframe
  329
- Standard Torque Values
  330
- Special Torque Values
  331
- Torque Measurement
  332
- General
  333
- Repair and Maintenance
  333
- Standard Practices - Electrical
  333
- Thread Locking
  333
- General
  337
- Special Torque Procedures
  337
- Standard Practices - Engine
  337
- Torque Values
  337
- Installation and Tightening Torques of Worm Drive Clamps
  341
Table of Contents

347
- CHAPTER 21 Trouble-Shooting
  353
- General
  353
- General
  355
- Maintenance Practices
  355
- Remove/Install the Heat Valve
  355
- Test/Adjust the Heat Valve
  358
- Remove/Install the Distributor Valve
  359
- Test/Adjust the Distributor Valve
  362
  - Cooling
    365
- Description
  365
- General
  365
- Operation
  368
  - Trouble Shooting
    369
- General
  369
- Maintenance Practices
  371
- Remove/ Install the Central Unit
  371
- Remove/Install the Control Panel
  376
- RACC System Test Procedure
  377
- Remove/Install Parts of the Refrigerant Circuit
  378
  - Cooling (OÄM 40-316/I or Later Installed)
    383
- Description
  383
- General
  383
- Operation
  386
  - Trouble Shooting
    387
- General
  387
  - Maintenance Practices
    389
- Remove/ Install the Central Unit
  389
- Remove/Install the Control Panel
  394
- RACC - System Test Procedure
  395
- Remove/Install Parts of the Refrigerant Circuit
  396
Maintenance Practices

405
- CHAPTER 22 Autopilot, GFC 700
  409
- Description
  409
- General
  409
- General
  413
- Maintenance Practices
  413
- Remove/Install the Roll Servo
  413
- Remove/Install the Roll Servo Clutch
  414
- Remove/Install the Pitch Servo
  416
- Remove/Install the Pitch Servo Clutch
  418
- Remove/Install the Pitch Trim Servo
  421
- Remove/Install the Pitch Trim Servo Clutch
  422
- Adjust the Bridle Cable Tension of the Roll and Pitch Servos
  423
- Adjust/Check the Servo Clutch Torques
  424
- Mechanical Check of the Autopilot System (if MÄM 40-561 (GSM 86 Servo Mounts) Is Installed)
  425
- Mechanical Check of the Autopilot System (if MÄM 40-561 (GSM 86 Servo Mounts) Is Not Installed)
  425
- Slip Clutch Override Procedure
  426
  - Autopilot, KAP 140
    427
- Description
  427
- General
  427
- General
  435
- Maintenance Practices
  435
- Remove/Install the Flight Control Computer
  435
- Remove/Install the KCM 100 Configuration Module
  437
- Remove/Install the Roll Servo
  439
- Remove/Install the Roll Servo Clutch
  440
- Remove/Install the Pitch Servo
  442
- Remove/Install the Pitch Servo Clutch
  443
- Remove/Install the Pitch Trim Servo
  445
- Remove/Install the Pitch Trim Servo Clutch
  446
- Adjust the Bridle Cable Tension
  447
- Adjust the Servo Clutch Torques
  448
- Mechanical Test of the Autopilot
  449
Electrical Power/Maintenance Practices

507
- Trouble-Shooting
  509
- Chapter 24 Electrical Power
  511
- General
  511
- VDC System Description and Operation
  516
  - DC Generation
    521
- General
  521
- Description and Operation
  524
  - Trouble-Shooting
    525
- General
  525
  - Maintenance Practices
    527
- Electrical Safety
  527
  - Installed
    528
  - Installed
    529
- General
  527
- Replacement of the Alternator Cable
  530
  - Battery System
    533
- General
  533
- Main Battery Description and Operation
  533
- ECU Backup Battery Description and Operation
  535
  - General
    537
  - Electrical Safety
    559
  - Remove/Install the External Power Relay
    570
  - DC Electrical Load Distribution
    573
  - General
    573
  - General
    579
  - Remove/Install the Avionics Master Relay
    582
  - Remove/Install a Circuit-Breaker
    583
  - Remove /Install an Instrument Panel Switch
    585
  - Remove /Install the ENGINE Switch
    587
Table of Contents

591
- Chapter 25 Equipment/Furnishings - General
  593
- General
  593
- Description and Operation
  595
- Flight Compartment
  595
- General
  595
- General
  605
- Maintenance Practices
  605
- Remove/Install a Pilot's Seat
  605
- Additional Maintenance Practices for Seats with Adjustable Backrest
  608
- Remove/Install a Pilot's Seat Access Panel (if Installed)
  624
- Remove/Install the Access Panel of the Passenger Seat (if Installed)
  625
- Remove/Install the Access Panel in the Baggage Extension
  626
- Remove/Install the Baggage Extension and Baggage Tray
  627
- Remove/Install the Short Baggage Extension and Baggage Tray
  628
- Remove/Install the Passenger Seat
  631
- Remove/Install a Safety Belt
  633
- Remove/Install the Instrument Panel Cover
  634
- Cleaning
  635
- Description
  637
- Emergency
  637
- General
  637
- Operation
  640
- Replace the ELT Batteries
  641
- Remove/Install the RCS
  648
- ELT Periodic Inspection
  649
Table of Contents

659
- Chapter 27 Flight Controls
  663
- Description
  663
- General
  663
- Control Rigging
  665
  - Maintenance Practices
    667
- Push-Rods
  665
- General
  667
- Push-Rod Adjustment
  667
- Remove/Install Bellcranks and Levers
  668
  - Flight Controls - Ailerons and Tabs
    669
- General
  669
- Description
  671
  - Trouble-Shooting
    675
- General
  675
  - Maintenance Practices
    677
- General
  677
- Aileron Control System Test for Correct Range of Movement
  678
- Aileron Control System Adjustments
  680
- Aileron Bellcrank and Lever Access
  683
- Aileron Push-Rod Access
  683
- Flight Controls - Rudder
  685
- General
  685
- Description
  687
- Operation
  688
  - Trouble-Shooting
    693
- General
  693
- General
  695
- Maintenance Practices
  695
- Rudder Control System Test for Correct Range of Movement
  695
- Rudder Control System Adjustments
  697
- Remove/Install Rudder Control Cables
  699
- Rudder Control Cable and Yoke Access
  705
- Description
  707
- Flight Controls - Elevator
  707
- General
  707
- Operation
  709
  - Trouble-Shooting
    711
- General
  711
- Elevator Control System Test for Correct Range of Movement
  713
- General
  713
- Maintenance Practices
  713
- Elevator Control System Adjustments
  715
- Elevator Bellcrank and Lever Access
  717
  - Flight Controls - Elevator Trim
    719
- Elevator Push-Rod Access
  717
- Description
  719
- General
  719
- Emergency Operation
  723
  - Trouble-Shooting
    725
- Operation
  723
- General
  725
  - Maintenance Practices
    727
- Elevator Trim Control System Test for Correct Range of Movement
  727
- General
  727
- Elevator Trim Control System Adjustments
  728
  - Stall Warning System
    733
- Description and Operation
  733
  - Trouble-Shooting
    737
- General
  733
- General
  737
  - Maintenance Practices
    739
- General
  739
- Remove/Install the Stall Warning Horn (System Without Capillary)
  739
- Remove/Install a Stall Warning Horn Assy
  741
- Ball Valve)
  743
- Procedure to Remove Water from the Stall Warning System
  745
- Stall Warning Horn Classification Test
  745
- Flight Controls - Flaps
  747
- General
  747
- Description
  749
- Operation
  753
  - Trouble-Shooting
    755
- General
  755
- General
  759
- Maintenance Practices
  759
- Test the Flap Control System
  762
- Adjust the Flap Control System
  764
- Flap Bellcrank and Lever Access
  767
Fuel Storage System/Maintenance Practices

771
- Flap Push-Rod Access
  767
- Chapter 28 Fuel System
  777
- Description
  778
- Operation
  780
- Fuel Storage System
  783
- General
  783
- Fuel Tank Description
  786
- Fuel Filler Assembly
  790
  - Trouble-Shooting
    791
- General
  791
- General
  793
- Maintenance Practices
  793
- Remove/Disassemble the Fuel Tank Assembly
  793
- Assemble/Install the Fuel Tank Assembly
  796
- Fuel Distribution System
  811
- General
  811
- Description
  813
- Fuel System Components
  813
- Fuel Transfer System Operation
  815
  - Trouble-Shooting
    817
- General
  817
- General
  819
- Maintenance Practices
  819
- Remove/Install the Fuel Valve and the Gascolator
  819
- Remove/Install the Gascolator Filter
  822
- Remove/Install the Fuel Filter Body
  824
- Remove/Replace/Install the Fuel Pressure Pulsation Damper
  826
- Remove/Install the Electrically Driven Fuel Pumps with Bypass Valve
  828
- Remove/Install the Fuel Transfer Pump
  830
- Disassemble/Assemble the Fuel Transfer Pump Assembly
  831
- Remove/Install the Fuel Cooler
  833
- Test the Fuel Valve
  834
- Test the Check Valve in the Fuel Return Line
  835
- Description
  837
- Fuel Quantity Indicating
  837
- General
  837
- Operation
  838
Table of Contents

851
- Chapter 31 Indicating Systems
  855
- General
  855
- General
  857
- Instrument and Control Panels with G1000 System Installed
  857
- Instrument Panel Description
  859
- Center Console Description
  861
  - Trouble-Shooting
    863
- General
  863
- General
  865
- Maintenance Practices
  865
- Remove/Install the Engine Control Assembly
  865
- General
  869
- Instrument and Control Panels with Conventional Cockpit Installed
  869
- Instrument Panel Description
  872
- Description
  873
  - Maintenance Practices
    875
- General
  873
- Independent Instruments
  873
- General
  875
- Remove/Install the Digital Chronometer
  875
  - Central Computers
    877
- General
  877
- Description
  879
  - Trouble-Shooting
    891
- General
  891
  - Maintenance Practices
    893
- General
  893
- Remove/Install a GDU 10XX Display
  896
- Remove/Install a GIA 63 Integrated Avionics Unit (IAU)
  899
- Remove/Install the GTX33/335 R Transponder
  902
- Remove/Install the GRS7X Attitude, Heading and Reference Unit (AHRS)
  905
- Remove/Install the GDC 7X Air Data Computer (ADC)
  909
- Remove/Install the GEA 71 Processor
  911
- GMU 44 Magnetometer
  913
- Central Warning System with Conventional Cockpit Installed
  917
- Description and Operation - White Wire Annunciator Panel
  917
- General
  917
- Functional Check
  919
- Wiring Diagrams
  919
  - Trouble-Shooting
    921
- General
  921
  - Maintenance Practices
    923
- General
  923
- Remove/Install the Annunciator Panel
  923
- Test the Annunciator Panel
  924
Maintenance Practices

928
- General
  955
- Maintenance Practices
  955
- Remove/Install the Nose Landing Gear Strut
  955
- Remove/Install the Elastomer Pack / Hydraulic Damper
  959
- Replace the Elastomer Elements (if OÄM 40-379 Is NOT Installed)
  961
- Replace the Center Tube Assembly
  963
- Adjust the Nose Wheel Steering Friction
  965
- Nose Wheel Balancing
  966
- Description and Operation
  967
- General
  967
- Wheels and Brakes
  967
- General
  975
- Trouble-Shooting
  975
- General
  977
- Maintenance Practices
  977
- Remove/Install a Main Wheel
  977
- Remove/Install the Nose Wheel
  979
- Remove/Install a Brake Master Cylinder
  984
- Remove/Install a Brake Cylinder
  986
- Remove/Install the Parking Brake Valve
  989
- Bleed the Brake System
  990
- Condition the Brake Linings
  993
Table of Contents

997
- Chapter 33
  999
- Description
  999
- General
  999
- Description
  1003
- General
  1003
- Lights - Flight Compartment
  1003
- General
  1007
- Trouble-Shooting
  1007
- General
  1009
- Maintenance Practices
  1009
- Remove/Install a Cabin Light Assembly
  1009
- Remove/Install a Dimmer Switch
  1010
- Replace a Filament in a Reading Light Assembly
  1010
- Description
  1013
- Exterior Lights
  1013
- General
  1013
- Remove/Install/Check/Adjust the Taxi Light
  1023
- Remove/Install the Landing Light
  1029
- Remove/Install the HID Ballast Assembly for the Landing and the Taxi Lights (if Installed)
  1031
- Replace a Filament in the Wing-Tip Light Unit (Neither OÄM 40-341 nor OÄM 40-369 Is Installed)
  1035
- Remove/Install the Light Unit in the Wing-Tip
  1037
- Remove/Install a Strobe Power Unit in the Wing-Tip (if OÄM 40-369 Is NOT Installed)
  1039
Table of Contents

1043
- Chapter 34 Navigation
  1049
- General
  1049
- Description
  1050
- Flight Environment Data
  1050
- Description
  1053
  - Trouble-Shooting
    1057
- General
  1053
- General
  1057
- General
  1059
- Maintenance Practices
  1059
- Remove/Install a Pitot-Static Instrument
  1059
- Remove/Install the Pitot-Static Probe
  1060
- Pitot and Static System Leak Tests
  1061
- Clean the Pitot System and the Static System
  1066
- Attitude and Direction with G1000 System Installed
  1069
- Description and Operation
  1069
  - Trouble-Shooting
    1071
- General
  1069
- General
  1071
- General
  1073
- Maintenance Practices
  1073
- Remove/Install the Magnetic Compass
  1073
- Test/Adjust the Magnetic Compass (Compass Swing)
  1074
- Remove/Install the Attitude Gyro (Artificial Horizon)
  1076
- Attitude and Direction with Conventional Cockpit Installed
  1079
- General
  1079
  - Magnetic Compass with Conventional Cockpit Installed
    1081
- Description and Operation
  1081
- General
  1081
- General
  1083
  - Independent Position Determining with G1000 System Installed
    1101
  - General
    1101
    
    Stormscope System with G1000 System Installed
    1103
  - General
    1103
  - Description and Operation
    1103
    
    Trouble-Shooting
    1105
  - General
    1105
  - Remove/Install the Stormscope Processor
    1107
  - Remove/Install the Stormscope Antenna
    1108
  - Test of the Stormscope System
    1108
    
    Traffic Advisory System (TAS)
    1109
  - General
    1109
  - Description and Operation
    1109
    
    Trouble-Shooting
    1111
  - General
    1111
    
    Maintenance Practices
    1113
  - General
    1113
  - Remove/Install TAS Processor
    1113
  - Remove/Install Transponder Coupler
    1114
  - Remove/Install a TAS Antenna
    1115
  - Dependent Position Determining with G1000 System Installed
    1117
  - General
    1117
  - Description
    1117
    
    Trouble-Shooting
    1119
  - General
    1119
    
    Maintenance Practices
    1121
  - General
    1121
  - Replace a Dependent Position Determining System Antenna
    1121
  - Used Types of Flexible Co-Axial Cables
    1126
  - Sealant Specification
    1126
  - Post-Installation Check of the ADF System
    1126
  - Dependent Position Determining with Conventional Cockpit Installed
    1129
  - General
    1129
    
    Vor/Localizer/Glideslope (VOR/LOC/GS) with Conventional Cockpit Installed
    1131
  - General
    1131
  - Description and Operation
    1131
    
    Trouble-Shooting
    1133
  - General
    1133
    
    Maintenance Practices
    1135
  - General
    1135
    
    Transponder (XPDR) with Conventional Cockpit Installed
    1137
  - General
    1137
    
    Trouble-Shooting
    1141
    
    General
    1141
    
    Maintenance Practices
    1143
  - General
    1143
  - Remove/Install the Transponder
    1143
  - Remove/Install the Blind Altitude Encoder
    1145
  - Test the Transponder
    1146
  - Adjust/Test the Blind Altitude Encoder
    1148
Table of Contents

1151
- Chapter 51
  1155
- General
  1155
- Laminated Components
  1156
- Sandwich Structure
  1156
- Types of Structure
  1156
- Bonded Components
  1157
- Repair Limitations
  1157
- Damage Classification
  1159
- General
  1159
- Investigation
  1159
- Inspection Techniques
  1160
- Types of Damage
  1160
- Further Inspection
  1161
- Center of Gravity Limits
  1163
- Control Surface Balancing
  1163
- Drain/Vent Holes
  1163
- General
  1163
- Repair Processes
  1163
- Holding the Component
  1164
- Safety Precautions
  1164
- Workshop Conditions
  1165
- General
  1167
- Maintenance Practices
  1167
- Resin
  1167
- Core Material
  1168
- Glass and Carbon Cloth
  1168
- Laminating
  1169
- Bonding Paste (Thickened Resin)
  1173
- Curing
  1173
- Exterior Paint Finish
  1175
- Repairs
  1183
- Materials
  1184
- Approved Materials
  1193
- General
  1193
- Description
  1201
- General
  1201
- General
  1203
- Maintenance Practices
  1203
- Replace a Quick Release Fastener Stud
  1203
- Description
  1213
- Electrical Bonding
  1213
- General
  1213
- General
  1217
- Maintenance Practices
  1217
- Test the Electrical Bonding System
  1217
Table of Contents

1225
- Chapter 52
  1227
- Description
  1227
- General
  1227
- Canopy and Passenger Door
  1229
- General
  1229
- Canopy Description and Operation
  1231
- Passenger Door Description and Operation
  1236
- General
  1241
- Trouble-Shooting
  1241
- General
  1243
- Maintenance Practices
  1243
- Remove/Install the Canopy
  1243
- Remove/Install the Canopy Door Handle (if MÄM 40-139 Is Installed)
  1245
- Remove/Install the Gas Spring Strut for the Canopy
  1247
- Remove/Install the Passenger Door
  1248
- Remove/Install the Passenger Door Handle (if MÄM 40-139 Is Installed)
  1251
- Remove/Install the Passenger Door Locking Mechanism
  1253
- Remove/Install the Gas Spring Strut for the Door
  1255
- Test the Door Unlocked Warning Light
  1256
- Examine the Carbon Hinges on the Passenger Door
  1257
- Inspection of the Door Locking and Safety Hook Mechanisms
  1261
- Replace a Passenger Door Carbon Hinge
  1261
Maintenance Practices

1269
- General
  1271
- CHAPTER 53 Fuselage Structure
  1273
- General
  1273
- Description
  1275
- General
  1283
- Maintenance Practices
  1283
- Repair Data for the Fuselage Shells
  1283
Maintenance Practices/Maintenance Practices

1293
- CHAPTER 55 Horizontal Stabilizer
  1295
- General
  1295
- Description
  1297
- General
  1297
- General
  1299
- Maintenance Practices
  1299
- Remove/Install the Horizontal Stabilizer
  1299
- Repair Data for the Horizontal Stabilizer Shells
  1304
- General
  1307
- Description
  1309
- General
  1311
- Maintenance Practices
  1311
- Remove/Install the Elevator
  1311
- Remove/Install the Elevator Trim Tab
  1314
- Repair Data for the Elevator Shells
  1316
- Description
  1317
- General
  1317
- General
  1319
- Remove/Install the Lower Fin
  1319
- General
  1321
- Description
  1323
- General
  1325
- Remove/Install the Rudder and the Upper Bearing
  1325
- Repair Data for the Rudder Shells
  1328
Table of Contents

1331
- General
  1333
- CHAPTER 56 Flight Compartment Windows
  1335
- General
  1335
- Description and Operation
  1337
- General
  1339
- Maintenance Practices
  1339
- Replace a Window
  1339
- Window Repairs
  1341
Maintenance Practices/Maintenance Practices

1347
- General
  1349
- CHAPTER 57 Wing Structure
  1351
- General
  1351
- Description
  1353
- General
  1355
- Maintenance Practices
  1355
- Remove/Install the Wings
  1355
- Remove/Install the a or B-Bolts
  1366
- Remove/Install Control Surface Hinge Brackets
  1370
- Repair Data for the Wing Shells
  1371
- Description
  1377
- General
  1377
- General
  1379
- Maintenance Practices
  1379
- Remove/Install a Flap
  1379
- Repair Data for the Flap Shells
  1381
- Description
  1385
- General
  1385
- General
  1387
- Maintenance Practices
  1387
- Remove/Install an Aileron
  1387
Maintenance Practices

1395
- General
  1397
- Chapter 61 Propeller
  1399
- Description
  1399
- General
  1399
- Propeller Assembly
  1399
- Operation
  1402
- General
  1405
- Trouble-Shooting
  1405
- General
  1407
- Maintenance Practices
  1407
- Remove/Install the MTV-6-R/190-69 Propeller
  1407
- Propeller Blade Tracking Test
  1413
- Check/Adjust the V-Belt Tension of the Additional Alternator
  1414
- Remove/Install the Additional Alternator V-Belt (if OÄM 40-314 Is Installed)
  1417
- Remove/Install the Additional Alternator (if OÄM 40-314 Is Installed)
  1423
- General
  1427
- Propeller Control
  1427
- Description and Operation
  1429
- General
  1433
- Trouble-Shooting
  1433

Diamond Aircraft DA 40 NG Airplane Flight Manual (326 pages)

Brand: Diamond Aircraft | Category: Aircrafts | Size: 2 MB

General

17
- Table of Contents
  17
- Chapter 1
  18
- Introduction
  18
- Certification Basis
  20
- Warnings, Cautions and Notes
  20
- Dimensions
  21
- Definitions and Abbreviations
  23
- Units of Measurement
  31
  - Conversion Factors
    31
  - Conversion Chart Liter / Us Gallon
    33
- Three-View Drawing
  34
- Source Documentation
  35
  - Engine and Engine Instruments
    35
  - Propeller
    36
Operating Limitations

37
- Chapter 2
  38
- Introduction
  38
- Airspeed
  39
- Airspeed Indicator Markings
  40
- Power-Plant Limitations
  41
- Engine Instrument Markings
  47
- Warning, Caution and Status Lights
  48
- Mass (Weight)
  52
- Center of Gravity
  54
- Approved Maneuvers
  55
- Maneuvering Load Factors
  56
- Flight Crew
  57
- Operating Altitude
  57
- Kinds of Operation
  58
- Fuel
  62
- Limitation Placards
  65
- Other Limitations
  71
  - Temperature
    71
  - Battery Charge
    71
  - Emergency Switch
    71
  - Door Locking Device
    72
  - Electronic Equipment
    72
  - Smoking
    72
  - Use of the Sun Visors
    72
Emergency Procedures

73
- Chapter 3
  75
- General
  75
- Introduction
  75
- Certain Airspeeds in Emergencies
  76
- Instrument Indications in Prohibited (Red) Range
  77
  - Engine Temperature
    77
  - Oil Temperature
    79
  - Oil Pressure
    81
  - Gearbox Temperature
    82
  - L/R Fuel Temperature
    83
  - Fuel Pressure
    84
  - Alternator Amps
    85
  - Alternator Fail
    86
- Engine Problems
  87
- Failures in the Electrical System
  102
  - Complete Failure of the Electrical System
    102
  - High Current
    103
  - Starter Malfunction
    104
- Smoke and Fire
  105
  - Smoke and Fire on Ground
    105
  - Smoke and Fire During Take-Off
    107
  - Smoke and Fire in Flight
    110
- Gliding
  112
- Emergency Landings
  113
  - Emergency Landing with Engine off
    113
  - Gear
    115
  - Landing with Defective Brakes
    116
- Recovery from an Unintentional Spin
  117
- Other Emergencies
  118
  - Icing
    118
A Normal Operating Procedures

121
- Airspeeds for Normal Operating Procedures
  122
- Chapter 4 A
  122
- Introduction
  122
- Daily Check
  123
- Flight Characteristics
  123
- Checklists for Normal Operating Procedures
  124
  - 5.1 Pre-Flight Inspection
    124
  - 5.2 before Starting Engine
    132
  - 5.3 Starting Engine
    134
B Abnormal Operating Procedures

161
- Precautionary Landing
  162
- Instrument Indications Outside of Green Range
  164
  - 2.1 Rpm
    164
  - 2.2 Coolant Temperature
    165
  - 2.3 Oil Temperature
    166
  - 2.4 Oil Pressure
    167
  - 2.5 Gearbox Temperature
    168
  - 2.6 Fuel Temperature
    169
  - 2.7 Voltage
    170
  - 2.8 Current
    171
Performance

191
- Chapter 5
  192
- Introduction
  192
- Use of the Performance Tables and Diagrams
  192
- Performance Tables and Diagrams
  194
  - Airspeed Calibration
    194
  - Fuel Flow
    195
  - Pressure Altitude - Density Altitude
    196
  - International Standard Atmosphere
    197
  - Wind Components
    200
  - Take-Off Distance
    201
  - Climb Performance - Take-Off Climb
    207
  - Climb Performance - Cruise Climb
    210
  - Time, Fuel and Distance to Climb
    213
  - Cruise Performance
    217
  - Landing Distances
    218
Mass and Balance / Equipment List

233
- Chapter 6
  234
- Introduction
  234
- Datum Plane
  235
- Mass and Balance Report
  235
- Flight Mass and Center of Gravity
  237
  - Moment Arms
    237
  - Loading Diagram
    237
  - Calculation of Loading Condition
    237
  - Permissible Center of Gravity Range
    237
  - Permissible Moment Range
    237
- Equipment List and Equipment Inventory
  247
Description of the Airplane and Its Systems

261
- Airframe
  262
- Chapter 7
  262
- Introduction
  262
- Flight Controls
  263
- Instrument Panel
  268
- Landing Gear
  274
- Seats and Safety Harnesses
  276
- Baggage Compartment
  278
- Canopy, Rear Door, and Cabin Interior
  278
- Power Plant
  281
  - Engine, General
    281
  - Operating Controls
    282
  - Propeller
    285
  - Fuel System
    287
  - Cooling System
    295
  - Oil Systems
    297
- Electrical System
  298
  - General
    299
Airplane Handling, Care and Maintenance

309
- Airplane Inspection Intervals
  310
- Chapter 8
  310
- Introduction
  310
- Airplane Alterations or Repairs
  311
- Ground Handling / Road Transport
  311
  - Ground Handling Without Tow Bar
    311
  - Ground Handling with Tow Bar
    312
  - Parking
    314
  - Mooring
    317
  - Jacking
    317
  - Alignment
    317
  - Road Transport
    318
- Cleaning and Care
  319
  - Painted Surfaces
    319
  - Canopy and Rear Door
    319
  - Propeller
    320
  - Engine
    320
  - Interior Surfaces
    320
- Ground De-Icing
  321

Diamond Aircraft DA 40 NG Manual (12 pages)

SUPPLEMENT S10, FLIGHT DATA LOGGING DEVICE

Brand: Diamond Aircraft | Category: Data Loggers | Size: 0 MB

Diamond Aircraft Categories

Aircrafts Tools Data Loggers

More Diamond Aircraft Manuals

Diamond Aircraft DA 40 NG Data Logger Manuals

Diamond Aircraft DA 40 NG Airplane Maintenance Manual (1765 pages)

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Scheduled Servicing

Table of Contents

Table of Contents

Maintenance Practices

Electrical Power/Maintenance Practices

Table of Contents

Table of Contents

Fuel Storage System/Maintenance Practices

Table of Contents

Maintenance Practices

Table of Contents

Table of Contents

Table of Contents

Table of Contents

Maintenance Practices

Maintenance Practices/Maintenance Practices

Table of Contents

Maintenance Practices/Maintenance Practices

Maintenance Practices

Diamond Aircraft DA 40 NG Airplane Flight Manual (326 pages)

Table of Contents

General

Operating Limitations

Emergency Procedures

A Normal Operating Procedures

B Abnormal Operating Procedures

Performance

Mass and Balance / Equipment List

Description of the Airplane and Its Systems

Airplane Handling, Care and Maintenance

Diamond Aircraft DA 40 NG Manual (12 pages)

Table of Contents

Related Products

Diamond Aircraft Categories