Download  Print this page

Advertisement

1
SERVICE MANUAL
Level 1&2
Nokia N9
RM-696
Transceiver characteristics
Band
EGSM 850/900/1800/1900 MHz
WCDMA HSPA 850/900/1700/1900/2100 MHz
Display
3.9" OLED display, 16:9 widescreen aspect ratio,
854 x 480 resolution
Camera
8 Mpx Carl Zeiss autofocus camera with CMOS
sensor, Dual LED flash, 1280x720 30fps HD video
recording
Operating System
Meego
Connections:
WLAN 802.11 a/b/g/n
NFC (Near Field Communication)
Micro USB 2.0
Bluetooth 2.1
Stereo audio out via 3.5mm AV connector
Transceiver with BV-5JW battery pack
Talk time
GSM: Up to 11 hours
WCDMA: Up to 7 hours
Note:
Talk times are dependent on network parameters
and phone settings
Conf idential | Copyright © 2011 Nokia | A ll rights reserved
Nokia N9 (RM-696)
L1L2 Service Manual
Standby
GSM: Up to 380 hours
WCDMA: Up to 450 hours
Version 5.0

Advertisement

   Also See for Nokia N9

   Related Manuals for Nokia N9

   Summary of Contents for Nokia N9

  • Page 1

    GSM: Up to 380 hours WCDMA: Up to 7 hours WCDMA: Up to 450 hours Note: Talk times are dependent on network parameters and phone settings Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 2: Table Of Contents

    BATTERY INFORMATION..............................8 EXPLODED VIEW ................................. 9 SERVICE DEVICES ................................10 SOFTWARE UPDATE................................11 DISASSEMBLY INSTRUCTIONS ............................12 10. ASSEMBLY HINTS................................21 11. SOLDER COMPONENTS ..............................23 Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 3

    FRONT CAMERA FLEX The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to carry out service to NOKIA products. This Service Manual is to be used only by authorized NOKIA service suppliers, and the content of it is confidential.

  • Page 4: Copyright

    Nokia operates a policy of continuous development. Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice. Under no circumstances shall Nokia be responsible for any loss of data or income or any special, incidental, consequential or indirect damages howsoever caused.

  • Page 5: Warnings And Cautions

    3. Use only approved components as specified in the parts list. 4. Ensure all components, modules screws and insulators are correctly re–fitted after servicing and alignment. 5. Ensure all cables and wires are repositioned correctly Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 6: Esd Protection

    ESD protected spare part packages MUST NOT be opened/closed out of an ESD Protected Area. For more information and local requirements about ESD protection and ESD Protected Area, contact your local Nokia After Market Services representative. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 7: Care And Maintenance

    All of the above suggestions apply equally to the product, battery, charger or any accessory. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 8: Battery Information

    Batteries’ performance is particularly limited in temperatures well below freezing. Do not dispose batteries in a fire! Dispose of batteries according to local regulations (e.g. recycling). Do not dispose as household waste. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 9: Exploded View

    AV FLEX I0021 MAIN FLEX USB DOOR NFC ANTENNA I0023 I0001 I0024 Only available Not reuseable Repair/swap Ver. 4.0 as assembly after removal only in level 3 Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 10: Service Devices

    For more information, refer to the Service Bulletin (SB-011) on Nokia Online. Supplier or manufacturer contacts for tool re-order can be found in “Recommended service equipment” document on Nokia Online. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 11: Software Update

    To use the FLS-5 Flash Dongle, follow the user guide inside the sales package. Please check always for the latest version of flash software, which is available on Nokia Online. Conf idential | Copyright © 2011 Nokia | A ll rights reserved...

  • Page 12: Disassembly Instructions

    5) Remove the USB DOOR by pulling it to direction 6) Open the SIM DOOR by pulling the release notch to shown. direction shown. Pull out and remove the SIM DOOR. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 13

    12) Use the SRT-6 to open the left side of the DISPLAY between the DISPLAY ASSEMBLY and the PLASTIC ASSEMBLY. BODY. Be careful not to damage the shown flex located halfway the top side. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 14

    17) Use the SS-93 to disconnect the two DISPLAY 18) Remove the DISPLAY ASSEMBLY. ASSEMBLY connectors. Be careful not to damage the connectors or any nearby components. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 15

    CHASSIS. Do not use them again. Discard them. tweezers. 23) Remove the CHASSIS with the tweezers. 24) Use the sharp end of the SS-93 to lift up the BATTERY. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 16

    30) Unscrew the Torx+ size 5 screw. Do not use it with the SS-93. Be careful not to damage the again. Discard it. connector or any nearby components. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 17

    36) Lever out the IHF SPEAKER with the dental tool. the tweezers. Be careful not to damage yourself or any nearby components with the sharp end of the dental tool. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 18

    40) Remove the FRONT CAMERA FLEX. Do not use it again. Discard it. 41) Insert the tweezers to the EARPIECE BOOT as 42) Remove the EARPIECE BOOT. Do not use it again. shown. Discard it. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 19

    47) Lift up and remove the CAMERA MODULE. 48) Lever out the RAPU SHIELDING LID with the SS-93. Be careful not to damage any nearby components. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 20

    53) Remove the NFC SHIELDING LID with the 54) The Nokia N9 disassembly is now complete. tweezers. Do not use it again. Discard it. -END OF DISASSEMBLY- Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 21: Assembly Hints

    5) Tighten the six TORX+ size 4 screws to the torque 6) Tighten the three TORX+ size 4 screws to the of 15 Ncm. torque of 15 Ncm. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 22

    Nokia N9 (RM-696) L1L2 Service Manual 7) Tighten the two TORX+ size 4 screws to the torque of 8 Ncm. Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

  • Page 23: Solder Components

    11. SOLDER COMPONENTS X1460 F1450 X6306 X7602 F3300 X1300 X6305 V1370 BOTTOM X1471 X1470 X1451 X6301 X6302 X6204 X6501 X6500 V1471 X6304 X7601 X7600 Ver. 1.0 Conf idential | Copyright © 2011 Nokia | A ll rights reserved Version 5.0...

Comments to this Manuals

Symbols: 0
Latest comments: