PROBLEMS? DO NOT RETURN TO STORE! CALL US AT TABLE OF CONTENTS Introduction ......................3 Laws & Regulations ....................4 Maintenance Requirements ................4 Safety .......................... 5 Getting Started: Assembling & Breaking In The Mini Bike ...... 7 Basic Operation: Starting, Riding, Stopping & Storing The Mini Bike ..9 Maintenance Procedures ...................
If you ever have questions about servicing or maintaining your mini bike, do not hesitate to reach out to Monster Moto customer service for help. Our goal is to provide you with a seamless ownership experience! When contacting Monster Moto customer service, please have your vehicle identification number (VIN) and engine number handy to help us best assist you.
Laws vary by jurisdiction. Monster Moto has no responsibility or liability for the costs to comply with all applicable laws and regulations or for mini bike damage or human injury resulting from an owner or operator’s failure to follow all relevant...
855-833-6483 OR EMAIL US AT INFO@MONSTERMOTO.COM! SAFETY The MM-B80 mini bike has the potential to cause serious injury or death. Although the risks associated with riding a mini bike can never be eliminated completely, following all of the instructions contained in this manual will reduce the risk of harm to the operator and others.
Page 7
Never modify the mini bike or attach after-market accessories. Modifications and after-market accessories reduce the rider’s ability to control and ride the mini bike safely. Monster Moto is not liable for any damage or injury caused by any after-market accessory.
855-833-6483 OR EMAIL US AT INFO@MONSTERMOTO.COM! GETTING STARTED: ASSEMBLING & BREAKING IN THE MINI BIKE After the mini bike has been removed from the cardboard shipping box, a protective metal frame will be exposed. REMOVING THE PROTECTIVE METAL FRAME 1. Unscrew the two handlebar bolts holding the mini bike to the metal frame. 2.
Page 9
PROBLEMS? DO NOT RETURN TO STORE! CALL US AT ATTACHING THE HANDLEBARS 1. Park your mini bike on a firm, level surface. 2. Locate the handlebar assembly hardware, which was included in the mini bike parts bag. TWO TOP RISERS FOUR BOLTS (SLIGHTLY RAISED ON TOP) TWO BOTTOM RISERS...
855-833-6483 OR EMAIL US AT INFO@MONSTERMOTO.COM! BASIC OPERATION: STARTING, RIDING, STOPPING & STORING THE MINI BIKE CHOKE LEVER (LEFT IS RUN/RIGHT IS START) FUEL VALVE LEVER VEHICLE IDENTIFICATION (LEFT IS OFF/RIGHT IS ON) NUMBER (ETCHED INTO METAL PLATE ON BOTTOM OF MINI BIKE) ENGINE NUMBER (ETCHED INTO OIL TANK) PULL STARTER CORD...
Page 11
Do not ride your mini bike if it is not in operating condition. Refer to the Troubleshooting section of this manual or call Monster Moto customer service to remedy any problems you find.
Page 12
855-833-6483 OR EMAIL US AT INFO@MONSTERMOTO.COM! RIDING YOUR MINI BIKE » To Go: The speed of the mini bike is controlled by the throttle. Twisting the throttle towards the rider increases the speed of the mini bike and releasing pressure from the throttle causes the mini bike to gradually slow down until it comes to a stop.
PROBLEMS? DO NOT RETURN TO STORE! CALL US AT MAINTENANCE PROCEDURES FUEL 1. CARBURETOR SEDIMENT CUP 2. CARBURETOR DRAIN SCREW FUEL TANK FUEL CAP 1. FUEL FILTER (THE SCREW ON THE 2. FUEL FILTER CLAMP FUEL CAP VENT SIDE OF THE CUP, NOT 3.
Page 14
855-833-6483 OR EMAIL US AT INFO@MONSTERMOTO.COM! REMOVING SEDIMENT FROM THE FUEL SYSTEM Avoid getting dust, dirt, water, and/or debris in the fuel tank. If the fuel tank has become contaminated, it will need to be drained and new fuel will need to be added.
Page 15
PROBLEMS? DO NOT RETURN TO STORE! CALL US AT CLEARING A FLOODED ENGINE If the engine fails to start after repeated attempts, it may be flooded with ex- cess fuel. Follow the steps below to clear a flooded engine: 1. Park the mini bike on a firm, level surface and turn the engine stop switch to the “off”...
855-833-6483 OR EMAIL US AT INFO@MONSTERMOTO.COM! ENGINE OIL Oil Filler Cap Dipstick Upper Mark OIL FILLER CAP & OIL DRAIN BOLT Lower Mark OIL FILLER HOLE & OIL TANK CHECKING & ADDING ENGINE OIL Before each ride, check the mini bike’s engine oil level and add oil if necessary. The Society of Automotive Engineers (SAE) 10W-30 oil is recommended for most climates.
Page 17
The frequency in which you will need to change the oil depends on how often you ride and the riding conditions; however, Monster Moto recommends changing the oil at least every six months and potentially more if you ride frequently in dusty environments.
855-833-6483 OR EMAIL US AT INFO@MONSTERMOTO.COM! AIR FILTER AIR FILTER AIR FILTER AIR FILTER COVER HOUSING TAB (AIR FILTER COVER HAS BEEN REMOVED) CLEANING THE AIR FILTER The mini bike’s air filter must be clean in order for the mini bike to operate properly. Inspect the air filter in your mini bike as part of your regular maintenance routine and clean it whenever it appears dirty.
PROBLEMS? DO NOT RETURN TO STORE! CALL US AT BRAKES ADJUSTING NUT BRAKE MECHANISM ADJUSTING THE BRAKES If you cannot stop your mini bike properly, you will most likely need to adjust its rear disc brake. You will also need to adjust the brake as part of your regular maintenance routine, as regular use of the mini bike will cause the brake to loosen over time.
855-833-6483 or email us at info@monstermoto.com to purchase a replacement tire. Monster Moto will also help direct you to an Authorized Monster Moto Service Center who can install the replacement tire for you.
6. Tighten the axle nut and the chain tensioner adjustment nut. If the chain tensioner is as tight as possible and slack still remains, the chain is worn beyond its service limit. Contact Monster Moto customer service for assistance or take your mini bike to an Authorized Monster...
You may clean your mini bike using water, mild neutral detergents, and/or mild spray cleaners. Avoid using products that contain harsh detergents or chemical solvents that can damage the mini bike’s metal, paint, and plastic. Monster Moto recommends that you use a garden hose and a soft sponge to wash your mini bike, as high pressure washers and harsh brushes can damage certain parts of the mini bike.
If you are having problems with your mini bike, please reference the troubleshoot- ing steps below. If you have completed all of the troubleshooting steps and your mini bike is still not running properly, contact Monster Moto at 855-833-6483 or info@monstermoto.com or take your mini bike to an Authorized Monster Moto Service Center.
Page 24
These problems need to be fixed by an Authorized Monster Moto Service Center. Do not continue to operate the mini bike. Take it to an Authorized Monster Moto Service Center for repair.
At that time, the returned part(s) or product component(s) become the property of Monster Moto and will not be returned. This product is also cov- ered by an Emissions Control System Warranty which is separate from and in addition to this warranty.
855-833-6483 OR EMAIL US AT INFO@MONSTERMOTO.COM! by the Environmental Protection Agency, Monster Moto makes no other warranty of any kind, express or implied. All implied warranties of merchantability and fitness for a particular purpose which exceed the obligations and time limits stated in this warranty are disclaimed and excluded from this warranty.
PROBLEMS? DO NOT RETURN TO STORE! CALL US AT SPECIFICATIONS RECOMMENDATIONS Recommended Age 16 + Recommended Fuel Type Unleaded 87 Octane Gasoline Recommended Engine Oil Type SAE 10W-30 SPECIFICATIONS Engine Displacement 79.8 cc Strokes per Cycle Four Strokes per Cycle Cylinder Head Configuration Overhead Valve (OHV) Transmission...
855-833-6483 OR EMAIL US AT INFO@MONSTERMOTO.COM! MINI BIKE MM-B80 PRODUCT REGISTRATION Monster Moto 1001 South Jupiter Road Garland, TX 75042 855-833-6483 info@monstermoto.com www.monstermoto.com Please help us serve you better by registering your new mini bike. You may register your product by calling us at 855-833-6483, by emailing us at info@monstermoto.com, or by mailing the registration form below to us at...
Page 29
IF YOU HAVE PROBLEMS, DO NOT RETURN TO STORE! CONTACT MONSTER MOTO AT 855-833-6483 INFO@MONSTERMOTO.COM! Monster Moto will handle all service, warranty, and return arrangements. Monster Moto 1001 South Jupiter Road Garland, TX 75042 855-833-6483 info@monstermoto.com www.monstermoto.com...
Need help?
Do you have a question about the MM-B80 Mini Bike and is the answer not in the manual?
Questions and answers