Viking RDECU2065BSB Service Manual
  1. Manuals
  2. Brands
  3. Viking Manuals
  4. Cooktop
  5. RDECU2065BSB
  6. Service manual

Viking RDECU2065BSB Service Manual

D3 series electric cooktop
Hide thumbs Also See for RDECU2065BSB:
Table of Contents

Advertisement

Quick Links

Download this manual See also: Use and Care Manual, Installation Manual
Service
Manual
This manual is to be used by qualified appliance technicians only. Viking
does not assume any responsibility for property damage or personal
injury for improper service procedures done by an unqualified person.
D3 Series
Electric Cooktop
Preferred Service
This Base Manual covers general and
specific information including, but not
limited to the following models:
RDECU2065BSB
RDECU2665BSB
®
SMC-0025
MAY 2012

Advertisement

Table of Contents
loading

Related Manuals for Viking RDECU2065BSB

Summary of Contents for Viking RDECU2065BSB

  • Page 1 Service ® Preferred Service Manual This manual is to be used by qualified appliance technicians only. Viking does not assume any responsibility for property damage or personal injury for improper service procedures done by an unqualified person. D3 Series This Base Manual covers general and...

  • Page 2: Table Of Contents

    Safety Information ............ 3 Warnings ..............4 Electrical Requirements ........... 4 Tip Over Hazard ............4 General Information ............5 RDECU2065BSB 30" Cooktop ........ 6 RDECU2665BSB 36" Cooktop ........ 6 Disassembly ..............7 Smooth Top Removal ..........7 Infinite Switch Removal ..........8 Element Removal .............

  • Page 3: Important Information

    Always read and obey all safety messages. This is the safety alert symbol. CAUTION VIKING will not be responsible for any injury or property damage from improper service procedures. This symbol alerts you to hazards that can kill If performing service on your own product, you must or hurt you and others.

  • Page 4: Warnings

    Canadian Electrical Code C22.1-1998 and C22.2 No. 0-M91 (or latest edition), and all local codes and ordinances. The cooktop is provided with a 240 Volt, 3 wire conduit that must be hardwired in accordance with local codes. ©2012 Viking Preferred Service...

  • Page 5: General Information

    UL 856 et les electrique domestiques, GREENWOOD, MISSISSIPPI 38930 CAN/USA C22.2 No.1 M-89 VOLTAGE WATTS AMPS RDECU2065BSB MODEL: 240 VAC 60 Hz 9.6 KW MAX 40 051012C00036178 SERIAL: 208 VAC 60 Hz 7.2 KW MAX 34.7 PEO20061 ©2012 Viking Preferred Service...

  • Page 6: Rdecu2065Bsb 30" Cooktop

    General Information RDECU2065BSB 30" Cooktop 1. 6-1/2" 1200 watt element 2. 11-7/8" 1100/1000/1100 watt element 3. 8-1/2" 2000/1000 watt element 4. Left front element control knob 5. Left rear element control knob 6. Center element control knob 7. Right rear element control knob 8.

  • Page 7: Disassembly

    6. Lift front of glass top up and slide power lamp off of lens cover, push all switches down and out of glass top, lift glass top assembly off of unit and place in a secure place to prevent damage to top and customer's property. ©2012 Viking Preferred Service...

  • Page 8: Infinite Switch Removal

    4. Verify new element mounting tabs match old element and reattach in the same location in the burner box. Failure to position new element in same alignment as old element could result in poor performance. ©2012 Viking Preferred Service...

  • Page 9: Terminal Board Removal

    Do not put the terminal on top the two outside screws shown with arrows of the plastic terminal block. below. 3. Remove wires one at a time and transfer to new terminal block as they are removed from the faulty terminal block. ©2012 Viking Preferred Service...

  • Page 10: Troubleshooting

    Discharge capacitor through a resistor before attempting to service. Ensure all ground wires are connected before certifying unit as repaired and/or operational. Single Infinite Switch Connections Low 6% High 100% Detented Detented PILOT 270° Power PILOT Indicator 4(1a) 2(2a) (2b)S (1b)H ©2012 Viking Preferred Service...

  • Page 11: Single Infinite Switch Voltage Measurements

    L2 when 120 vac when Red/Black thermostat thermostat closes to closes to neutral element Pilot L2 to Power 120 vac when Red/White Light when thermostat thermostat closes to neutral closes ©2012 Viking Preferred Service...

  • Page 12: Dual Infinite Switch Connections

    Ensure all ground wires are connected before certifying unit as repaired and/or operational. High 100% High 100% Detented Detented LOAD LOAD 1 only 1 & 2 122° 122° Low 6% Low 6% Detented Detented Dual Infinite Switch Connections Indicator Power 1b (H) 2b (S) ©2012 Viking Preferred Service...

  • Page 13: Dual Infinite Switch Voltage Measurements

    L2 when 120 vac when Blue/Black thermostat thermostat closes to closes to neutral element L2 to Power 120 vac when Red/White Light when thermostat thermostat closes to neutral closes ©2012 Viking Preferred Service...

  • Page 14: Triple Infinite Switch Connections

    Ensure all ground wires are connected before certifying unit as repaired and/or operational. Triple Infinite Switch Connections High 100% Low 6% Detented Detented LOAD LOAD 1 1+2+3 Low 6% High 100% Detented LOAD 1+2 Detented High 100% Low 6% Detented Detented Aux. Switch Energy - Regulator Indicator Power ©2012 Viking Preferred Service...

  • Page 15: Triple Infinite Switch Voltage Measurements

    Aux Switch 4 120 vac when White/Black L2 when thermostat thermostat closes to neutral closes to element Aux Switch 4b L2 when 120 vac when Blue/Black thermostat Aux thermostat Aux Switch closes to Switch closes to element neutral ©2012 Viking Preferred Service...

  • Page 16: Schematic

    Schematic Schematic ©2012 Viking Preferred Service...

  • Page 17: Wiring Diagram

    Wiring Diagrams Wiring Diagram ©2012 Viking Preferred Service...

This manual is also suitable for:

Rdecu2665bsb

Table of Contents